Documente Academic
Documente Profesional
Documente Cultură
The turn lamp arrows in the instrument cluster flash showing the direction indicated by the turn signals. A
sudden increase in the rate of flashing indicates failure of one or more of the lamp bulbs. Have them
replaced as soon as possible.
8.12.2 Airbag Warning Lamp
The airbag warning lamp in the instrument cluster illuminates when the ignition is switched ON and goes
OFF in about 3 seconds. If the lamp remains ON continuously or flashs intermittently, contact an
authorized Mahindra dealer immediately.
The front fog lamp telltale indicates the status of the front fog lamp. The front fog lamp can be switched
ON only when the parking lamp is ON.
8.12.4 Glow Plug/Electronic Fault Lamp
Glow plug indicator illuminates when the ignition is turned ON. It automatically goes OFF when the glow
plug reaches the required temperature. The electronic fault lamp illuminates when there is a fault in the
electrical or electronic circuits of the vehicle. Contact an Authorized Mahindra Dealer if the glow plug
lamp does not illuminate with ignition ON or illuminates while driving.
8.12.5 Engine Immobilizer Lamp
The Engine Immobilizer lamp flashes intermittently (few seconds frequency) once the ignition is switched
OFF. Fast blinking indicates a malfunction in the engine immobilizer system or when a wrong key is
inserted in the ignition. Contact an Authorized Mahindra Dealer immediately.
8.12.6 High Engine Coolant Temperature Warning Lamp
The high engine coolant temperature warning lamp flashes when the coolant temperature is above 108C.
Do not continue driving the vehicle with an overheated engine. This may result in engine damage, which
will not be covered by the warranty.
8.12.7 Water-in-Fuel Warning Lamp
The water-in-fuel warning lamp illuminates when the accumulation of water in the fuel filter reaches the
maximum permissible limit. The fuel filter needs to be drained. Contact an authorised Mahindra dealer.
Do not continue driving the vehicle with the water-in-fuel warning lamp ON. This may result in fuel
pump/other fuel system component damage, which will not be covered by the limited warranty.
8.12.8 Low Engine Oil Pressure Warning Lamp
The low engine oil pressure warning lamp illuminates when the ignition switch is turned ON goes out as
soon as the engine is started. If the lamp remains ON even after starting the engine, or illuminates while
driving, stop immediately, check the oil level after 2-3 minutes. If low, add engine oil to the MAX level
and check status. If problem persists, contact an Authorized Mahindra Dealer immediately.
Operating the vehicle with the low oil pressure warning lamp ON could cause sudden unexpected engine
failure and loss of vehicle control, resulting in an accident, personal injury.
Do not run the engine with low oil pressure warning indicator ON. This may result in engine damage, which will not be covered by
the limited warranty.
The rear windshield de-mister lamp illuminates to indicates the status of the de-mister. Contact an
authorised Mahindra dealer if the lamp fails to illuminate.
8.12.10 Parking Brake Lamp
The lamp illuminates when: Parking brake is engaged or Brake fluid level is low
If the lamp illuminates while driving, do the following:
Check if the parking brake is engaged. If yes, disengage it
Check if brake fluid level is low. If yes, top-up brake fluid (DOT 4) to the required level
If the brake lamp still continues to illuminate, immediately get the vehicle checked at an Authorized
Mahindra Dealer.
Clean the top of the brake fluid reservoir before removing the cap. Make sure no dirt, impurities or other
items fall into the reservoir. Do not leave the cap off for more than a few minutes. Any contaminants,
impurities or moisture in the brake fluid can affect brake operation, resulting in an accident.
If the brake warning lamp comes ON while driving, the brake system might not be working properly. The pedal might be harder to
operate or might go closer to the floor and it can take longer to stop. Pull off the road carefully and stop the vehicle. Contact the
nearest Authorized Mahindra Dealer for checks or repairs.
Driving the vehicle with the brake warning lamp ON or when you suspect brake trouble is very dangerous and could result in serious
injuries. Contact an Authorized Mahindra Dealer for checks or repairs.
The OBD check lamp illuminates when the ignition is switched ON and remains ON till the engine is
started indicating normal status. If the lamp remains ON, it indicates a potential engine malfunction.
There may be a malfunction in:
The low fuel warning lamp illuminates when the ignition is switched ON and switches OFF after few
seconds. When the fuel level in the fuel tank falls below the reserve limit, the low fuel warning lamp
illuminates.
Refuel sufficiently and the lamp switches OFF. If the lamp continues to remain ON, even after refueling,
contact an Authorized Mahindra Dealer.
8.12.13 Head Lamp Low Beam Lamp
The head lamp low beam telltale illuminates whenever the head lamps are switched ON to low beam.
8.12.14 Head Lamp High Beam Lamp
The head lamp high beam telltale illuminates whenever the head lamps are switched ON to high beam or
when the head lamp flash is used.
8.12.15 Anti-lock Brake System (ABS) Malfunction Lamp
The ABS malfunction lamp illuminates when the ignition is switched ON and goes OFF after about 3
seconds. If the ABS malfunction lamp continues to remain ON or illuminates while driving, ABS will not
operate. But the brake system will still operate conventionally. In this condition, the wheels can lock during
severe braking. Have the vehicle checked by an authorized Mahindra dealer as soon as possible.
8.12.16 Battery Charging System Warning Lamp
The battery charging system warning lamp illuminates when the battery is not being charged or when there
is a malfunction in the alternator.
This lamp illuminates when the ignition is switched ON and goes out as soon as the engine is started. If the
lamp continues to remain ON even after starting the engine, it is an indication that the battery is not being
charged or there is a malfunction in the alternator. Check the alternator drive belt for looseness/breakage. If
the drive belt is okay, switch OFF all unnecessary electrical equipment and recheck. Contact an Authorized
Mahindra Dealer for further assistance.
8.12.17 Door Ajar Warning Lamp
The door ajar warning lamp illuminates and the buzzer chimes 3 times when any of the doors including the
hood and back door are open during ignition ON. The lamp goes OFF when all the doors are closed
properly.