Documente Academic
Documente Profesional
Documente Cultură
2007 Porsche Cars North America, Inc. All Rights Reserved. Reproduction or translation in whole or in part is not permitted
without written authorization from publisher. AfterSales Training Publications
Dr. Ing. h.c. F. Porsche AG is the owner of numerous trademarks, both registered and unregistered, including without limitation
the Porsche Crest, Porsche, Boxster, Carrera, Cayenne, CaymanTM, Tiptronic, VarioCam, PCM, 911, 4S, and
the model numbers and distinctive shapes of Porsches automobiles such as, the federally registered 911 automobile. The third
party trademarks contained herein are the properties of their respective owners. Porsche Cars North America, Inc., believes the
specifications to be correct at the time of printing. However, specifications, standard equipment and options are subject to
change without notice.
Part Number - PNA QR1 002
Edition - 4/07
H51-030
Controls
1 Ignition lock/steering lock
2 Turn signals/high beam/
headlight flasher stalk
3 Hands-free microphone for
telephone
4 Horn
5 Wiper/washer stalk, rear
window wiper
6 Button for seat heating, left
7 Interior temperature
sensor/GPS antenna
8 Stopwatch
9 Emergency flasher switch
10 Central locking button,
readiness display for alarm
system
11 Porsche Communication
Management (PCM)
Ignition lock
12 Button for seat heating,
right
13 Cupholder
14 Light switch
15 Operating lever for
on-board computer
16 Locking lever for
steering-wheel adjustment
17 Operating lever for
automatic speed control
18 Operating panel for air
conditioning
19 Buttons for rear spoiler,
Porsche Active Suspension
Management (PASM), Sport
mode, Porsche Stability
Management (PSM),
sports exhaust system
0
1
2
3
4
5
A
Parking light
Switch ignition off.
Press lever up or down.
Intermittent operation of
rear window wiper
Push wiper lever forward.
Welcome Home
Lighting
0
1
2
3
Side lights
Initial position
Ignition on
Start engine
Ignition off
On-board computer
10 Fuel:
Level gauge, warning
light
11 Engine oil pressure
gauge
12 Adjustment button for
instrument illumination
and trip counter
13 Odometer and daily trip
mileage display
14 Automatic speed control
indicator light
15 Light sensor for
instrument illumination
16 Airbag warning light
17 Emission control warning
light (Check Engine)
To confirm selection:
Push the lever forward 1.
To move back several
selection levels:
Pull lever back 2
or
Z
Select arrow in the
on-board computer
display and push lever
forward 1.
Off
Rain sensor
Slow
Fast
One-touch operation
Spray and wipe
Headlight washer system
Light switch
Windshield wiper/
washer system
Page 1
Windshield wiper/
washer system
parking light/
headlight flasher stalk
Lifting/sliding roof
Targa
A Opening
B Lowering, closing
C Lifting
Convertible Top
HKA51-004
H51-030
on lock
tial position
nition on
art engine
nition off
e vehicle key
bounds to the initial
sition from every
Manually adjustable seat
ition lock position.
Seat height
Fore and aft
Seat inclination
Backrest angle
Lumbar support
(pelvis and spinal column support)
F Backrest side bolster adjustment
(sports seat only)
G Seat cushion side bolster adjustment
(sports seat only)
H Fold backrest forward and back up
Entry
Safe and convenient starting
Canada: Display in km / C
H51-061
Helpful tips
Remote control standby
The remote control standby function
switches off after 7 days if the vehicle is
not unlocked or started within this time.
In this case, unlock the drivers door
at the lock.
Leave the door closed in order to prevent
the alarm system from being triggered.
Press button 1 on the remote control.
The remote control is activated again.
Immobilizer
If you leave the ignition on for more than
two minutes without starting the engine,
the immobilizer will be reactivated.
Deactivating:
Switch ignition off (position 3).
Start the engine.
Emergency operation
The doors, the luggage compartment lid,
the filler flap, the lifting/sliding roof, sliding
glass roof (Targa) and the convertible top
can be operated manually in the event of
a technical fault.
Tools, etc.
A tool kit with towing lug and tire sealant
can be found in the tool box in the luggage
compartment.
Servicing
The addresses and telephone numbers
of Porsche dealerships are shown in the
dealer directory.
Additional information
Convertible top
A Quick Reference Guide can be found
on the reverse of the drivers sun visor.
P
Page 2
911QuickCarrera
Reference Guide
Tiptronic S
Buttons in the
center console
Speed control
A Switching off/on
1 +SPEED/SET
(accelerate/store)
2 SPEED (decelerate)
3 OFF (interrupt)
4 RESUME
The speed control maintains
any selected speed in the
range of 15 145 mph
(30 240 km/h).
Parking assistant
Engage reverse gear.
A brief signal tone
sounds.
A detected obstacle is signalled by an intermittent
tone. The intervals decrease
as the obstacle is approached.
A continuous tone sounds
when the distance becomes
less than one foot.
Tiptronic S is a 5-speed
automatic transmission:
D: Automatic gear-changing
M: Manual gear-changing
using rocker switches on
the steering wheel
You can change between
selector lever position D and
M as you wish while driving.
Seat heating
Switching on:
High heating power
Press button.
Low heating power
Press button again.
Switching off:
Press button.
Pit stop
Switch off windshield wipers (rain sensor).
Unscrew external antenna.
Washer fluid
Capacity
Approx. 2.6 quarts (2.5 liters) without headlight washer.
Approx. 6.3 quarts (6.0 liters) with headlight washer.
Engine data
911 Carrera
911 Carrera 4
911 Targa 4
Engine type
M 96/05
Type
Horizontally opposed engine,
liquid cooled
Number of cylinders
6
Cubic capacity
219.4 cu. in. (3596 cm3)
Net-horsepower, SAE J 1349 325 hp (239 kW)
at crankshaft speed
6800 rpm
911 Carrera S
911 Carrera 4S
911 Targa 4S
M 97/01
Horizontally opposed engine,
liquid cooled
6
233.3 cu. in. (3824 cm3)
355 hp (261 kW)
6600 rpm
Car care
Please observe the following:
High-pressure cleaning equipment may damage the convertible top, tires, logos, emblems,
painted surfaces, the generator and the sensors of the ParkAssist.
