Sunteți pe pagina 1din 4

cooling and heating faqs

We understand you have a lot of concerns about your HVAC system and we hope this will assist
you find the answers to them. Here is a list of the frequently asked questions:
1. Should my air conditioning unit be covered?
During winter season, you can cover the condenser unit only a couple of inches of the side given
that there ought to be adequate space to enable wetness to evaporate. Covering it will definitely
avoid leaves, dirt or any other particles from going in the unit.
Make sure that it is uncovered all year long if you have a heat pump.
2. How does cooling work?
Central air conditioning works by moving the heat from the air inside to outside of your home.
Cooled and conditioned air is being re-circulated. The compressor pumps the refrigerant back and
forth to absorb heat and moisture from the inside. The cycle goes on up until the thermostat is
pleased and it shuts the system off.
3. Exactly what's NATE?
Nate or North America Specialist Quality Inc., is an independent body for COOLING AND
HEATING service technicians. They provide certification of 5 specialty areas: air distribution, heat
pumps, air conditioning, oil heating and gas heating.
4. What's zoning?
Zoning is when you use existing devices and set up thermostats in various places to control the
temperature level more exactly in those places. This is most useful in 2 story houses with only 1
central air conditioning system.
5. What's SEER?
SEER or Seasonal Energy Performance Ratio is the rating of a devices's efficiency. The higher
the rating, the less the device will cost to work. The efficiency of units is managed by Department
of Energy and is governed by US law.
You get SEER by dividing the cooling output to electrical power energy consumed.
6. Exactly what is Puron?
R-22 which is the standard refrigerant that is being utilized in the majority of air conditioning unit
and heat pumps has actually been phased out by the 1990 Clean Air Act.

Due to the fact that it is environment safe and energy effective, Puron Refrigerant is exceptional
to R-22. That being stated, the Puron refrigerant has actually been globally accepted for cooling
and heating.
7. Should I utilize Puron Refrigerant?
In upgrading your air conditioner or heat pump, Puron refrigerant is very energy-efficient.
Updating to Puron now can prevent potential increase in the expense of maintenance heat pumps
and air conditioners given that United States federal government has restricted future production.
8. How long should my air conditioning system last?
An air conditioning system or a heating system usually last for about 10-15 years. Sometimes,
changing an older system is much better as newer systems offer higher performance. Know that
life span can differ greatly and that proper upkeep will not just take full advantage of effectiveness
however safeguard your investment.
9. Exactly what is a 2 stage heating?
A heating system that has 2 levels of heat output (high for winter days and low for mild days) is a
2-stage heating. A device with 2 phase heating runs longer and supplies a more even distribution
of heat since it works on low level the majority of the time.
The advantages of longer, low-capacity operation are the following:
a. It removes temperature level swings that are associated with standard heating systems,
regulating the temperature level to as low as 1 degree of the setting.
b. There will be no fast burst of air considering that it begins in the First page where there is low
demand of heat.
c. The filter traps more contaminants on low-speed operation.
d. There is less fuel being burned due to a lower-capacity first stage, unlike a standard heating
system that will go for full capacity upon starting.
10. Exactly what's HSPF?
HSPF or Heating Seasonal Efficiency Element is a measurement for the efficiency of a heat
pump's heating portion.
11. What's AFUE?
AFUE or Yearly Fuel Utilization Performance is the score for heating systems. It's the

percentage of heat that is being utilized for every dollar of fuel that is being taken in. The greater
the score, the lower the fuel will cost. Heaters that are being produced today must have at least
78 percent AFUE.
Example: a 60 percent reliable heating system uses only 60 percent to heat you house. The
staying 40 percent will go up the chimney.
12. Exactly what is a heat pump?
A heat pump is a system that can warm and work as an air conditioning system. As an air
conditioning unit, the heat pump takes the heat inside the space and declines it outside. The
procedure reverses during colder weather condition.
Keep in mind that even when it's incredibly cold outside, the air still has heat and that's what the
heat pump requires to move within. If there's inadequate heat, the electrical heating unit will
supplement the air to provide heat.
13. What is a BTU and how much do I need?
When referring to the heating capability (or size) of an air conditioner, BTU or British Thermal
Device is the device used. The size depends on elements such as effectiveness scores, size of
existing unit, and insulation.
14. Exactly what is hybrid heating?
When a heat pump and a gas furnace pair, that's when you have hybrid heating or dual fuel. The
heat pump is the main system for heating and cooling; nevertheless, when it's no longer efficient
for the heat pump to operate due to a drop in the temperature, the gas heating system takes over.
15. What is 2-stage cooling?
If your heat pump or ac unit's compressor has 2 levels of operation (high for summer and low for
milder weather), you have a 2-stage cooling. Much like the 2-stage heating, it will produce a more
even temperature level and will run for a longer time. A 2-stage a/c unit will have a more effective
and quieter operation. Together with that, it can dehumidify the air two times as much as a singlestage device can.
Ac unit are important in one's house and we hope we have provided the answers to your most
frequently asked questions.

Central air conditioning works by transferring the heat from the air inside to outside of the house.
They offer accreditation of 5 specialty locations: air distribution, heat pumps, air conditioning, oil
heating and gas heating.
A heat pump is a system that can heat up and work as an air conditioner. As an air conditioner,
the heat pump takes the heat inside the room and rejects it outside. The heat pump is the main

system for heating and cooling; however, when it's no longer efficient for the heat pump to
operate due to a drop in the temperature, the gas heater takes over.
http://heatingandcoolingblogger.angelfire.com/

S-ar putea să vă placă și