Sunteți pe pagina 1din 36

FibeAir IP-10

CLI
(Command Line Interface)

Procedures

Part ID: BM-0154-0


Doc ID: DOC-00023091 Rev a.02
October 2009

Notice
This document contains information that is proprietary to Ceragon Networks Ltd.
No part of this publication may be reproduced, modified, or distributed without prior written
authorization of Ceragon Networks Ltd.
This document is provided as is, without warranty of any kind.

Registered TradeMarks
Ceragon Networks is a registered trademark of Ceragon Networks Ltd.
FibeAir is a registered trademark of Ceragon Networks Ltd.
CeraView is a registered trademark of Ceragon Networks Ltd.
Other names mentioned in this publication are owned by their respective holders.

TradeMarks
CeraMapTM, PolyViewTM, EncryptAirTM, ConfigAirTM, CeraMonTM, EtherAirTM, and MicroWave
FiberTM, are trademarks of Ceragon Networks Ltd.
Other names mentioned in this publication are owned by their respective holders.

Statement of Conditions
The information contained in this document is subject to change without notice.
Ceragon Networks Ltd. shall not be liable for errors contained herein or for incidental or
consequential damage in connection with the furnishing, performance, or use of this
document or equipment supplied with it.

Information to User
Any changes or modifications of equipment not expressly approved by the manufacturer
could void the users authority to operate the equipment and the warranty for such equipment.
Copyright 2009 by Ceragon Networks Ltd. All rights reserved.

Corporate Headquarters:
Ceragon Networks Ltd.
24 Raoul Wallenberg St.
Tel Aviv 69719, Israel
Tel: 972-3-645-5733
Fax: 972-3-645-5499
Email: info@ceragon.com
North American Headquarters:
Ceragon Networks Inc.
10 Forest Avenue,
Paramus, NJ 07652, USA
Tel: 1-201-845-6955
Toll Free: 1-877-FIBEAIR
Fax: 1-201-845-5665
Email: infous@ceragon.com

www.ceragon.com

European Headquarters:
Ceragon Networks (UK) Ltd.
4 Oak Tree Park, Burnt Meadow Road
North Moons Moat, Redditch,
Worcestershire B98 9NZ, UK
Tel: 44-(0)-1527-591900
Fax: 44-(0)-1527-591903
Email: infoeuro@ceragon.com
APAC Headquarters:
Ceragon Networks APAC
(S'pore) Pte Ltd
100 Beach Road
#27-01/03 Shaw Towers
Singapore 189702
Tel.: 65 65724170
Fax: 65 65724199

Contents

General .......................................................................................................... 1
Basic Commands.......................................................................................... 1
Basic System Configuration ........................................................................ 3
Navigating between Stacked Units.............................................................. 4
TDM Trail Management................................................................................. 5
TDM Protected Trails (SNPC)......................................................................10
Showing TDM Trail PMs and Status ...........................................................12
Ethernet Switch Application Configuration...............................................13
Management Ports.......................................................................................14
VLAN Configuration.....................................................................................16
QoS Configuration .......................................................................................16
Auxiliary Channels.......................................................................................19
Automatic State Propogation, 1+0 Configuration Only ............................20
Metro Switch and Port Type Configuration ...............................................20
Radio Script Configuration .........................................................................22
Radio Parameter Configurations ................................................................23
NTP................................................................................................................25
SNMP ............................................................................................................26
CFM ...............................................................................................................29

General
This guide provides instructions for specific FibeAir IP-10 CLI based operations. The document is
updated for software release 6.5CA.
CLI (Command Line Interface) is used to perform IP-10 configuration and obtain system statistical and
performance information.
Using the CLI, you can perform configuration operations for stand-alone IP-10 units or units connected in a
stacked configuration, as well as configure several IP-10 units in a single batch command.
In a stacked configuration, all commands are available both in the main and extension units unless
otherwise stated.

Basic Commands
The following basic commands are available when you first log in, if you belong to the Operator user
group:
ls

List entities

get

Get parameter

set

Set parameter

help

Help

cd

Change directory

exit

Exit CLI

logout

Logout from CLI

cli-ver

CLI version

cls

Clear screen

shell

Enter secondary shell

write

Write the current switch configuration to the configuration file

show-tree

Show entity tree

find

Search for a string in the parameter's entity name and information fields

lsp

List entity parameters and commands

echo

echoing free text to the console

In order to get help on a specific command, add a question mark or the parameter --help after the
command.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

In addition, you can use the up and down arrow keys, or the q key, when the word END appears at the
end of the screen.
Note: To perform the operations in this guide, you should log in as follows:
User: admin or operator
Password: admin

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

Basic System Configuration


Setting IP Addresses
To define a new IP address, do the following at the main unit:
1. Log in as follows:
User: admin or operator
Password: admin
2. At the command prompt, type: cd management/networking/ip-address/, and press Enter.
3. Type: get ip-address, and press Enter. This will give you the current IP address.
4. Type: set ip-address <ip> (the new IP address), and press Enter.