Maintain a minimum distance of 21in. (50 cm) and do not point the jet directly onto the
aforementioned components.
Before cleaning in a car wash:
Ask the operator about wheel widths and convertible top and special accessories such as
roof-mounted equipment, external antenna, fixed rear spoiler and highly polished wheels.
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 997 121 07
Page 3
Manually adjustable seat
H51-074
e
re.
Por
Tipt
trad
Por
Dr.
All r
Prin
Notes
Page 4
Notes
Page 5
Boxster
Cockpit(987)
Cockpit
I51-019
I51-019
Controls
1 Light switch
2 Turn signals/headlight
Controls
dimmer/flasher lever
13 Light
switch
Ignition
lock/locking the
2 Turn
signals/headlight
steering
column
lever for
4 dimmer/flasher
Hands-free microphone
3 Ignition
lock/locking the
telephone
column
5 steering
Horn
46 Hands-free
for
Windshield microphone
wiper/
telephone
washer lever
57 Horn
Porsche Communication
6 Windshield
wiper/
Management/Radio
8 washer
Interior lever
temperature sensor,
7 Porsche
Communication
GPS antenna
9 Management/Radio
Emergency flasher switch
8 Interior
sensor,
10
Central temperature
locking button,
GPS
antenna
Readiness
display for alarm
9 Emergency
flasher switch
system
10
locking button,
11 Central
Cupholder
Readiness display for alarm
system
11 Cupholder
Ignition lock
12 Operating lever for
on-board computer
13 Locking lever
12 Operating
lever for
for steering-wheel
on-board
computer
adjustment
13
lever
14 Locking
Operating
lever for
for
steering-wheel
cruise
control
15 adjustment
Control panel for
14 Operating
lever for and
heating, ventilation
cruise
control system
air conditioning
15
for spoiler,
16 Control
Buttonspanel
for rear
heating,
and
Porsche ventilation
Active
air
conditioning
system
Suspension
Management
16 Buttons
rearmode,
spoiler,
(PASM), for
Sport
Porsche
Porsche Active
Stability
Suspension
ManagementManagement
(PSM),
(PASM),
Sport mode,
Sports exhaust
system
Stability
17 Porsche
Seat heating,
left/right
Management (PSM),
Sports exhaust system
17 Seat heating, left/right
Ignition lock
Windshield wiper/
washer system
Windshield wiper/
washer system
0
1
2
03
14
25
3A
4
5
A
Off
Rain sensor
Slow
Off
Fast
Rain
sensoroperation
One-touch
Slow
Spray and wipe
Fast
Headlight washer system
One-touch operation
Spray and wipe
Headlight washer system
Light switch
Light switch
Welcome Home
Lighting
Side lights
Welcome Home
Lighting
Low
beam, high beam
0 Initial position
1 Ignition on
2 Start engine
03 Initial
position
Ignition
off
1 Ignition on
2 The
Startvehicle
enginekey
!
3 rebounds
Ignition offto the initial
position from every
vehicle
! The
ignition
lockkey
position.
rebounds to the initial
position from every
ignition lock position.
Fog light
Side
lights
Pull switch to first
Lowclick.
beam, high beam
Fog
Rearlight
fog light
Pull switch to first
On-board computer
Tiptronic S
Helpful
On-board computer
Tiptronic S
Helpful
Remote
cont
re
d,
e
t
will
ill
1 Speedometer with
analogue display
2 Tire pressure warning
1 Speedometer
with
light
display
3 analogue
Turn signal
indicator
2 Tire
warning
lightpressure
left
4 light
Tachometer
35 Turn
High signal
beam indicator
indicator light
6 light
Turn left
signal indicator
4 Tachometer
light right
57 High
indicator
ABS beam
warning
light light
68 Turn
signal
indicator
Cooling
system:
light
right
Temperature
gauge,
7 ABS
warning
warning
light light
89 Cooling
system:
Fuel: Level
gauge,
Temperature
warning light gauge,
warning light
9 Fuel: Level gauge,
warning light
Page 6
18 Porsche Stability
Canada: Display in km/C
Management
Multifunctional PSM light
18
Stability
19 Porsche
Brake warning
light
20 Management
Safety belt warning light
PSM light
21 Multifunctional
Tiptronic indicator
19
light
22 Brake
Clock warning
and outside
20 Safety
belt warning
temperature
displaylight
21
indicator
23 Tiptronic
Adjustment
button for
22 Clock
clock and outside
temperature display
23 Adjustment button for
clock
Selecting
To confirmfunctions:
selection:
up 3forward
or
Push
Push lever
the lever
1.
down 4.
To move back several
To
confirmlevels:
selection:
selection
the lever
1.
Push
Pull lever
backforward
2.
To
back several
- ormove
selection
levels:
Z
Select
arrow in the onboard
computer
Pull
lever
back 2.display
- orand
- push lever forward 1.
Z
Select arrow in the onboard computer display
and push lever forward 1.
H62-534
ger
e
H62-534
Push
Push operating
lever up 3lever
or
forward
down 4.or back.
re
d,
ger
s
this case
the In
alarm
syste
the lock.
at
Press
butto
Leave
theremote
door
The
the alarm syste
Press butto
The remote
Immobilizer
Boxster (987)
Cockpit
Windshield wiper/
washer system
parking light/
headlight flasher stalk
Press
button
A.
ignition lock position
ignition lock position.
Swivel lever B to the front
Swivel lever B to the rear
until it is felt to engage.
until it is felt to engage.
Emergency operation
*At DIN empty weight and half load, without performance-inhibiting extra equipment.
Maximum speed
Acceleration 0 - 60 mph
Acceleration 0 - 100 km/h (62 mph)
Boxster S
Fuel tank
Refill volume approx. 16.9 U.S. gallons (64 liters), including
approx. 2.6 U.S. gallons (10 liters) reserve
Fuel octane rating
Premium fuel with 98 RON (93 CLC or AKI).
! If fuels with octane numbers of 95 RON (90 CLC or AKI) are used, the engines knock
control automatically adapts the ignition timing.
