Documente Academic
Documente Profesional
Documente Cultură
Fundamental Concepts
The direction of a line is defined by a horizontal angle with respect to a reference line.
Depending on the type of reference, the direction of the line is termed as relative or absolute. In
relative direction, the reference line does not remain fixed over time.
Meridian
The reference line with respect to which horizontal angle of survey line are measured is known
as meridian. There are different types of meridians based on the type of reference.
True Meridian
Magnetic Meridian
Grid Meridian
Arbitrary Meridian
True Meridian
The true meridian passing through a station on surface of the earth is the (imaginary) line of
intersection of a (imaginary) plane passing through the geographical North and South poles of
the earth with its actual surface. The direction of true meridian at any station is constant and
hence, direction of a line with reference to this remains same over time. At any station, it can
be determined through Astronomical survey. For any engineering works of importance, the
direction of at least one line is determined with true meridian as reference.
Magnetic Meridian
The magnetic meridian at a station on surface of the earth is the (imaginary) line of intersection
of a (imaginary) plane passing through the magnetic North and South poles of the earth with its
actual surface. The direction of a freely suspended well balanced magnetic needle provides the
magnetic meridian at a station. As the magnetic poles of the earth changes with time and so the
magnetic meridian at any station. Thus, the direction of a line with reference to magnetic
meridian varies with time. Magnetic meridian is employed as a line of reference for rough
surveys.
Grid Meridians
To eliminate the effect of convergence of meridian, a meridian through a station is adopted as a
reference meridian and all other meridians are considered parallel to the reference meridian.
Together, all of these are known as grid meridians and the reference meridian is known as
central meridian.
Convergence of meridian : Meridians on the surface of the earth converge towards each other
as the distance from the equator towards either of the poles increases.
Arbitrary Meridian
Any convenient direction from a survey station to some well defined permanent object is
known as arbitrary meridian. This is used for small area survey or to determine the relative
directions of small traverse.
Relative Direction
The direction of a line is expressed in different ways depending upon the type of survey. It is
depicted by bearing, included angle, deflection angle etc. These quantities may be observed
directly in the field or can be obtained indirectly by computation.
Bearing
The horizontal angle measured in clockwise or anticlockwise direction between the meridian
and the survey line is termed as bearing. Different types of bearings are defined based on
different criteria.
Based on meridian
Azimuth
Magnetic Bearing
Grid Bearing
Arbitrary Bearing
Based on direction
Fore Bearing
Back Bearing
Based on designation
Whole circle bearing
Quadrantile bearing (or Reduced bearing)
Magnetic Bearing
The horizontal angle which a line makes with the magnetic meridian measured from Magnetic
North line is called magnetic bearing. It varies with time. Magnetic meridian of a line can be
Grid Bearing
The horizontal angle between a line and a grid meridian is called grid bearing.
Arbitrary Bearing
The horizontal angle of a line measured with respect to an arbitrary meridian is called arbitrary
bearing.
NOB.
Back Bearing
The bearing of a line measured in the backward direction (i.e., opposite to the direction of
progress of survey) is known as back bearing.
In Figure 19.5, the back bearing of the line AB is
bearing of the line BA. Thus,
Back Bearing = Fore Bearing 180
NOA (= 223).
Designation of Bearing
The angle representing bearing is designated depending on the measurement of the angle either
in clockwise and anti-clockwise direction measured either from the North or from the South limb
whichever provides minimum angle.
Conversion of reduced bearing (RB) to whole circle bearing (WCB) and vice versa
The RB of any line can be converted to its equivalent RB as shown in Table 19.1.
Table 19.1 Conversion of RB to WCB (Figure 19.8)
Quadrant
Line
QB or RB
WCB
OA
Nq1 E
q1
II
OB
Sq2 E
180 - q1
III
OC
Sq3 W
180 + q3
IV
OD
Nq4 W.
360 - q4
Similarly the WCB of a line can be converted to its equivalent RB as shown in Table 19.2.
Quadrant
Line
WCB
RB
OA
0 q1 90
Nq1 E
II
OB
90 q2 180
S (180 -q2) E
III
OC
180 q3 270
S (q3 -180) W
IV
OD
270 q4 360
N (360 -q4) W
Interior Angle
In any closed polygon, the direction of any side can be depicted by the angle it makes with its
adjacent side. This angle measured clockwise or anti-clockwise is known as interior angle.
Figure 19.10 shows interior angles at the stations A, B, C, D and E of a closed polygon. The
direction of the side AB can be obtained either of the included angles at vertices such as A, B
etc.
Deflection Angle
The angle between a line and the prolongation of the preceding line is called a deflection angle.
Deflection angle can also be used to note the direction of a line. It is recorded as right or left
depending on whether the line to which measurement is taken lies to the right (clockwise) or left
(counterclockwise) of the prolongation of the preceding line. Figure 19.11 shows deflection
angles. In this, the line BC is having a right deflection angle CD does have left deflestion angle.
Deflection angles may have values between 0 and 180, but usually they are not employed for
angles greater than 90. In any closed polygon the algebraic sum of the deflection angles
(considering right deflections as of sign opposite to left deflections) is 360
Angles to Right
Angles are also depicted by clockwise measurement from the preceding to the following line, as
shown in Figure 19.12. Such angles are called angles to right.
Declination
The horizontal angle which a magnetic meridian makes with the true or astronomic meridian is
called the magnetic declination, or magnetic variation. If the north end of the compass needle
deflects right of the true meridian, the declination is said to be east (Figure 19.13(a)) and if it
deflects to the left of the true meridian, the declination is said to be west (Figure 19.13(b)).
