Documente Academic
Documente Profesional
Documente Cultură
Er.V.M.RAJAN,M.E.(Struct),F.I.E.
Former CE(Civil),TANGEDCO, Chennai
PROBLEM SOLVING USING COMMAND FILE &GUI
PROBLEM :6 SPAN CONTINUOS BEAM WITH VARYING LOADS
File Name=Plane 1
Next
E CONC ALL
DENS CONC ALL
POI CONC ALL
SUPPORT
1 FIXED
2 TO 7 FIXED BUT FX MZ
LOAD 1
MEMB LOADS
1 UNI GY -45
2 UNI GY -35 1 3
2 CONC GY 30 1
2 CONC GY -30 3
3 LIN Y 0 0 -60
4 LIN Y 0 -33
5 CMOM GZ 30 2
6 TRAP GY -20 -40
JOINT LOADS
2 4 FY -20
PERFORM ANALYSIS
PRINT ANALYSIS RESULTS
FINISH
After this
Save the File and Run the Program.
From Main Menu ` Analysis Run Analysis Run Analysis Done.
Select the member and double click on it Shear bending Close.
GRAPHICAL METHOD:
1. Geometry creation:
New Project Select Plane Length =meters; Force=KN;
File Name= Continuous Beam 2
Select Add Beam Finish.
Click Snap node/Beam Edit
X-Y Plane.
Construction Lines:
Next
X Right 6 spacing 4
Y Right 0 spacing 1 OK.
Click (0,0), (4,0), (8,0), (12,0), (16,0) &(24,0). Close Snap node.
Right clickLabels Node Numbers Node Points Beam Members
OK.
2. Member Properties:
Select the member From Page Control General Property Define
Prismatic Rectangular
YD=0.35
Assign Yes.
Select Support 3 in the data area and select the nodes 2 TO 7 Assigned
to selected member Assign Yes Close.
De select the nodes and change to beam cursor.
4. Loads:
From Page control click Loads & Definitions Click Load Details Add
No print Add.
7. Analysis:
From Main Menu ` Analysis Run Analysis Done.
Click Report setup icon Click input from available from left side.
Select sections , Loadings and sent to Right side by clicking > Select output.
From output select Beam end forces, reactions, shear forces, axial forces,
Beam force detail summary.
To Take picture:
Click take picture icon Enter the title of the sketch. Then Go to report set
up. Select picture Album. If you want to change the sketch title enter the
title in caption. Adjust the picture size by adjusting height & width. Select
Full page.
To export Results in word file:
File Export Report MS word file. Click save.