1 Speedometer with
analogue display
2 Tire pressure warning
light
3 Turn signal indicator
light left
4 Tachometer
5 High beam indicator light
6 Turn signal indicator
light right
7 ABS warning light
8 Cooling system:
Temperature gauge,
warning light
9 Fuel: Level gauge,
warning light
Maximum speed
5-speed transmission
6-speed transmission
Acceleration 0 - 60 mph
Acceleration 0 - 100 km/h (62 mph)
Boxster
Tiptronic S
Manual transmission
6.7 seconds
7.0 seconds
Tiptronic S
Manual transmission
H62-534
Tools, etc.
Immobilizer
H51-074
Driving performance*
6
Number of cylinders
Cubic capacity
163.96 cu. in. (2687 cm3)
Net-horsepower, SAE J 1349 245 hp (180 kW)
at crankshaft speed
4600 - 6000 rpm
Engine type
Type
Engine data
6
206.67 cu. in. (3387 cm3)
295 hp (217 kW)
4400 - 6000 rpm
M 97/21
Horizontally opposed engine,
liquid cooled
M 97/20
Horizontally opposed engine,
liquid cooled
Boxster S
Boxster
Pit stop
23
Unlocking lids
19
20
21
22
Convertible top
The engine is designed for oils with ACEA, API and ILSAC specifications, with the following
viscosity values: Above -13F/-25C: SAE 0W-40, 5W-40 and 5W-50.
Below -13F/-25C: SAE OW-40.
Use only engine oils approved by Porsche. If in doubt ask your authorized
Porsche dealer for tested and approved all-season oils.
Comprehensi
found in the
This Quick R
18
The specified tire filling pressures apply only to the tire makes and types approved by
Porsche.
17, 18-inch wheels
front 29 psi (2.0 bar) / rear 36 psi (2.5 bar)
19-inch wheels
front 32 psi (2.2 bar) / rear 36 psi (2.5 bar)
Washer fluid
This Quick Reference Guide does not replace the Owners Manual.
Warnings in particular are not replaced by this Quick Reference Guide.
Displays
and indicators
Helpful
tips
Capacity
Approx. 0.66 U.S. gallons (2.5 liters) without
headlight washer
Approx. 1.59 U.S. gallons (6.0 liters) with
headlight washer
Tiptronic S
Car care
On-board computer
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 987 121 07
Entry
1
2
3
4
5
6
7
8
Page 7
warning light
Boxster, Boxster
S
Quick Reference Guide
Boxster (987)
Tiptronic S
Seat heaters
Switching on:
High heating power
Press button.
Low heating power
Press button again.
Tiptronic S is a 5-speed
automatic transmission:
D: Automatic gear-changing
M: Manual gear-changing
using rocker switches on
the steering wheel
Manually extending/
retracting rear spoiler
ParkAssist
H51-012
Switching off:
Press button.
Speed control
A Switching off/on
1 +SPEED/SET
(accelerate/store)
2 SPEED (decelerate)
3 OFF (interrupt)
4 RESUME
Pit stop
Engine data
Engine type
Type
Washer fluid
Boxster
Boxster S
M 97/20
Horizontally opposed engine,
liquid cooled
M 97/21
Horizontally opposed engine,
liquid cooled
6
Number of cylinders
Cubic capacity
163.96 cu. in. (2687 cm3)
Net-horsepower, SAE J 1349 245 hp (180 kW)
at crankshaft speed
4600 - 6000 rpm
Driving performance*
Boxster
Maximum speed
5-speed transmission
6-speed transmission
Acceleration 0 - 60 mph
Acceleration 0 - 100 km/h (62 mph)
Boxster S
Capacity
Approx. 0.66 U.S. gallons (2.5 liters) without
headlight washer
Approx. 1.59 U.S. gallons (6.0 liters) with
headlight washer
6
206.67 cu. in. (3387 cm3)
295 hp (217 kW)
4400 - 6000 rpm
Maximum speed
Acceleration 0 - 60 mph
Acceleration 0 - 100 km/h (62 mph)
Manual transmission
Tiptronic S
Manual transmission
Tiptronic S
*At DIN empty weight and half load, without performance-inhibiting extra equipment.
Page 8
This Quick Reference Guide does not replace the Owners Manual.
Warnings in particular are not replaced by this Quick Reference Guide.
Press button A.
Swivel lever B to the rear
until it is felt to engage.
Car care
The specified tire filling pressures apply only to the tire makes and types approved by
Porsche.
17, 18-inch wheels
front 29 psi (2.0 bar) / rear 36 psi (2.5 bar)
19-inch wheels
front 32 psi (2.2 bar) / rear 36 psi (2.5 bar)
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 987 121 07
H51-074
Unlocking lids
Comprehensiv
found in the O
This Quick Re
Notes
Page 9
Notes
Page 10
Seite 1
Cayman (987)
Cockpit
Cockpit
Windshield wiper/
washer system
Windshield wiper/
washer system
K61-009
K61-009
Controls
1 Light switch
2 Turn signals/
Controls
headlight dimmer/flasher lever
3
lock/locking the
1 Ignition
Light switch
column
2 steering
Turn signals/
4 Hands-free
microphone forlever
headlight dimmer/flasher
3 telephone
Ignition lock/locking the
5 Horn
steering column
6
lever
4 Windshield
Hands-free wiper/washer
microphone for
Rear
window wiper
telephone
7
Communication
5 Porsche
Horn
6 Management/radio
Windshield wiper/washer lever
8 Interior
temperature
Rear window
wiper sensor,
antenna
7 GPS
Porsche
Communication
9 Emergency
flasher switch
Management/radio
10
button,
8 Central
Interior locking
temperature
sensor,
readiness
display for alarm
GPS antenna
9 system
Emergency flasher switch
11
10 Cupholder
Central locking button,
readiness display for alarm
system
11 Cupholder
Ignition lock
12 Operating lever for
on-board computer
13 Locking lever for
12 steering-wheel
Operating lever for
adjustment
on-board computer
14
leverforfor
13 Operating
Locking lever
cruise
control
steering-wheel
15 Control
panel for heatadjustment
ventilation
14 ing,
Operating
leverand
for air
conditioning
system
cruise control
16
for rear
15 Buttons
Control panel
forspoiler,
heatPorsche
Active and air
ing, ventilation
Suspension
Management
conditioning system
mode,
16 (PASM),
Buttons Sport
for rear
spoiler,
Porsche
Porsche Stability
Active
Management
(PSM),
Suspension Management
Sports
system
(PASM),exhaust
Sport mode,
17 Seat
heating,
left/right
Porsche
Stability
Management (PSM),
Sports exhaust system
17 Seat heating, left/right
Ignition lock
position
Light switch
Light switch
0 Off
1 Rain sensor
2 Slow
3
0 Fast
Off
4
operation
1 One-touch
Rain sensor
5
2 Spray
Slow and wipe
A
washer system
3 Headlight
Fast
4 One-touch
Rear
window operation
wiper
Spray and wipe
5 intermittent
operation
A
Headlight
washer
Move wiper lever system
forward.