Declination varies from place to place and at any station time to time
Solution :
Declination in 1970 = 9 W
change in (1970 - 1947) = 23 yrs (23 x 1') = 23' Eastwards
Therefore
Declination in 1947 was 9 + 23' = 9 23' W
Magnetic Bearing of the line on 1947 = N 34 E
(i) True bearing of the line = 34 - 9 23' = 24 37'
= N 24 37' E
Declination in 1997 = (9 - 27 x 1' ) W = 8 33' W
Therefore Magnetic bearing in 1997 = 24 37' + 8 33' W
= N 33 10' E
Local Attraction
In presence of magnetic materials, the magnetic needle deviates from the magnetic meridian
and thus provides wrong direction of a line. The deviation arising from such local sources is
called local attraction. If the fore bearing and back bearing of a line does not differ by 180,
then there is a possibility of local attraction during the observation of the line. Otherwise, if
the sum of the interior angles of a closed traverse does not provide (2n - 4) right angles [where
n is the number of sides in the traverse], then there is a possibility of local attraction during
the observation of the traverse.
Determination of Angles/ Directions
Direction and thus angles can be determined by means of a tape, plane-table, alidade, sextant,
or compass etc but normally these are measured with a transit theodolite. In this module,
measurement of angles using theodolite has been considered
Ex19-2 Following are the observed magnetic bearings of the traverse legs:
Line
FB (RB)
BB (WCB)
AB
S 59 30' E
300 30'
BC
N 78 15' E
256 00'
CD
N 59 30' W
125 15'
DA
S 30 15' W
12 45'
At what stations local attraction is suspected? Determine the correct bearings of the traverse
legs and also calculate the included angles.
Solution :
Figure Ex19-2
The FB of the lines are given in reduced bearing. Their equivalent WCB are
Line
AB
BC
CD
DA
FB
RB
S 59 30' E
N 78 15' E
N 59 30' W
S 30 15' W
WCB
120 30' W
78 15'
300 30'
207 45'
RB
300 30'
256 00'
125 15'
27 45'
The FB and BB of any line differs exactly by 180, if the stations are free from local attraction.
In the given observation, the FB and BB of the line AB differs by 180 and thus stations A and
B are free from local attraction. The bearing of the lines observed at stations A and B may be
considered to be correct.
Given, FB of BC = 78 15'
Therefore Correct, BB of BC = 78 15' + 180 = 258 15'
But, observed BB of BC = 256 00'
Therefore Error at C = 258 15' - 256 00' = - 215'
Correction at C = 2 15'
Observed FB of CD = 300 30'
Correction at C = + 2 15'
Therefore corrected FB of CD = 302 45' - 180 = 122 45'
and corrected BB of CD = 125 15'
Error at D = + 2 30'
or Correction at D = - 2 30'
observed FB of DA = 210 15'
Therefore corrected FB of DA = 210 15' - 2 30' = 207 45'
and corrected BB of DA = 207 45' - 180 = 27 45' (Checked)
Line
AB
Corrected FB Corrected RB
120 30'
300 30'
BC
CD
DA
78 15'
302 45'
207 45'
258 15'
122 45'
27 45'
Included angle
As the traverse is running anti-clockwise the included angle will be the interior angles.
Angle at A = F.B. of AB - B.B. of DA = 120 30' -27 45' = 92 45'
B = F.B of BC - B.B of AB = 78 15' - 300 30' = - 222 15' + 360 = 137 45'
C = F.B of CD - B.B of BC = 300 30' - 256 00' = 44 30'
D = F.B of DA - B.B of CD = 210 15' - 125 15' = 85 00'
Calculation of Bearing (2nd method)
Bearing of the line AB = 120 30' (correct)
B = 137 45'
----------------------Bearing of the line BC = 258 15' - 180 = 78 15' (since traverse is anti-clockwise)
C = + 44 30'
-------------------------122 45'
Bearing of the line CD = 122 45' + 180 = 302 45'
D = + 85 00'
--------------------------387 45'
Bearing of CD = 387 45' - 180 = 207 45'
A = + 92 45'
------------------------
300 30'
Bearing of AB = 300 30' - 180 = 120 30' (checked)
Line
FB
BB
AB
BC
CD
DA
120 30'
78 15'
302 45'
207 45'
300 30'
258 15'
122 45'
27 45'
Angle
A = 92 45'
B =137 45'
C = 44 30'
D = 85
[Note : In any traverse, running anti-clockwise, included angle at any stations = F.B. of the
forward line - B.B. of the backward line].
Exercise 19
Ex.19-1 Tabulate the differences between different types of meridians along with differences
in their utilities.
Ex.19-2 What is magnetic declination ?
Ex.19-3 The magnetic bearing of a line was found to be N 60 30' W in 1992, when the
declination was 5 10' E. find its present magnetic bearing, if declination is 3 W.
Ex.19-4 The bearing taken for two lines are as follows:
Line
AB
BC
Back Bearing
322 30' (WCB)
N 44 15' E
Fore Bearing
S 37 30' E
223 15' (WCB)
PQ
74 20'
256 00'
QR
107 20'
286 20'
RS
224 50'
44 50'
SP
200 15'
126 00'
At what stations local attraction is suspected? Determine the correct bearings of the traverse
legs and also calculate the included angles.
Answers
For Exercise 19
Ex.19-1 N 52 20'
Ex.19-2 99 15'
Ex.19-5 At R and S;
Angles 106 45', 123 45', 64 30', 65 00'