Adding Users
To define a new user, do the following:
1. Log in.
2. At the command prompt, type: cd management/mng-services/users/, and press Enter.
3. Type: add-user <name> <group> <password aging days> <expiration date>, and press Enter.
4. Type the password for the new user.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

Navigating between Stacked Units


Going from the Main Unit to a Different Unit
After log-in, a prompt always appears at the main unit. Tto change the prompt to a different unit, do the
following:
1. Log in.
2. At the command prompt, type: cd /platform/shelf-manager/, and press Enter.
3. Type: logon-unit <slot number>, and press Enter.
The prompt will change according to the relevant slot ID. For example, the prompt for a unit located in slot
3 will show:
IP-10-SLOT-3:/>

Returning to the Main Unit


In order to go back to the main unit, do the following:
1. Log in.
2. At the command prompt, type: cd /platform/shelf-manager/, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

TDM Trail Management


Defining a TDM Trail
To define a TDM trail, do the following at the main unit:
1. Log in.
2. At the command prompt, type: cd /interfaces/pdh/trails/, and press Enter.
3.

Type: add-trail <trail ID> <trail desctiption> <ACM priority> <operational/reserved>


<protected/unprotected> <interface 1 slot #> <interface 1 type> <interface 1 number> <interface
2 slot #> <interface 2 type> <interface 2 number>, and press Enter.

Argument Description:

Trail-ID: up to 16 alphanumeric characters

Trail description: string of up to 32 characters

ACM priority: high or low

Operational/reserved: reserved trails are introduced in the database and the bandwidth wont be
used for TDM traffic (it may be used for ethernet traffic) but traffic does not flow. For operational
trails, bandwidth is fully allocated and traffic flows.

Protected/unprotected: unprotected trails map between two interfaces only. Protected trails map
between an end-point interfaces and two other interfaces, the first of which is the primary path and
the second of which is the secondary path (see the SNCP section below).

Interface slot: slot number of the IDU containing the interface (from 1 to 6).

Interface type: line (E1/T1) or radio

Interface number: the number of the E1/T1 interface or radio VC to be used.


o

For E1/T1 it can be 1 to 32 (1 to 16 if no extra 16 E1 T-card is installed)

For radio, the maximum number depends on the radio script being used

Unprotected trail example:


add-trail id1 desc1 high operational unprotected 1 line 1 1 radio 1.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

XC Configuration for STM-1


The following table lists the STM-1 CLI related parameters. The parameter path in CLI is
/interfaces/sdh/stm1/.

Parameter

CLI Name

Description
The clock source used as a
reference for the outgoing
STM-1 signal.
Enable/disable receiving
and transmitting traffic
through the STM-1
interface

Range
Internal clock,
TDM trail,
Loop timing
Enable or Disable

Enable

Force-mute

STM-1 mute override

Mute, or Unmute

Unmute

Trace-identifierstring-length

Length of the STM-1 signal


J0 trace identifier

In E1 systems:
1 to 15

15 or 62

Transmitted J0
trace identifier string

Transmit-traceidentifier

String used as the


transmitted STM-1 signal
J0 trace identifier

String of length:
(0,trace-identifier-length)

String of
NULLs

Received J0 trace
identifier string

received-traceidentifier

String of length: (0,traceidentifier-length)


Integer (0.255)

String of
NULLs, or
0

Expected J0 trace
identifier string

expected-traceidentifier

String of length:
[0,trace-identifier-length]

String of
NULLs

SDH network management


bytes to be used

D1-D3, D4-D12, None

None

STM-1 interface
transmission behavior
under protection mode

Normal or
Uni-directional MSP

Normal

STM-1 excessive BER


threshold configuration

1E-3, 1E-4, 1E-5

1E-3

STM-1 signal degrade


threshold configuration

1E-6, 1E-7, 1E-8, 1E-9

1E-6

STM-1 signal clock


source

STM1-clocksource

STM1
enable/disable

admin

STM1
transmit/silent
J0 trace identifier
length

SDH management
bytes
Protection mode
STM-1 excessive
BER threshold
STM-1 signal
degrade threshold

SDH-Networkmanagementchannel
Line-txProtectionmode
STM1excessive-berthreshold
STM1-signaldegradethreshold

STM-1 signal J0 trace


identifier actually received
from the interface
String expected to be
received as the STM-1
signal J0 trace identifier

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

Default
Internal
clock

The configuration for XC with an STM-1 interface is the same as that for the E1 interface, with the
following exceptions:
The interface type to write in the CLI is "stm-1", instead of "line". The interface number is the VC-12
slot number. For example, the command:
add-trail t1 d1 high operational unprotected 1 stm-1 3 2 radio 6
will configure a trail between VC-12 number 3 in the STM-1 interface placed in IDU 1, and channel
(VC) 6 in the radio of IDU 2.
CLI interface numbers in the STM-1 are numbered 1-63 for the available VC-12 slots inside the
STM-1.
The numbering of the VC-12 slots is according to the KLM numbering, as defined in ITU-T G.707
clause 7.3, as shown in the following table taken from the standard:
Allocation of TU-n capacity to Time Slots within VC-4