Rear
window wiper
intermittent operation
Move wiper lever
forward.
Welcome Home
Lighting
Side lights
Welcome Home
Low
beam, high beam
Lighting
0 Initial position
1 Ignition on
2 Start engine
3
off
0 Ignition
Initial position
1 Ignition on
2! The
Start
engine
vehicle
key
3 rebounds
Ignition off
to the initial
position from every
lock key
position.
The vehicle
! ignition
rebounds to the initial
position from every
ignition lock position.
Fog
Sidelight
lights
Pull switch to first
Low
beam,
high beam
click.
Fog light
Rear
fog light
Pull switch
switch to
to second
first
Pull
click.
click.
Rear fog light
Pull switch to second
click.
On-board computer
Tiptronic S
On-board computer
Tiptronic S
H
Rem
ions:
Selecting
To
confirmfunctions:
selection:
Push
Push the
lever
up 3forward
or
lever
1.
To down
move4.
back several
ystem if it
using the
ot open a
vehicle will
cally. the
using
ot open a
e vehicle will
d
ically.
for approx.
id
for approx.
1 Speedometer with
analogue display
2 Tire pressure warning
1 light
Speedometer with
3 Turn
signaldisplay
indicator
analogue
left
2 light
Tire pressure
warning
4 Tachometer
light
5
3 High
Turn beam
signal indicator
indicator light
6 Turn
light signal
left indicator
right
4 light
Tachometer
7
light
5 ABS
High warning
beam indicator
light
8
system:
6 Cooling
Turn signal
indicator
Temperature
light right gauge,
light light
7 warning
ABS warning
9
Level
gauge,
8 Fuel:
Cooling
system:
warning
light gauge,
Temperature
warning light
9 Fuel: Level gauge,
warning light
18 Porsche Stability
Canada: Display in km/C
Management
Multifunctional PSM light
19
warning
light
18 Brake
Porsche
Stability
20 Safety
belt warning light
Management
21 Tiptronic
indicator
Multifunctional
PSM light
22
outside
19 Clock
Brake and
warning
light
display light
20 temperature
Safety belt warning
23
Adjustment
button
21 Tiptronic indicator for
22 clock
Clock and outside
temperature display
23 Adjustment button for
clock
To confirm
selection:
selection
levels:
Pull
Pushlever
the lever
1.
back forward
2.
-To
or move
back several
Z
Select
arrow in the onselection
levels:
computer
board
Pull lever
back 2.display
- orand
- push lever forward 1.
Z
Select arrow in the onboard computer display
and push lever forward 1.
TheEngage
displaythe
flashes
if the
correctly.
selector
lever is between
two positions.
OilEngage
level indicator
the selector lever
correctly.
H62-534
up 3 lever
or
forward
down
4. or back.
H62-534
assenger
system are
ions:
be opened,
om
inside.
assenger
system are
d,
bepassenger
opened,
system
is
om
inside.
.
pulling
the
d,
passenger
system is
m. system.
pulling the
ystem if it
m system.
waitingcomputer:
time to
theAllow
on-board
elapse.
Switch ignition on (do not
Read
off engine
start the
engine).oil level
thewaiting
segment
display.
on
Allow
time
to
elapse.
Read off engine oil level
on the segment display.
Page 11
The r
switch
Rem
not un
TheInr
at
switc
Leave
not u
the
al
In
Pr
a
Th
Leave
the a
P
T
Imm
If you
two m
Imm
the im
Deact
If you
twoSm
the Sim
Deac
S
S
Cayman (987)
Cockpit
Seat
Windshield wiper/
washer system
Servicing
1 Speedometer with
analogue display
2 Tire pressure warning
light
3 Turn signal indicator
light left
4 Tachometer
5 High beam indicator light
6 Turn signal indicator
light right
7 ABS warning light
8 Cooling system:
Temperature gauge,
warning light
9 Fuel: Level gauge,
warning light
10
11
12
Manual transmission
Cayman S
6.7 seconds
7.0 seconds
Manual transmission
Tiptronic S
Driving performance*
Number of cylinders
Cubic capacity
Net-horsepower, SAE J 1349
at crankshaft speed
Net torque, SAE J 1349
at crankshaft speed
Engine oil consumption
Maximum rpm
M 97/20
Engine type
Type
Engine data
Cayman
Pit stop
H62-534
* At DIN empty weight and half load, without performance-inhibiting extra equipment.
Top track speed
Acceleration 0 - 60 mph
Acceleration 0 - 100 km/h (62 mph)
Immobilizer
Fuel tank
Refill volume approx. 16.9 U.S. gallons (64 liters), including
approx. 2.6 U.S. gallons (10 liters) reserve
Fuel octane rating
Premium fuel with 98 RON (93 CLC or AKI).
! If fuels with octane numbers of 95 RON (90 CLC or AKI) are used, the engines knock
control automatically adapts the ignition timing.
Cayman S
Page 12
H51-074
C
fo
Th
sche Stability
agement
ifunctional PSM light
ke warning light
ety belt warning light
ronic indicatorA Main key
ck and outside1 Central locking button
2 Button for front luggage compartment lid
perature display
Button for rear lid
ustment button3 for
4 Light-emitting diode
k
B Spare key
Tools, etc.
