Documente Academic
Documente Profesional
Documente Cultură
Table of Contents
Summary Information: .................................................................................................................................. 2
How to install Deep Sea Electronics PLC Software to monitor Genset? ....................................................... 3
Getting started with DSE Suit........................................................................................................................ 6
Login Credentials Info? ................................................................................................................................. 8
How to view Power Informations? .............................................................................................................. 9
How to view Logs? ...................................................................................................................................... 10
How to Start/Stop Remotely? ..................................................................................................................... 10
How to access DSE Installer Setup from NAS? ............................................................................................ 11
Summary Information:
Genset IP Address: 10.10.8.33
Genset Manufacturer: Orient
Genset Module: Deep Sea Electronics
Vendor: Interactive Group
Read the license agreement for the Virtual Serial Port software supplied by Tibbo Technology Inc. Click I
AGREE to continue.
The
driver
installs...
Select REBOOT NOW and click FINISH to reboot your computer and complete the installation process.
You cannot use the DSE860/5 connection until the PC has been rebooted.
Goto
connect via ->
Tibbo Virtual Serial Port
Serial Setting ->
Baud Rate : 9600
Tick Enable 485
Tick x86 Support
After Selecting above options click Read Configuration from a module. It will read configuration from
the module.
On Left pane Click the Scada and it will connect to the generator and shows all the details about
genetaor e.g OIL gauge, Power, Voltages , Current & Event logs etc..
This is the Main display of generator and it shows the current status of the generator.
Username: mepco
Password: mepco
Note: Mepco is a limited user to gain admin access kindly contact
AD (MIS)/Data Center In charge.
Click ok after entering Password to it, go to startup screen then
follow the steps mentioned in getting started with DSE Suit
Power information can be viewed from the 7310 Scada -> generator -> Power
It will view all the logs and can be export to excel and pdf files.
10
11
Double click on ATS configuration-suite-installer and the suite will start installation.
12