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

View Trails Defined in the System


To see all defined trails, do the following:
1. Log in.
2. At the command prompt, type: cd /interfaces/pdh/trails/, and press Enter.
3. To show all trails, type show-all-trails, and press Enter.
4. To show a specific trail by its ID, type show-trail-by-id <trail ID>, and press Enter.
5. To show a specific trail by its source interface, type show-trail-by-src <interface 1 slot #> <interface
1 type> <interface 1 number>, and press Enter.
The trails will be shown in a table, as follows (this is an example of a trail from E1#1 in slot 2 to radio
VC#1 in slot 3):
================================================================
Legend: s/i/n/- 's'=slot-id 'i'=if-type 'n'=if-num '-'=Empty
s(0..6) i(l=line/r=radio/s=stm-1/c=chain/s=sync_ethernet) n(1..180)
================================================================
Source Dest1 Dest2 Dest3 Dest4

Dest5 Dest6 Dest7 Dest8 Dest9

-----------------------------------------------------------------------------IndexInDb = 1, ID = t1, Desc = d1, Prio = high


Act = operational, TS = (0)
2/l/ 1 3/r/ 1

-----------------------------------------------------------------------------Where 2/l/1 denotes slot 2/line/interface 1.

Deleting Trails
There are several ways to delete trails:
1. Log in.
2. At the command prompt, type cd /interfaces/pdh/trails/, and press Enter.
3. To delete all trails, type del-all-trails, and press Enter.
4. To delete a specific trail by its ID, type del-trail-by-id <trail ID>, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

4. To delete a specific trail by its source interface, type del-trail-by-src <interface 1 slot #> <interface 1
type> <interface 1 number>, and press Enter.

Activating/Deactivating Trails
Trails mode can be toggled between active and reserved, as follows:
1. Log in.
2. At the command prompt, type cd /interfaces/pdh/trails/, and press Enter.
3. To activate/reserve all trails, type act-all-trails, and press Enter.
4. To activate/reserve a specific trail by its ID, type act-trail-by-id <trail ID>, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

TDM Protected Trails (SNCP)


All operations for unprotected trails are available for protected trails as well. The additional operations for
protected trails are described in this section.

Defining a Protected TDM Trail


In order to define a TDM trail, do the following at the main unit:
1. Log in.
2. At the command prompt, type: cd /interfaces/pdh/trails/, and press Enter.
3.

Type add-trail <trail ID> <trail desctiption> <ACM priority> <operational/reserved>


<protected/unprotected> <end-point interface slot #> < end-point interface type> < end-point
interface number> <primary path slot #> < primary path type> < primary path number>
<secondary path slot #> < secondary path type> < secondary path number>, and press Enter.

Argument Description:

Trail-ID: up to 16 alphanumeric characters

Trail description: string of up to 32 characters

ACM priority: high or low

Operational/reserved: reserved trails are introduced in the database and the bandwidth wont be
used for TDM traffic (it may be used for ethernet traffic) but traffic does not flow. For operational
trails, bandwidth is fully allocated and traffic flows.

Protected/unprotected: unprotected trails map between two interfaces only. Protected trails map
between an end-point interfaces and two other interfaces, the first of which is the primary path and
the second of which is the secondary path.

Interface slot: slot number of the IDU containing the interface (from 1 to 6)

Interface type: line (E1/T1) or radio

Interface number: the number of the E1/T1 interface or radio VC to be used.


o

For E1/T1 it can be 1 to 32 (1 to 16 if no extra 16 E1 T-card is installed)

For radio, the maximum number depends on the radio script being used

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

10

Protected trail example:


add-trail id1 desc1 high operational protected 1 line 1 2 radio 1 3 radio 1.

Forcing Trails to Active/Stand-by


Each protected trail can be forced to make either one of its paths active (or none of them), as follows:
1. Log in.
2. At the command prompt, type cd /interfaces/pdh/trails/, and press Enter.
3. To force all trails to one of their paths, type protected-trail-force-active <Id> <path>, and press
Enter.
4. To force a specific trail by its ID type to one of its paths, type protected-trail-force-active-by-id <Id>
<path>, and press Enter.
where:
<Id> - trail ID
<path> - primary, secondary or none

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

11

Showing TDM Trail PMs and Status


Showing TDM Trail PM Measurements
To see the TDM trails end-to-end PM measurements (as measured from this systems interface), do the
following:
1. Log in.
2. At the command prompt, type: cd /interfaces/pdh/trails/, and press Enter.
3. To show PMs of all trails, type show-all-trail-pms, and press Enter.
4. To show a specific trails PMs by its ID, type show-trail-pms-by-id <trail ID> <15 min interval>
<24h interval>, and press Enter.
where: <15min/24h interval> is the interval number to be shown, 0 is the current interval, 1 is the
previous one, and so on. If no interval is selected, the current one will be shown.