The engine is designed for oils with ACEA, API and ILSAC specifications, with the following
viscosity values: Above -13F/-25C: SAE 0W-40, 5W-40 and 5W-50.
Below -13F/-25C: SAE OW-40.
Use only engine oils approved by Porsche. If in doubt ask your authorized
Porsche dealer for tested and approved all-season oils.
The specified tire filling pressures apply only to the tire makes and types approved by
Porsche.
Pull lever back 2.
Unlocking:
- or Press button 1.
Z
Select arrow in the onVehicle is unlocked.
board computer display
! If you unlock the vehicle using the
and push lever forward 1.
remote control and do not open a
Emergency operation
Washer fluid
Capacity
Approx. 0.66 U.S. gallons (2.5 liters) without
headlight washer
Approx. 1.59 U.S. gallons (6.0 liters) with
headlight washer
Car care
This Quick Reference Guide does not replace the Owners Manual.
Warnings in particular are not replaced by this Quick Reference Guide.
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 987 721 07
Helpful
tipsand indicators
Displays
d trademarks
automobiles
Tiptronic S
On-board computer
Entry
warning light
Cayman (987)
Automatic transmission and electronics
Tiptronic S
Seat heaters
Switching on:
High heating power
Press button.
Low heating power
Press button again.
Tiptronic S is a 5-speed
automatic transmission:
D: Automatic gear-changing
M: Manual gear-changing
using rocker switches on
the steering wheel
Manually extending/
retracting rear spoiler
ParkAssist
Engage reverse gear. A
brief signal tone sounds.
A detected obstacle is
signalled by an intermittent
tone. The intervals decrease
as the obstacle is approached.
A continuous tone sounds
when the distance becomes
less than one foot.
H51-012
Switching off:
Press button.
Speed control
A Switching off/on
1 +SPEED/SET
(accelerate/store)
2 SPEED (decelerate)
3 OFF (interrupt)
4 RESUME
Page 13
Notes
Page 14
Notes
Page 15
This Quick Reference Guide does not replace the Owners Manual. In particular, warnings are not replaced by this Quick Reference Guide.
Entry
Cayenne/S
(9PA)
Immobilizer
Parking brake
Vehicle key
9 Light switch
Unlocking
all vehicle doors
10 Turn signal/high
beam/headlight
Z Briefly
flasherpress
stalk on the remote control
twice within two seconds.
Panic button
Turn signal/high beam
Switching off:
Z Insert the ignition key into the ignition
lock.
Switching on:
Z Withdraw ingnition key, or switch
ignition off in vehicles that have
Porsche Entry & Drive.
To trigger alarm:
1, 2
Turnbutton.
signal lights
Z
Press
3 TheHigh
hornbeam
sounds and the emergency
4 flashers
Headlight
flasher
flash.
Rear window:
6 Intermittent mode:
Z Press lever forward to first click.
7 Wipe three times:
Z Press lever forward briefly.
Spray and wipe:
Z Press lever forward.
To stop
the alarm:
Parking
light
Z
button
again.
Z Press
Switch
off ignition.
Z
Low beam
Z
Move lever to middle position.
Fuel octane ra
! If fuels wit
automatica
The engine is
the following v
Cayenne (V6
Cayenne S: a
b
U
Refuelling
Car care
Pay attention
High-pressure
logos, emblem
generator, val
sensors.
! Always ob
of 21 in. (
jet nozzle.
G
H
I
J
K
Powerliftga
Fuel gage
Reset button for trip counter display
Speedometer
Mileage displays
Voltmeter
Unlocking ta
Variant 1:
Z Briefly pre
rear lid.
Variant 2:
Z Press the
control fo
e does not
l.
not
rence
Fuel tank
General warning
Observe warning message on the
multipurpose display!
Oil temperature gage
Tachometer
Clock
Clock reset button
Cooling system
temperature gage
Multi-purpose display
Fuel and en
Powerl
Instruments
A
B
C
D
E
Pit stop
ayenne,
registered
orsche AG.
Cockpit
r duplication
with
Variant 3:
Z Pull the b
(see Fig.
switched
ns,
Scrolling in menu:
Z Press rocker switch A up or down.
Page 16
Air conditioning
bers of
in the
on
ve.
3.
Main menu:
You can have different menus displayed
when driving:
Phone
MPH limit
Vehicle information
Tire pressure
Settings
heel, tire
r the cover
Closing tailg
Z Briefly pre
interior tri
Cayenne/S (9PA)
Seat
nd none of
d within
, automatic
Seat heating
assenger
system and
ning in the
s being transr ship, for
artment
ion sensor
h off passensystem and
Seat position:
A Seat height, front
B Seat height, rear
C Lengthwise
D Backrest angle
E Lumbar support
F Seat memory: Person button 1, 2, 3
Recalling position with key or
Porsche Entry & Drive, drivers seat:
Z Open drivers door.
s Manual.
1
2
3
4
5
6
7
8
9
10
11
12
13
Powerliftgate
Power windows
Inner door handle
Door mirror adjustment
Engine compartment lid release
Parking brake
Diagnostic socket (OBD)
Parking brake release
Ignition lock/steering lock
Steering wheel adjustment (manual)
Seat adjustment
Instrument lighting knob
Light switch
A
B
C
D
E
F
Mu
Scr
Z
s on the
Powerliftgate (tailgate)
Rear window
ght
or light
Ma
light
ht
ge on the
Unlocking tailgate:
Variant 1:
Z Briefly press the release handle on the
rear lid.
Variant 2:
Z Press the button
on the remote
control for approx. 1 second.
Variant 3:
Z Pull the button A on the drivers door
(see Fig. above) with the ignition
switched on until the rear lid opens.
Opening:
Z Press release button A.
Closing:
Z Close and press into lock until you feel
the rear window engage.
A
B
C
D
Close completely
Open to comfort position
Open completely
Open to lift position
Au
displayed
A
B
C
D
Page 17
Cayenne/S (9PA)
This Quick Reference Guide does not replace the Owners Manual. In particular, warnings are not replaced by this Quick Reference Guide.
Entry
Starting safely and comfortably
The Porsche Cayenne is equipped with
exceptional engine power. Bear this in mind
when you are driving.
