Documente Academic
Documente Profesional
Documente Cultură
Nitoproof 30
Feb 07
constructive solutions
the
requirements
of
British
Standard
of
Practice
CP102:1973.
Technical Support
offers
comprehensive
range
of
high
to specificers, end users and contractors, as well as onDP membrane for basement structures
Design criteria
External
walling
and
cladding:
Nitoproof
30
is
10
Page 1
Nitoproof 30
(Formerly known as Mulseal DP)
Properties
Product
Nitoproof 30
Form
Thixotrophic Liquid
Storage Life
6 months
Solids content
60%
Density
1.00 kg / litre
shown below.
Coverage
- Coverage will depend upon the nature of the surface
being treated
Application Instructions
Preparation
Surface must be clean and free dust, dirt, oil, grease,
moss and loose material. Nitoproof 30 may be used on
1.
Plastijoint
2.
flashing
3.
4.
5.
Nitoproof 30
6.
existing roof
7.
wood block
8.
screed
9.
30 and water.
Application
Nitoproof 30 may be applied by brush and squeegee.
Where required, Nitoproof 30 may be reinforced by
bedding layer of bitumen- saturated glass fibre, such as
Marglass 250, into the first full coat, prior to application of
subsequent coats.
When used as a sandwich damp course to ground slabs,
and wall.
constructive solutions
Page 2
Nitoproof 30
(Formerly known as Mulseal DP)
If required, the treated surface may be painted or
emulsion paint.
Cleaning
thoroughly
stirred
before
use.
For
Thinning
efficient
Estimating
Coverage
Properties
2
1.1 to 1.4m /litre
Priming Coat
2.0 to 2.5m2/litre
Fosroc Primer No 3
12 to 15m2/litre
litres. Soak the brush in the solution and shake out before
Additional Information
Flash point
-1oC
Density
0.85kg/ litre
Storage Life
12 months +
Coverage
12.5m2/litre
Application Temperature
5 to 50oC
Drying time
to 2 hours
in use.
If paint is applied direct to the Nitoproof 30 membrane,
severe crazing and cracking of the paint film will occur;
although this is not serious, it spoils the appearance of the
coat with chippings and, when dry, surface can be painted
with cementitious or PVA paint. No solvent based
constructive solutions
Page 3
Nitoproof 30
(Formerly known as Mulseal DP)
d) After the first coat had been dried, apply the third final
General specifications
30
Bitumen
Rubber
Latex
Emulsion
Apply two coats of bitumen based aluminium paint at the
Waterproofing Membrane.
a) Concrete Roofs
(optional)
(minimum).
a) Sprinkle dry fine sand (passing a 1mm of B.S 14 mesh
2. Application of Nitoproof 30 waterproofing system
laitance etc.
parapet walls.
screed.
metres per litre and whilst still wet, embed into the wet coat
membrane.
Fosroc Singapore
30 Toh Guan Road
#07-07, ODC Districentre
Singapore 608840
www.fosroc.com
telephone:
+ 65 6665 3828
fax:
+ 65 6899 1283
Page 4
email:
Fosroc.Singapore@Fosroc.com