Showing TDM Trail Status


To see the TDM trails end-to-end PM measurements (as measured from this systems interface), do the
following:
1. Log in.
2. At the command prompt, type cd /interfaces/pdh/trails/, and press Enter.
3. To show PMs of all trails, type show-all-trail-alarms and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

12

Ethernet Switch Application Configuration


The Ethernet Switch menu includes the Switch Configuration, STP Protocol, STP Configuration, and QoS
& Rate Limiting items.
The Ethernet switching methods include:
Single Pipe - Ethernet switching is disabled, whereby only a single Ethernet interface is used for traffic and
the unit operates as a point-to-point microwave Ethernet radio.
Managed Switch - For Layer 2 802.1Q switching.
Metro switch - Ethernet Q-in-Q provider switch is enabled.
To set the Ethernet switching method, do the following:
1. Log in.
2. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
3. Type: set ethernet-application <Ethernet application type> (Single pipe, Managed switch, or Metro
switch), and press Enter.
4. The system will reset (automatically).

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

13

Management Ports
Setting the Number of Management Ports
1. At the command prompt, type: cd /management/networking/, and press Enter.
2. Type: set number-of-ports <no. of ports> (0-3), and press Enter.
Setting the Management Type (inband, outband, VLAN)
1. At the command prompt, type: cd /management/networking/, and press Enter.
2. Type set type < in-band or out-of-band >, and press Enter.
If you choose in-band, you should configure management VLAN id as follows:
a) At the command prompt, type: cd /management/networking/, and press Enter.
b) Type set vlan <no. of VLAN> (1-4090), and press Enter.
Port Configuration
Flow Control (Single Pipe only)

To enable or disable flow control, do the following


1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set flow-control <on/off>, and press Enter.
Managed Switch Ethernet Ports

To enable or disable port admin, do the following:


1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set admin <enable/disable>, and press Enter.
To set port speed rate, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set ethernet-rate <Rate> (10, 100 or 1000 Mbps), and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

14

To set port duplex, do the following:


1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set duplex < full-duplex / half-duplex > ,and press Enter.
To set auto negotiation on/off, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set auto-negotiation <on/off>, and press Enter.
To set the port type, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set type <access or trunk>, and press Enter.
To set the default VLAN ID, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set vlan <VLAN no.> (1-4090), and press Enter.
To enable or disable port learning, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set learning <enable/disable>, and press Enter.
To add, remove, accept VLANS, do the following:
1. The port type must be trunk.
2. At the command prompt, type cd interfaces/ethernet/bridge/eth-port [port no.]/, and press Enter.
3. Type set-allowed-vlans <add, except, remove> <VLAN no.>, and press Enter.
4. Type set-allowed-vlans < all, no-vlans>, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

15

VLAN Configuration
To add, remove, enable, or disable VLANs, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/, and press Enter.
2. Type vlan <VLAN no.> <add, remove, enable, disable>, and press Enter.
To add or change the VLAN name, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/, and press Enter.
2. Type vlan <VLAN no.> name <VLAN name>, and press Enter.

QoS Configuration
Ingress Classifier

To set classify initial, do the following:


1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set qos-classify-initial < ip-tos, ip-tos-over-vlan-pbits, port, vlan-pbits, vlan-pbits-over-iptos>, and press Enter.
To set classify vid override, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set qos-classify-vid-override <disable, pbit-override, queue-and-pbit-override, queueoverride>, and press Enter.
To set classify mac da override, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type set qos-classify-mac-da-override <disable, pbit-override, queue-and-pbit-override, queueoverride>, and press Enter.
To set classify default, do the following:
1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

16

2. Type set qos-classify-default<1st, 2nd, 3rd, 4th>, and press Enter.


Egress Scheduler

To set Egress scheduler, do the following:


1. At the command prompt, type cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type: set qos-scheduling-scheme < all-queues-hrr, all-queues-strict, fourth-and-third-queuesstrict, fourth-queue-strict >, and press Enter.
Egress Shaper

To set egress shaper, do the following:


1. At the command prompt, type: cd interfaces/ethernet/bridge/eth-port[port no.]/, and press Enter.
2. Type: set qos-egress-shaper on/off, and press Enter.
3. Type: set qos-egress-shaper-rate <rate>, and press Enter.
Policer

To add/remove Policer, do the following:


1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: qos-policer <add, remove> <policer name>, and press Enter.
To add a class to the Policer, do the following:
1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: qos-policer-class <add, remove> <policer class name> <policer name> <matching type: all,
arp, first-queue, second-queue, third-queue, fourth-queue, broadcast, multicast, non-tcp-udp,
tcp-control, tcp-data, udp, unicast, unknown-unicast, unknown-multicast> <rate> <CBS>
<exceed action: drop>, and press Enter.
3. Type: qos-show-policers to verify the data, and press Enter.
QoS Tables

To set VLAN Pbits Priority Remap Table, do the following:


1. At the command prompt, type: cd interfaces/ethernet/bridge/eth-port [port no.]/, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