Z Familiarize yourself with the displays
and controls.
Z Adjust the interior and door mirrors
before starting your journey.
Z Adjust the position of the seat, safety
belt and steering wheel to your size.
Z Make sure that you and your passengers always wear a safety belt.
Vehicle key
Panic button
Immobilizer
Switching off:
Z Insert the ignition key into the ignition
lock.
Switching on:
Z Withdraw ingnition key, or switch
ignition off in vehicles that have
Porsche Entry & Drive.
To trigger alarm:
Z Press button.
The horn sounds and the emergency
flashers flash.
To stop the alarm:
Z Press button again.
Entry
Entry with remote control
Instruments
at:
ons,
ition
rs)
Drive.
r 3.
he
nt.
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 948 221 08
Unlocking doors:
Z Press the button
control.
Locking doors:
Z Press the button
control.
on the remote
on the remote
Scrolling in menu:
Z 18
Press rocker switch A up or down.
Page
Unlocking doors:
Z Grip door handle fully.
Locking doors:
Z Press the button on the door handle.
! The doors cannot be opened again if
the vehicle key with remote control is
range.
G out
Fuelofgage
H Reset button for trip counter display
Unlocking
and locking tailgate, rear
I Speedometer
window,
spare
wheel bracket:
J Mileage
displays
Z
order to open the tailgate, rear
K In
Voltmeter
window and spare wheel bracket, you
need only be in the rear area of your
vehicle with the Porsche remote
control.
Functional readiness:
Functional readiness of Porsche Entry &
Drive is deactivated if the vehicle has not
been unlocked for a period of 3 days.
Z Pull door handle of drivers door once:
The system is activated again.
Z Pull door handle again to open the
door.
Powe
Warning and indicator lights on the
speedometer:
Powerliftg
Unlocking
Variant 1:
Z Briefly p
rear lid.
Variant 2:
Z Press th
control
Variant 3:
Z Pull the
(see Fig
switche
Main menu:
You can have different menus displayed
when driving:
Phone
MPH limit
Vehicle information
Tire pressure
Settings
Closing ta
Z Briefly p
interior
Defrost windshield
circulating-air mode.
Cayenne/S (9PA)
Automatic transmission and electronics
Light
A
B
Fog lights
Pull out switch to first click. Indicator
light lights up.
Tiptronic S
A
1
2
3
4
Store speed
Switch on
Switch off
Accelerate speed
Decelerate speed
The automatic speed control keeps the
speed constant in the range 20150
mph (30240 km/h).
ParkAssist
Switching off/on:
Z Press button A in the roof console.
When ParkAssist is switched off, the
indicator light in the button lights up.
Light segments/distance/signals:
Warning displays on the dashboard for
front end, and in the roofliner at the rear
for rear end.
ParkAssist activate
up to 3 segments
front: 4824 in. (12060 cm) distance
rear: 5924 in. (15060 cm) distance
4 segments
2410 in. (6025 cm) distance
Intermittent signal sounds.
Distance less than 10 in. (25 cm),
continuous signal sounds.
Manual transmission
Instrument illumination
Driving programmes
! Please read the corresponding
section of the Owners Manual carefully before using the different driving
programmes of your Porsche.
Page 19
Cayenne/S (9PA)
Cayenne, Cayenne S
Air conditioning
Manual air conditioning
A
B
C
D
Temperature sensor
Air conditioning display
Setting air quantity
Setting temperature
ECON mode
Automatic mode
Circulating-air mode
Air to windshield
Air to footwell
Defrost windshield
REST mode
Automatic mode/
REST mode
!
Z
Parking heater
Parking heater on/off,
activate programs
Start programming,
call memories
Set ON times,
Activate heating function
Set ON times,
Activate ventilation function
Pit stop
Fuel
and engine oiltransmission
Automatic
Entry
and electronics
Entry with re
Light
The engine is designed for oils corresponding to the specifications ACEA, API or ILSAC with
the following viscosities:
Cayenne (V6):
SAE 0W-30 and 0W-40 (all temperature ranges)
Cayenne S: above 23 F (-25C) SAE 0W-40, 5W-40 and 5W-50
below 23 F (-25C) SAE 0W-40
Use only engine oil approved by Porsche.
ARefuelling
Instrument lightning knob
B
Light switch
Light switch
Light is switched off
Automatic driving light assistant
Slide lights
Low beam, high beam
Fog lights
Pull out switch to first click. Indicator
Car care
light lights up.
Pay attention
to the following:
Rear fog light
High-pressure
cleaners
damage
Z
Pull out switch
to can
second
click.tires,
logos,Indicator
emblems,
paint,
widened
light
lights
up. fenders,
generator, valve covers and the ParkAssist
sensors.
Instrument illumination
! Always observe a minimum distance
of 21 in. (50 cm). Never use a roundjet nozzle.
Manual transmission
Before cleaning in a car wash:
Z Ask the operator about special wheel
widths as well as accessories such as
spoilers, high-gloss wheels, etc.
Z Switch the windshield wipers off.
Z Fold in door mirrors.
Z Remove roof transport system.
Unlocking doo
Z Press the b
control.
Page 20
ParkAssist
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 948 221 08
Oil level
Fuel tank
el.
Locking doors
Z Press the b
control.
Opening tailga
Z Press the b
control.
Page 21
Pit stop
Fuel and engine oil
Entry
Oil level
Entry with
Fuel tank
Filling capacity approx. 26.4 U.S. gallons (100 Liters) of which
approx. 3 U.S. gallons (12 Liters) reserve
Fuel octane rating
Premium fuel with 98 RON/88 MON
! If fuels with octane numbers of at least 95 RON/85 MON are used, the knock control
automatically adapts the ignition timing.
The engine is designed for oils corresponding to the specifications ACEA, API or ILSAC with
the following viscosities:
Cayenne (V6):
SAE 0W-30 and 0W-40 (all temperature ranges)
Cayenne S: above 23 F (-25C) SAE 0W-40, 5W-40 and 5W-50
below 23 F (-25C) SAE 0W-40
Use only engine oil approved by Porsche.
