Documente Academic
Documente Profesional
Documente Cultură
Router# tclsh
foreach var {
X.X.X.X
Y.Y.Y.Y
Z.Z.Z.Z
} {
ping $var }
Setting up an interface
interface <int>
go up when initialized
description ...
interface
ip address <ip> <subnet mask>
including the subnet mask
clock rate <clock>
bandwidth <bw>
computation
no shutdown
Routing
Gateway of Last Resort
ip route 0.0.0.0 0.0.0.0 <int>
interface
clear ip bgp
something doesn't update)
interface <int>
ip authentication mode eigrp <AS> md5
ip authentication key-chain eigrp <AS> <KEYCHAIN>
Create OSPF
interface <interface>
! Select the interface for Point
to Point
ip ospf network point-to-point
! Setup OSPF point-to-point
router ospf <AS>
! Initialize the OSPF AS
router-id <id>
! Set the Router-ID (Do this
before creating networks)
area <no> range <start-ip> <end-ip>
! Optionally setup the Area
network <network> [wildcard] area <no>
! Add the networks to broadcast
passive-interface default
no passive-interface <int>
redistribute <routing protocol> <no> subnets metric <no>
distribute-list <acl> <direction>
default-information originate always
interface <int>
ip ospf network broadcast
! Set OSPF to broadcast on the
interface.
ip ospf priority <priority>
! Set priority (force DR)
ip ospf network point-to-point
! Loopbacks must be point-topoint to broadcast correct mask
access-list <no> <deny|permit> <network wildcard|any> ! Remember to Deny,
then Permit
!
!
!
!
!
STUB, on ABR
NSSA, on ABR
Totally STUB, on ABR
Totally NSSA, on ABR
All areas must connect to
IPv6 Routing
ipv6 unicast-routing
ipv6 router rip <process>
interface <int>
ipv6 rip <process> enable
!
!
!
!