17

2. Type: qos-set-vlan-pbits-prio-remap <original Pbit> <Remapped Pbit>, and press Enter.


To set VLAN ID to Queue Table, do the following:
1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: qos-vlan-to-queue set/remove <VID> <queue ID: 1st-queue, 2nd-queue, 3rd-queue, 4thqueue >, and press Enter.
To set VLAN Pbits to Queue Table, do the following:
1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: qos-set-vlan-tag-pbit-val <VLAN_Pbit> <queue ID: 1st-queue, 2nd-queue, 3rd-queue, 4thqueue >, and press Enter.
To set IP Pbits to Queue Table, do the following:
1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: qos-set-ip-pbit-val <IP_Pbit> <queue ID: 1st-queue, 2nd-queue, 3rd-queue, 4th-queue>, and
press Enter.
To set IP priority options, do the following:
1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: set qos-ip-tos-tc-pbits-option <diffserv, ip-precedence>, and press Enter.
To set static MAC table, do the following:
1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: qos-static-mac-priority set/remove <MAC address> <dest.port no.[1-8]> <priority [0-7]>
<VLAN ID [1-4090]> , and press Enter.
To set Queue Weights table, do the following:
1. At the command prompt, type: cd interfaces/ethernet/bridge/, and press Enter.
2. Type: qos-set-scheduler-q-weight <queue ID: 1st-queue, 2nd-queue, 3rd-queue, 4th-queue >
<weight:1-32>, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

18

Auxiliary Channels
Wayside Channel

At the command prompt, type: cd interfaces/wayside/, and press Enter.


To set port admin, do the following:
1. Type: set admin <enable/disable>, and press Enter.
To set port rate:
1. Type: set ethernet-rate <10mbps or 100mbps>, and press Enter.
To set auto negotiation on/off:
1. Type: set auto-negotiation <on/off>, and press Enter.
To set port duplex:
1. Type: set duplex <full-duplex or half-duplex>, and press Enter.
User Channel

1. At the command prompt, type: cd interfaces/auxiliary/user-channel/, and press Enter


To set port admin:
1. Type: set admin <enable/disable>, and press Enter.
To set port type:
1. Type: set type asynchronous-<rs232 or v-11>, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

19

Automatic State Propagation, 1+0 Configuration Only


At the command prompt, type: cd interfaces/ethernet/, and press Enter.
To set Automatic state Propagation (also called GBE-mute-override) in Single Pipe application:
1. Type: set-gbe-mute-override <criteria: none, lof-loc, lof-loc-excber, lof-loc-remote, lof-loc-excberremote >, and press Enter.
To set Automatic state Propagation (also called GBE-mute-override) in Managed/Metro application:
1. Type: set-gbe-mute-override <criteria: none, lof, lof-excber, lof-remote, lof-excber-remote >, and
press Enter.
Ethernet Shutdown (Rx) Profile Threshold (when ACM is enabled)

At the command prompt, type: cd radio/mrmc/, and press Enter


To set Ethernet shutdown (Rx) profile threshold:
1. Type: set eth-shutdown-threshold-profile < profile-0 to profile-7 >, and press Enter.

Metro Switch and Port Type Configuration


To set Metro Switch:
1. At the prompt (IP-10:/>), type cd interfaces/ethernet/bridge/, and press Enter.
2. At the new prompt, type set ethernet-application metro-switch, and press Enter.
3. Confirm by typing yes, and press Enter.
The system will restart automatically.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

20

To set the port type (CN/PN):


1. At the prompt (IP-10:/>), type cd interfaces/ethernet/bridge/eth-port[port no.], and press Enter.
2. At the new prompt, type set type customer-network (or provider-network), and press Enter.
To set Default VLAN on CN ports:
1. At the prompt (IP-10:/>), type cd interfaces/ethernet/bridge/eth-port[port no.], and press Enter.
2. At the new prompt, type set vlan <VLAN ID>, and press Enter.
To set Allowed VLANs on PN ports:
1. At the prompt (IP-10:/>), type cd interfaces/ethernet/bridge/eth-port[port no.], and press Enter.
2. At the new prompt, type set-allowed-vlans <add,all,except,no-vlans,remove> <VLAN ID>, and
press Enter.
To set provider port ether type:
1. At the prompt (IP-10:/>), type cd interfaces/ethernet/bridge/, and press Enter.
2. At the new prompt, type set provider-port-ethertype <0x88a8, 0x8100, 0x9100, 0x9200>, and press
Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

21

Radio Script Configuration


To set the radio script:
1. At the prompt (IP-10:/>), type cd radio/mrmc/, then press Enter.
2. At the new prompt, type change-script-cmd < Script's name> < Operational mode> <Maximum
profile> disable-adaptive-power, then press Enter.
Parameter values for the radio script include:
Script Name
10Mbps-6.5MHz-4QAM-Grade-1
155Mbps-26MHz-128QAM-Grade-1
181Mbps-26MHz-256QAM-Grade-1
20Mbps-6.5MHz-16QAM-Grade-1
39Mbps-26MHz-4QAM-Grade-1
39Mbps-6.5MHz-256QAM-Grade-1
47Mbps-9MHz-64QAM-Grade-1
ACM_181Mbps-26MHz-256QAM-Grade-1
ACM_367Mbps-52MHz-256QAM-Grade-1
ACM_42Mbps-6.5MHz-256QAM-Grade-1
ACM_87Mbps-12.5MHz-256QAM-Grade-1
Operational Mode
acm-adaptive-mode
acm-fixed-mode
regular-mode (for non ACM scripts)
Maximum Profile
Note: For ,choose a specific profile for ACM fixed mode . In regular mode only profile-0 is
available.
profile-0
profile-1
profile-2
profile-3
profile-4
FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