Refuelling
Opening the filler flap:
Z Unlock the filler flap in the rear, right
wing by means of the central locking
system.
Z Press on the rear part of the filler flap
(arrow).
Locking the filler flap:
Z Lock the vehicle.
Car care
Pay attention to the following:
High-pressure cleaners can damage tires,
logos, emblems, paint, widened fenders,
generator, valve covers and the ParkAssist
sensors.
! Always observe a minimum distance
of 21 in. (50 cm). Never use a roundjet nozzle.
Washer fluid
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 948 221 08
Cayenne
Cayenne
Manual transmission Tiptronic S
Cayenne S
Manual transmission
Cayenne S
Tiptronic S
Type
4-cycle engine,
liquid-cooled
4-cycle engine,
liquid-cooled
4-cycle engine,
liquid-cooled
Number of cylinders
Displacement
Net-horsepower, SAE J 1349
Engine oil consumption
Maximum permitted engine speed
6
6
8
219.5 cu. in.
219.5 cu. in.
293.3 cu. in.
290 bhp (213 kW)
290 bhp (213 kW)
385 bhp (283 kW)
1.5 Liters / 1000 km (all up to 1.6 quarts/622 miles)
6700 rpm
6700 rpm
6700 rpm
4-cycle engine,
liquid-cooled
6500 rpm
8
293.3 cu. in.
385 bhp (283 kW)
Additional information
Engine data
Maximum speed
when towing a trailer
Cayenne
Cayenne
Manual transmission Tiptronic S
Cayenne S
Manual transmission
Cayenne S
Tiptronic S
Acceleration
062 mph (100 km/h)
8.1 seconds
8.5 seconds
6.6 seconds
6.8 seconds
Tools, etc.
Driving performance
Servicing
Technical data
Cayenne/S (9PA)
Notes
Page 22
Notes
Page 23
This Quick Reference Guide does not replace the Owners Manual. In particular, warnings are not replaced by this Quick Reference Guide.
Cockpit
Vehicle key
Immobilizer
Parking brake
Panicsignal/high
button
Turn
beam
Switching off:
Z Insert the ignition key into the ignition
lock.
Switching on:
Z Withdraw ingnition key, or switch
ignition off in vehicles that have
Porsche Entry & Drive.
To trigger alarm:
1,
Turn button.
signal lights
Z 2Press
3 The
High
beam
horn
sounds and the emergency
4 flashers
Headlight
flasher
flash.
To stop
the alarm:
Parking
light
Z Press
button
again.
Z
Switch
off ignition.
Z
Press lever up or down.
Pit sto
Fuel and en
Fuel tank
Fuel octane r
! If fuels wi
automatic
The engine is
the following
above 23 F
below 23 F
Use only engi
Car care
Pay attentio
High-pressure
logos, emblem
generator, va
sensors.
! Always ob
of 21 in.
jet nozzle
Low beam
Z
Move lever to middle position.
Powe
Instruments
t:
A
B
C
D
E
Powerliftg
Unlocking
Variant 1:
Z Briefly p
rear lid.
ayenne,
egistered
orsche AG.
r duplication
with
Variant 2:
Z Press th
control f
Variant 3:
Z Pull the
(see Fig
switched
ons,
tion
rive.
3.
he
t.
Scrolling in menu:
Z Press rocker switch A up or down.
Page 24
Air conditioning
Main menu:
You can have different menus displayed
when driving:
Phone
MPH limit
Vehicle information
Tire pressure
Settings
Closing tai
Z Briefly p
interior
nd none of
d within
, automatic
Seat heating
assenger
system and
ning in the
s being transr ship, for
partment
tion sensor
h off passensystem and
s Manual.
s on the
Seat position:
A Seat height, front
B Seat height, rear
C Lengthwise
D Backrest angle
E Lumbar support
F Seat memory: Person button 1, 2, 3
1
2
3
4
5
6
7
8
9
10
11
12
13
Powerliftgate
Power windows
Inner door handle
Door mirror adjustment
Engine compartment lid release
Parking brake
Diagnostic socket (OBD)
Parking brake release
Ignition lock/steering lock
Steering wheel adjustment (manual)
Seat adjustment
Instrument lighting knob
Light switch
A
B
C
D
E
Mu
Scr
Z
Rear window
ght
Au
or light
r light
ght
ge on the
Unlocking tailgate:
Variant 1:
Z Briefly press the release handle on the
rear lid.
Variant 2:
Z Press the button
on the remote
control for approx. 1 second.
Variant 3:
Z Pull the button A on the drivers door
(see Fig. above) with the ignition
switched on until the rear lid opens.
Opening:
Z Press release button A.
Closing:
Z Close and press into lock until you feel
the rear window engage.
A
B
C
D
Close completely
Open to comfort position
Open completely
Open to lift position
A
B
C
D
displayed
!
Z
Page 25
t:
ons,
tion
rive.
3.
he
rs)
t.
This Quick Reference Guide does not replace the Owners Manual. In particular, warnings are not replaced by this Quick Reference Guide.
Entry
Starting safely and comfortably
The Porsche Cayenne is equipped with
exceptional engine power. Bear this in mind
when you are driving.
Z Familiarize yourself with the displays
and controls.
Z Adjust the interior and door mirrors
before starting your journey.
Z Adjust the position of the seat, safety
belt and steering wheel to your size.
Z Make sure that you and your passengers always wear a safety belt.
Vehicle key
Panic button
Immobilizer
Switching off:
Z Insert the ignition key into the ignition
lock.
Switching on:
Z Withdraw ingnition key, or switch
ignition off in vehicles that have
Porsche Entry & Drive.
To trigger alarm:
Z Press button.
The horn sounds and the emergency
flashers flash.
To stop the alarm:
Z Press button again.
Entry
Entry with remote control
Instruments
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 948 321 08
c3
Locking doors:
Z Press the button
control.
on the remote
on the remote
on the remote
temperature gage
Multi-purpose display
Scrolling in menu:
Z 26
Press rocker switch A up or down.
Page
Unlocking doors:
Z Grip door handle fully.
Locking doors:
Z Press the button on the door handle.
! The doors cannot be opened again if
the vehicle key with remote control is
of range.
