Documente Academic
Documente Profesional
Documente Cultură
Answers to Questions:
1. What is the purpose of the liquid limit test?
The purpose of the liquid limit test is to determine the stress history
and general properties of the soil met with construction; with the help of the
liquid limit, the compression index can be estimated which would be helpful
in the settlement analysis.
2. How do you define liquid limit?
Liquid limit is the arbitrary limit of water content at which the soil is
just about to pass from plastic state into the liquid state. At liquid limit,
the soil possesses a small value of shear strength, losing its ability to
flow as a liquid. The gist is that the liquid limit is the minimum
moisture content at which the soil tends to flow as a liquid.
3. What is the main difference between wet specimen and dry specimen
preparation methods for the liquid limit test?
When conducting the wet specimen preparation method for liquid limit
test, one must determine by visual or manual methods that the soil
sample has little or no material retained on the # 40 sieve. If this is the
case, prepare 150-200g of material by mixing thoroughly with distilled
water. Adjusting the water content of the material would bring the soil
to consistency which would require about 25-35 blows of the liquid
limit device to close the groove made by the grooving tool.
When conducting the dry specimen preparation method for liquid limit
test, one must first dry the soil sample passing through the # 40 sieve
at room temperature or in an oven dry not exceeding a temperature of
60deg C, until the soil clods pulverize readily. Pulverize the material
using mortar and pestle or in some other way that does not cause a
breakdown of individual particles. The procedure must be stopped once
most of the fine material has been disaggregated and the material
retained on the 425-m sieve consists of individual particles. Adjusting
the water content of the material would bring the soil to consistency
which would require about 20-30 blows of the liquid limit device to
close the groove made by the grooving tool.
4. Why do you use a special cup and cranking device to determine the liquid
limit? Why not use another shape for the cup?
A special cup and cranking device is used to determine the liquid limit
because those are the standards of the ASTM and every test must
comply with the ASTM standards (ASTM D4318). The cup can be
adjusted for a 10mm fall and can be raised and dropped. Not only that
but, the shape of the cup is curved in a way that the plasticity of moist
soil can easily be seen.
DISCUSSION