22

profile-5
profile-6
profile-7

Radio Parameter Configurations


To set TX frequency:
1. Type cd /radio/rfu/ set tx-freq <frequency in KHz>, then press Enter.
To set RX frequency:
1. Type cd /radio/rfu/ set rx-freq <frequency in KHz>, then press Enter.
To set TX power level:
1. Type cd /radio/rfu/max-tx-level <TX level in dBm>, then press Enter.
To mute/unmute the TX:
1. Type cd /radio/rfu/ set mute-tx <disable/enable>, then press Enter.
To set ATPC reference level:
1. Type cd /radio/rfu/ set atpc-ref-rx-level <reference level in dBm>, then press Enter.
To enable ATPC:
1. Type cd /radio/rfu/ set atpc-admin <enable/disable>, then press Enter.
To set RX level PM threshold1:
1. Type cd /radio/rfu/ set pm-rx-level-threshold-1 <threshold in dBm>, then press Enter.
To set RX level PM threshold2:
1. Type cd /radio/rfu/ set pm-rx-level-threshold-2 <threshold in dBm>, then press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

23

To set TX level PMs threshold:


1. Type cd /radio/rfu/ set pm-tx-level-threshold <threshold in dBm>, then press Enter.
To enable/disale MAC header compression:
1. Type cd /radio/ set mhc-admin <enable/disable>, then press Enter.
To set Link-ID:
1. Type cd /radio/framer/ set link-id <Link-ID number>, then press Enter.
To set radio excessive BER threshold:
1. Type cd /radio/framer/ set radio-excessive-ber-threshold <BER: 1e-3, 1e-4, 1e-5>, then press
Enter.
To set radio signal degrade threshold:
1. Type cd /radio/framer/ set radio-signal-degrade-threshold <BER: 1e-6, 1e-7, 1e-8, 1e-9>, then
press Enter.
To set MSE PMs threshold:
1. Type cd /radio/modem/set mse-threshold <Threshold in dB>, then press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

24

NTP
To set NTP service enable/disable:
1. At the command prompt, type: cd /management/mng-services/time-service/ntp, and press Enter.
2. Type set server 192.168.1.100, and press Enter.
3. Type set admin <enable/disable>, and press Enter.
To set NTP offset from GMT:
1. At the command prompt, type: cd management/mng-services/time-service/, and press Enter.
2. Type set gmt-offset-hours 2, and press Enter.
3. Type set gmt-offset-minutes 0, and press Enter.
To set Daylight Saving Time:
1. At the command prompt, type: cd /management/mng-services/time-service, and press Enter.
2. Type set dst-start-month Apr, and press Enter.
3. Type set dst-start-day 1, and press Enter.
4. Type set dst-end-month Nov, and press Enter.
5. Type set dst-end-day 1, and press Enter.
To set Date and Time, whereby the time and date format are day-month-year,hours:mins:secs:
1. At the command prompt, type : cd /management/mng-services/time-service, and press Enter.
2. Type set time-and-date 10-3-2009,15:00:00, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

25

SNMP
To set SNMP enable/disable:
1. At the command prompt, type: cd /management/mng-protocols/snmp, and press Enter.
2. Type set admin <enable /disable>, and press Enter.
To set the SNMP version:
1. At the command prompt, type: cd /management/mng-protocols/snmp, and press Enter.
2. Type set version v3 (or v1 for SNMP version 1), and press Enter.
SNMP Parameters for SNMP Version 3
To set the security mode to authentication, and the authentication algorithm to sha:
1. At the command prompt, type: cd /management/mng-protocols/snmp, and press Enter.
2. Type change-user-settings user_name_example authentication sha, and press Enter.
3. Enter the SNMPv3 Password: user_password_example, and press Enter.
To set the security mode to authentication-privacy, and the Authentication algorithm to md5:
1. At the command prompt, type: cd /management/mng-protocols/snmp, and press Enter.
2. Type change-user-settings user_name_example authentication-privacy md5, and press Enter.
3. Enter the SNMPv3 Password: user_password_example, and press Enter.
To set the security mode to no-security, and the authentication algorithm to no authentication:
1. At the command prompt, type: cd /management/mng-protocols/snmp, and press Enter.
2. Type change-user-settings no-se-user no-security no-auth, and press Enter.
To set the telnet protocol to enable/disable:
1. At the command prompt, type: cd /management/mng-protocols, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

