Documente Academic
Documente Profesional
Documente Cultură
com
INSTALLATION
INSTRUCTIONS
Accessory
Application
2007 ODYSSEY
Publications No.
AII 33173
Issue Date
JULY 2006
PART LIST
Flat-tip screwdriver
Ratchet
10 mm Socket
Drill
3 mm, 6 mm, 8 mm and 10 mm Drill bits
Center punch
File
Blanket
5 Stepped bolts
Masking tape
Isopropyl alcohol
Shop towel
Eye protection (face shield, safety goggles, etc.)
INSTALLATION
Customer Information: The information in this
installation instruction is intended for use only by
skilled technicians who have the proper tools,
equipment, and training to correctly and safely add
equipment to your vehicle. These procedures
should not be attempted by do-it-yourselfers.
2 Washer-nuts
NOTE:
4 Self-tapping screws
4 Spring nuts
08F01-SHJ-1000-91
1 of 5
www.collegehillshonda.com
1.
LONG
CLIP
CLIP (8)
FOG LIGHT
CONNECTOR
FOG LIGHT
CONNECTOR
FRONT BUMPER
BULKHEAD
COVER
4121010Y
2.
4311060Y
FRONT
CORNER
SENSOR
CONNECTOR
FRONT
BUMPER
FRONT
CORNER
SENSOR
CONNECTOR
4728010Y
FRONT
BUMPER
BOLT
CLIP
BOLT
SELF-TAPPING
SCREW
4121021Y
2 of 5
www.collegehillshonda.com
3.
5.
DIMPLE
FRONT
BUMPER
CENTER-PUNCHED
MARKS (2)
FRONT
BUMPER
DIMPLE
DRILL
(3 mm 6 mm
DRILL BIT)
4.
4716011Y
DRILL
(3 mm 8 mm
DRILL BIT)
4716030Y
6.
CENTER
PUNCH
FRONT
BUMPER
DRILL
(3 mm 6 mm
10 mm DRILL BIT)
FRONT
BUMPER
SCRIBE
MARK (7)
CENTER
PUNCH
4716020Y
CENTER-PUNCHED
MARKS (5)
4716040Y
7.
3 of 5
www.collegehillshonda.com
8.
FRONT BUMPER
ADHESIVE BACKINGS (6)
Fold back the ends and tape
them to the surface of the front
under spoiler.
SPRING
NUTS
HOLES
DRILLED
IN STEP 3.
SPRING
NUTS
HOLES
DRILLED
IN STEP 3.
HOLES
DRILLED
IN STEP 3.
9.
SPRING
NUT
FRONT UNDER
SPOILER
4220042Y
4220020Y
SPOILER
BRACKET
FRONT UNDER
SPOILER
SQUARE
HEAD BOLT
Slide onto the
bracket.
FRONT
BUMPER
FRONT UNDER
SPOILER
WASHER-NUTS
4220050Y
4220030Y
4 of 5
www.collegehillshonda.com
13. Secure the front bumper to the front under spoiler
using the five stepped bolts.
STEPPED BOLT
FRONT
BUMPER
SELF-TAPPING
SCREW
Install loosely.
FRONT
UNDER
SPOILER
SELF-TAPPING
SCREW
Install loosely.
4220061Y
BOLTS
(reused.)
4220072Y
FRONT UNDER
SPOILER
SPLASH
GUARD
SELF-TAPPING
SCREW
CLIP
(reused.)
SELFTAPPING
SCREW
(reused.)
FRONT
UNDER
SPOILER
FRONT
BUMPER
SELF-TAPPING
SCREW
4511220Y
BOLTS
(reused.)
CLIP (reused.)
4407060Y
5 of 5
www.collegehillshonda.com
Give a copy this page to your customer.
When towing Odyssey, follow the instructions described in the vehicle Owners Manual.
When using the front towing hook, make sure to remove the front bumper with front under spoiler. Failure to
follow this precaution could damage the vehicle, the front bumper, and the front spoiler.
4727020Y
6 of 5
www.collegehillshonda.com
INSTALLATION
INSTRUCTIONS
Accessory
Application
2007 ODYSSEY
Publications No.
All 33187
Issue Date
JULY 2006
PARTS LIST
1.
Open the front and rear doors. Remove the selftapping screw that fasten the left side sill panel to
the left front inner fender. Slide the side sill panel
forward, then remove it by pulling it out toward
you.
LEFT SIDE
SILL PANEL
26 Seals
FRONT
LEFT FRONT
INNER FENDER
SELF-TAPPING
SCREW (Reuse.)
