Documente Academic
Documente Profesional
Documente Cultură
EXPLODED VIEW
Page 1
DISASSEMBLY/INSPECTION
NOTE:
1. Compress the damper spring, then remove the self-locking nut (A) while holding the damper shaft with a
hex wrench (B). Do not compress the spring more than necessary to remove the nut.
Page 2
Page 3
3. Reassemble all the parts, except for the upper spring mounting cushion, bump stop sleeve, bump stop and
the damper spring.
4. Compress the damper assembly by hand, and check for smooth operation through a full stroke, both
compression and extension. The damper should extend smoothly and constantly when compression is
released. If it does not, the gas is leaking and the damper should be replaced.
Page 4
Page 5
REASSEMBLY
1. Install the spring mounting cushion (A) on the upper spring seat (B) by aligning the tab portion (C) on the
cushion with the cutout (D) in the seat.
Page 6
Fig. 38: Aligning Bottom Of Spring And Stepped Part Of Lower Spring Seat
Courtesy of AMERICAN HONDA MOTOR CO., INC.
4. Align the bottom of the spring (B) and the stepped part of the lower spring seat (C).
5. Align an angle of the damper bracket (A) and the tab portion (B) on the spring mounting cushion.
Page 7
Fig. 39: Aligning Angle Of Damper Bracket And Tab Portion On Spring Mounting Cushion
Courtesy of AMERICAN HONDA MOTOR CO., INC.
6. Position the angle of the tab portion and the stud bolt (C) near the "FR" stamp on the upper spring seat as
shown.
7. Install the damper mounting washer (A) and a new self-locking nut(B).
Page 8
Page 9