26

2. Type set telnet-admin <enable/disable>, and press Enter.


To set web GUI to enable/disable:
1. At the command prompt, type: cd /management/mng-protocols, and press Enter.
2. Type set web-admin <enable/disable>, and press Enter.
The following steps are used to define the web protocol that will work with HTTPS
It is important to note the order!
Step 1: Create the NE certificate based on the NE's public key. The public key receives the public key file
through upload.
1. At the command prompt, type: cd /platform/idc-board, and press Enter.
2. Type upload-archive public-key, and press Enter.
You can find your public_key file (such as 192.168.1.18_pub_key) in your host path directory.
Step 2: Download the NE certificate.
Note: Before you download the certificate, copy your NE certificate to your ftp host path directory.
1. At the command prompt, type: cd /platform/idc-board, and press Enter.
2. Type set security-file-format <pem/der>, and press Enter.
3. Type set security-file-type <target-certificate>, and press Enter.
4. Type set security-file-name <MYCERT.crt> (your certificate file name), and press Enter.
5. Type download-archive security-file, and press Enter.
Step 3: (Optional) Download the NE CA's certificate.
1. At the command prompt, type: cd /platform/idc-board, and press Enter.
2. Type set security-file-format <pem/der>, and press Enter.
3. Type set security-file-type <target-ca-certificate>, and press Enter.
4. Type set security-file-name <EssentialSSLCA_2.crt> (your CA-certificate file name), and press
Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

27

5. Type download-archive security-file, and press Enter.


Step 4: (Optional) Set the web-ca-certificate-admin parameter to enable.
1. At the command prompt, type: cd /management/mng-protocols, and press Enter.
2. Type set web-ca-certificate-admin <enable> /<disable>, and press Enter.
Step 5: Set the web-protocol parameter to https.
1. At the command prompt, type: cd /management/mng-protocols, and press Enter.
2. Type set web-protocol <https> /<http>, and press Enter.
Note: Enter the URL in the WEB GUI, such as https://192.168.1.1 to use the https protocol.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

28

CFM
Domain
Under service-oam level
Creation:
IP-10:/interfaces/ethernet/bridge/service-oam> domain add <Domain name> <Domain level [1-7]> , and
press Enter.
Deletion:
IP-10:/interfaces/ethernet/bridge/service-oam> domain remove <Domain name> <Domain level [1-7]> ,
and press Enter.
Domain & Association
Under service-oam level
Creation:
IP-10:/interfaces/ethernet/bridge/service-oam> domain add <Domain name> <Domain level [1-7]>
<Association name> <VLAN ID [1-4090]> , and press Enter.
Deletion:
IP-10:/interfaces/ethernet/bridge/service-oam> domain remove <Domain name> <Domain level [1-7]>
<Association name> <VLAN ID [1-4090]> , and press Enter.
Association
Under service-oam level:
Creation
IP-10:/interfaces/ethernet/bridge/service-oam> association add <Association name> <Domain name>
<VLAN ID [1-4090]> , and press Enter.
Deletion
IP-10:/interfaces/ethernet/bridge/service-oam> association remove <Association name> <Domain name>
<VLAN ID [1-4090]> , and press Enter.
CCM
Under service-oam level
On
IP-10:/interfaces/ethernet/bridge/service-oam> ccm-admin enable <Domain level [1-7]> <VLAN ID [14090]> , and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

29

Off
IP-10:/interfaces/ethernet/bridge/service-oam> ccm-admin disable <Domain level [1-7]> <VLAN ID [14090]> , and press Enter.
Local MEP
Under interfaces level
Creation
1. IP-10:/interfaces/ethernet/bridge/eth-port [x]> mep set < MEP ID [1-8191]> < Domain level [1-7]>
<VLAN ID [1-4090]> < Direction [up/down]> <CCM VLAN Pbit priority [0-7]> , and press Enter.
2. IP-10:/interfaces/ethernet/bridge/eth-port [x]> mep set < MEP ID [1-8191]> < Domain level [1-7]>
<VLAN ID [1-4090]> < Direction [up/down]> , and press Enter.
Deletion
IP-10:/interfaces/ethernet/bridge/eth-port [x]> mep remove < MEP ID [1-8191]> < Domain level [1-7]>
<VLAN ID [1-4090]> < Direction [up/down]> , and press Enter.
Remote MEP
Under service-oam level
Creation
1. IP-10:/interfaces/ethernet/bridge/service-oam> remote-mep set <Remote MEP ID [1-8191]> <Domain
name> <VLAN ID [1-4090]> <MAC address [xx:xx:xx:xx:xx:xx]> , and press Enter.
2. IP-10:/interfaces/ethernet/bridge/service-oam> remote-mep set <Remote MEP ID [1-8191]> <Domain
name> <VLAN ID [1-4090]> , and press Enter.
Deletion
IP-10:/interfaces/ethernet/bridge/service-oam> remote-mep remove <Remote MEP ID [1-8191]>
<Domain name> <VLAN ID [1-4090]> , and press Enter.
MIP
Under interfaces level
Creation
IP-10:/interfaces/ethernet/bridge/eth-port[x]> mip add <Domain level [1-7]> , and press Enter.
Deletion
IP-10:/interfaces/ethernet/bridge/eth-port[x]> mip remove <Domain level [1-7]> , and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

