Documente Academic
Documente Profesional
Documente Cultură
Internal
Score: _________
B)
All
out
door
microwave
equipment
C) Split mount microwave equipment
D) All above
2. The antenna aligning means the aligning of the ( D ) between two sites.
A) Rear lobe to main lobe
B) decode
D) Modulation
B) 180 m
C) 300 m
D) 360 m
6. The loss between the active (main) interface and standby interface is ( C ).
A) the same
D) stochastic
B) 3
C) 4
D) 5
B) 2
C) 3
D) 4
9. Two IF1A boards in the 1+1 SD, can be installed in IDU 620 slot ( D ).
A) 7 and 8
10. There are ( D
B) 7 and 6
C) 4 and 5
D) 5 and 7
A) 3
B) 5
Internal
C) 6
D) 7
B) 16QAM
C) 128QAM
D) ASK
12. In the OptiX RTN 600, one ODU can support the capacity ( E ) .
A) 4 E1s
B) 8 E1s
C) 16 E1s
D) one STM-1
E) all of them
B) Hi sites
C) Lo sites
16. The ODU interface is like
D) never mind
, it means its polarity is ( D ).
A) Horizontal
B) Vertical
C) round
B) SCC board
C) IF1A board
D) SDH/PDH board
B) SCC board
C) IF1A board
D) SDH/PDH board
B) 1+1 SD
C) ATPC
B) admin/password
C) admin/T2000
D) admin/root
Internal
21. The default user name and password for logining RTN equipment is ( B ).
A) admin/t2000
B) root / password
C) admin/T2000
D) root / T2000
22. When connect laptop to the new IDUthe IP segment of laptop should be ( B ).
A) 192.168. ***.***
B) 129.9. ***.***
C) 172.168. ***.***
D) 10.0. ***.***
B) SCC
C) PXC
D) IF1A
B) 1+1 FD+SD
C) 1+1 SD
D) 1+1 FD
C) RF signal
D) ODU DC power
26. The MANT indicator on the SCC board is on, it means ( ABD ) .
A) Loopback has been done
27. For a new station, the sequence of 1+1HSB or 1+1SD configuration should be ( BEADC ).
A) set parameters of Active IF board and ODUunmute Active ODU
B) create logic boards in the slot layout window
C) create cross connection to configure the service
D) Unmute Standby ODU manually
E) Create IF 1+1 protectionspecify which IF board is working boardwhich one
is protection board
28. Replace an ODU, it should ( ABCD ).
A) Make sure the type of the spare ODU is consistent with that of the ODU to be
replaced
B) Keep the polarity of the new ODU the same as before
C) Carry out the waterproof measures for the IF interface of the ODU
D) Turn off the ODU-PWR switch on the panel of the IF board
Internal
34. RTN 600 is SDH/PDH hybrid equipment, we can modify working mode of IF board
to determine SDH or PDH signal can be transmitted in the microwave link. ( T