2.
INSTALLATION
LEFT SIDE
SILL PANEL
4114010Y
NOTE:
Turn 45 to
remove.
FRONT
LEFT SIDE SILL
CLIPS (13)
(Reused.)
08F04-SHJ-1000-91
4114020Y
1 of 2
www.collegehillshonda.com
3.
5.
CLIPS (8)
(Center align the
clip with the rib.)
CUTOUT
RIBS (8)
FRONT
LEFT SIDE
UNDER SPOILER
SQUARE
HOLE
LEFT SIDE
UNDER
SPOILER
6.
4114050Y
CLIP
CUTOUT
LEFT FRONT
INNER FENDER
4.
4114031Y
SELF-TAPPING
SCREW (Reused.)
7.
CLIPS
(13)
OLD SEAL
(Replace.)
SEAL
2 of 2
SIDE UNDER
SPOILER (LEFT)
4114060Y
4114040Y
www.collegehillshonda.com
INSTALLATION
INSTRUCTIONS
Accessory
Application
2007 ODYSSEY
Publications No.
AII 33181
Issue Date
JULY 2006
PARTS LIST
Flat-tip screwdriver
Ratchet
10 mm Socket
Drill
3 mm, 8 mm, and 10 mm Drill bits
Clip remover
Felt-tip pen
File
Isopropyl alcohol
Shop towel
Masking tape
Blanket
Pushpin
Eye protection (face shield, safety goggles, etc.)
INSTALLATION
2 Self-tapping screws
NOTE:
15 Washer-nuts
2 Spring nuts
4 Adhesive Collars
08F03-SHJ-1000-91
1 of 5
www.collegehillshonda.com
1.
2.
SELFSELF-TAPPING
TAPPING
SCREW
SCREWS (4) (If equipped with
inner fender.)
MARK NOT
USED
(Do not
pierce
through
this mark.)
MARK NOT USED
(Do not pierce
through
this mark.)
BOLTS (4)
BOLT
COVERS
(4)
3.
REAR
BUMPER
SELF-TAPPING SCREW
(If equipped with
inner fender.)
CLIP
REAR
BUMPER
REAR
BUMPER
4727030Y
REAR UNDER
SPOILER MARK
(Mark in the same
position on the
other side.)
4120011Y
DRILL
(First drill with
a 3 mm drill
bit and finish
with an 8 mm
drill bit.)
MARKED
AREA (6)
4211031Y
REAR
BUMPER
2 of 5
www.collegehillshonda.com
4.
7.
ADHESIVE COLLAR
ATTACHMENT POINT
DRILL
(First drill with
a 3 mm drill bit
and finish with
a 10 mm drill
bit.)
ADHESIVE
BACKING
MARKED
AREA (7)
ADHESIVE
COLLAR
ATTACHMENT
POINT
REAR
BUMPER
ADHESIVE
COLLAR ADHESIVE
SLOT
COLLAR
ADHESIVE COLLAR
ATTACHMENT POINT
4508020B
5.
REAR UNDER
SPOILER
8.
4211052Y
BRACKET
ADHESIVE
BACKINGS (5)
(Fold the ends
back, and tape
the ends to
the outer surface
of the under
spoiler.)
SPRING NUT
DIMPLE
SPRING NUT
DIMPLE
REAR
UNDER
SPOILER
SQUARE HEAD
BOLTS (6)
6.
9.
4414012Y
4526020Y
3 of 5
www.collegehillshonda.com
10. Position the rear under spoiler on the rear bumper,
and install a washer nut to each square-head bolt.
Tighten the washer-nuts in the order shown.
REAR BUMPER
REAR BUMPER
REAR BUMPER
REAR UNDER
SPOILER
REAR UNDER
SPOILER
REAR BUMPER
REAR UNDER
SPOILER
SELF-TAPPING
SCREW
REAR
UNDER
SPOILER
SHORT
STEPPED
BOLT
LONG
STEPPED
BOLT
SHORT
STEPPED
BOLT
4719030Y
REAR
BUMPER
4212021Y
SELF-TAPPING
SCREW
REAR UNDER
SPOILER
4 of 5
www.collegehillshonda.com
Give a copy of this page to your customer.
When towing the Odyssey, follow the instructions described in the vehicle Owners Manual.
When using the rear towing hook, make sure to remove the rear bumper with rear under spoiler. Failure to
follow this precaution could damage the vehicle, the rear bumper, and the rear spoiler.
4727010Y
5 of 5