30

Loopback (Ping)
Under service-oam level
1. IP-10:/interfaces/ethernet/bridge/service-oam> ping mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-name <Domain name> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> ,
and press Enter.
2. IP-10:/interfaces/ethernet/bridge/service-oam> ping mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-name <Domain name> <VLAN ID[1-4090]> , and press Enter.
3. IP-10:/interfaces/ethernet/bridge/service-oam> ping mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-level <Domain level[1-7]> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]>
, and press Enter.
4. IP-10:/interfaces/ethernet/bridge/service-oam> ping mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-level <Domain level[1-7]> <VLAN ID[1-4090]> , and press Enter.
5. IP-10:/interfaces/ethernet/bridge/service-oam> ping mep-id <Remote MEP ID[1-8191]> md-name
<Domain name> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> , and press Enter.
6. IP-10:/interfaces/ethernet/bridge/service-oam> ping mep-id <Remote MEP ID[1-8191]> md-name
<Domain name> <VLAN ID[1-4090]> , and press Enter.
7. IP-10:/interfaces/ethernet/bridge/service-oam> ping mep-id <Remote MEP ID[1-8191]> md-level
<Domain level[1-7]> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> , and press Enter.
8. IP-10:/interfaces/ethernet/bridge/service-oam> ping mep-id <Remote MEP ID[1-8191]> md-level
<Domain level[1-7]> <VLAN ID[1-4090]> , and press Enter.
Link Trace
Under service-oam level
1. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-name <Domain name> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> ,
and press Enter.
2. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-name <Domain name> <VLAN ID[1-4090]> , and press Enter.
3. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-level <Domain level[1-7]> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]>
, and press Enter.
4. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mac-address <MAC address
[xx:xx:xx:xx:xx:xx]> md-level <Domain level[1-7]> <VLAN ID[1-4090]> , and press Enter.
5. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mep-id <Remote MEP ID[1-8191]> mdname <Domain name> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> , and press Enter.
6. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mep-id <Remote MEP ID[1-8191]> mdname <Domain name> <VLAN ID[1-4090]> , and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

31

7. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mep-id <Remote MEP ID[1-8191]> md-level


<Domain level[1-7]> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> , and press Enter.
8. IP-10:/interfaces/ethernet/bridge/service-oam> linktrace mep-id <Remote MEP ID[1-8191]> md-level
<Domain level[1-7]> <VLAN ID[1-4090]> , and press Enter.
Auto Link Trace
Under service-oam level:
Creation
1. IP-10:/interfaces/ethernet/bridge/service-oam> auto-linktrace add <Remote MEP ID [1-8191]> mdname <Domain name> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> , and press Enter.
2. IP-10:/interfaces/ethernet/bridge/service-oam> auto-linktrace add <Remote MEP ID [1-8191]> mdname <Domain name> <VLAN ID[1-4090]> , and press Enter.
3. IP-10:/interfaces/ethernet/bridge/service-oam> auto-linktrace add <Remote MEP ID [1-8191]> mdlevel <Domain level[1-7]> <VLAN ID[1-4090]> <VLAN Pbit priority[0-7]> , and press Enter.
4. IP-10:/interfaces/ethernet/bridge/service-oam> auto-linktrace add <Remote MEP ID [1-8191]> mdlevel <Domain level[1-7]> <VLAN ID[1-4090]> , and press Enter.
Deletion
1. IP-10:/interfaces/ethernet/bridge/service-oam> auto-linktrace remove <Remote MEP ID [1-8191]>
md-name <Domain name> <VLAN ID[1-4090]> , and press Enter.
2. IP-10:/interfaces/ethernet/bridge/service-oam> auto-linktrace remove <Remote MEP ID [1-8191]>
md-level <Domain level[1-7]> <VLAN ID[1-4090]> , and press Enter.
CCM Interval
Under service-oam level
Modification
IP-10:/interfaces/ethernet/bridge/service-oam> ccm-interval <interval time: 1-sec, 10-sec, 1-min, 10-min>
<Domain level [1-7]> <VLAN ID [1-4090]> , and press Enter.
: , , , Auto Link Trace Interval
Under service-oam level
Modification
IP-10:/interfaces/ethernet/bridge/service-oam> set auto-linktrace-interval [seconds: range 60-3600] , and
press Enter.
: Remote MEP Learning Time
Under service-oam level

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

32

Modification
IP-10:/interfaces/ethernet/bridge/service-oam> set remote-meps-learning-time [seconds: range 60-3600] ,
and press Enter.
: Ring RSTP
To enable Ring RSTP:
1. Type cd /interfaces/ethernet/bridge/ set stp-protocol ring-rstp, and press Enter.
To set bridge priority:
Type cd /interfaces/ethernet/bridge/ set priority <priority no: range 0-61440, steps of 4096>, and press
Enter.
To set interfaces priority:
Type cd /interfaces/ethernet/bridge/ethe-port[port no.]/ set priority <interface priority no: range:0240, steps of 16>, and press Enter.
To set interfaces patch cost:
Type cd /interfaces/ethernet/bridge/ethe-port[port no.]/ set path-cost <patch cost>, and press Enter.
To set if interface is an edge port or ring port (non-edge port):
Type cd /interfaces/ethernet/bridge/ethe-port[port no.]/ set edge-port <yes/no>, and press Enter.

FibeAir IP-10 CLI Procedures Guide, for Relase 6.5

33

S-ar putea să vă placă și