F out
Digital
speedometer, Outside
temperature, Clock, Mileage displays
Unlocking
and locking tailgate, rear
G Fuel gage
window,
H Resetspare
buttonwheel
for tripbracket:
counter display
Z
order to open the tailgate, rear
I In
Speedometer
window
and
spare
wheel
bracket, you
J Engine boost pressure display
need only be in the rear area of your
vehicle with the Porsche remote
control.
Functional readiness:
Functional readiness of Porsche Entry &
Drive is deactivated if the vehicle has not
been unlocked for a period of 3 days.
Z Pull door handle of drivers door once:
The system is activated again.
Z Pull door handle again to open the
door.
Power
Warning and indicator lights on the
speedometer:
Powerliftg
Unlocking t
Variant 1:
Z Briefly p
rear lid.
Variant 2:
Z Press th
control f
Variant 3:
Z Pull the
(see Fig.
switched
Main menu:
You can have different menus displayed
when driving:
Phone
MPH limit
Vehicle information
Tire pressure
Settings
Closing tail
Z Briefly p
interior t
A
B
Light switch
Fog lights
Pull out switch to first click. Indicator
light lights up.
Tiptronic S
A
1
2
3
4
Store speed
Switch on
Switch off
Accelerate speed
Decelerate speed
The automatic speed control keeps the
speed constant in the range 20150
mph (30240 km/h).
ParkAssist
Switching off/on:
Z Press button A in the roof console.
When ParkAssist is switched off, the
indicator light in the button lights up.
Light segments/distance/signals:
Warning displays on the dashboard for
front end, and in the roofliner at the rear
for rear end.
ParkAssist activate
up to 3 segments
front: 4824 in. (12060 cm) distance
rear: 5924 in. (15060 cm) distance
4 segments
2410 in. (6025 cm) distance
Intermittent signal sounds.
Distance less than 10 in. (25 cm),
continuous signal sounds.
Instrument illumination
Driving programmes
! Please read the corresponding
section of the Owners Manual carefully before using the different driving
programmes of your Porsche.
Hillholder
Hillholder for Tiptronic S:
In selector lever position D or M, the hillholder function makes it easier to move off
from a standstill on an upward slope when
the engine is running without having to
apply the brake.
! The hillholder function is deactivated in
selector lever position N or R, in the
restricted driving program and if not all
wheels are in contact with the ground.
Page 27
Cayenne Turbo
Air conditioning
A
B
C
D
Temperature sensor
Air conditioning display
Setting air quantity
Setting temperature
ECON mode
Air to windshield
REST mode
Air to footwell
Defrost windshield
Rear window heating
Air quantity
Automatic mode
!
Z
Parking heater
Automatic mode/
REST mode
Circulating-air mode
Start programming,
call memories
Set ON times,
Activate heating function
Set ON times,
Activate ventilation function
Pit stop
Fuel
and engine oiltransmission
Automatic
Entry
and electronics
Refuelling
Oil level
Entry with re
Fuel tank
Light
The engine is designed for oils corresponding to the specifications ACEA, API or ILSAC with
the following viscosities:
above 23 F (-25C) SAE 0W-40, 5W-40 and 5W-50
below 23 F (-25C) SAE 0W-40
Use only engine oil approved by Porsche.
A
B
Light switch
ParkAssist
Washer fluid
up to 3 segments
front: 4824 in. (12060 cm) distance
rear: 5924 in. (15060 cm) distance
4 segments
2410 in. (6025 cm) distance
Intermittent signal sounds.
Distance less than 10 in. (25 cm),
continuous signal sounds.
Page 28
Unlocking doo
Z Press the b
control.
Oil dipstick
ParkAssist activate
Car care
Fog lights
Z
Pull out switch to first click. Indicator
Pay attention to the following:
light lights up.
High-pressure cleaners can damage tires,
logos, emblems, paint, widened fenders,
Rear fog light
generator, valve covers and the ParkAssist
Z
Pull out switch to second click.
sensors.
Indicator light lights up.
! Always observe a minimum distance
ofInstrument
21 in. (50 cm).
Never use a roundillumination
jet nozzle.
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 948 321 08
el.
Locking doors
Z Press the b
control.
Opening tailga
Z Press the b
control.
Page 29
Pit stop
Fuel and engine oil
Entry
Refuelling
Oil level
Entry with
Fuel tank
Filling capacity approx. 26.4 U.S. gallons (100 Liters) of which
approx. 3 U.S. gallons (12 Liters) reserve
Fuel octane rating
Premium fuel with 98 RON/88 MON
! If fuels with octane numbers of at least 95 RON/85 MON are used, the knock control
automatically adapts the ignition timing.
The engine is designed for oils corresponding to the specifications ACEA, API or ILSAC with
the following viscosities:
above 23 F (-25C) SAE 0W-40, 5W-40 and 5W-50
below 23 F (-25C) SAE 0W-40
Use only engine oil approved by Porsche.
Car care
Pay attention to the following:
High-pressure cleaners can damage tires,
logos, emblems, paint, widened fenders,
generator, valve covers and the ParkAssist
sensors.
! Always observe a minimum distance
of 21 in. (50 cm). Never use a roundjet nozzle.
Oil dipstick
Measuring oil level:
Z Pull out oil dipstick and wipe with a
clean, lint-free cloth.
Z Insert oil dipstick fully again.
Z Withdraw the oil dipstick once more
and read off oil level.
! The oil level must not be below or
above the MIN or MAX marks respectively.
Washer fluid
Dr. Ing. h.c. F. Porsche AG, Printed in Germany, WKD 948 321 08
l.
This Quick Reference Guide does not replace the Owners Manual.
In particular, warnings are not replaced by this Quick Reference Guide.
Additional information
Maximum permitted
engine speed
Engine oil
consumption
6700 rpm
Maximum speed
when towing a trailer
Acceleration
062 mph (100 km/h)
Top track speed
5.1 seconds
Displacement
Number of cylinders
Driving performance
Type
Tools, etc.
Addresses and telephone numbers of
Porsche workshops are listed in the
service directory.
Servicing
Engine data
Technical data
Notes
Page 30
Notes
Page 31
Notes
Page 32