Documente Academic
Documente Profesional
Documente Cultură
SUNWAVE Repeater
CONTENT
1. OMT Installation....................................................................................................... 3
Hardware ............................................................................................................. 3
Installation procedure........................................................................................ 3
2. Operation ................................................................................................................ 7
Hardware Preparation....................................................................................... 7
Start Program....................................................................................................... 7
Remote Connection... 8
Local Connection (use data cable connection) 14
1.
OMT Installation
After installation of the repeater, the Operation & Maintenance Terminal shall be used to
initialize and control the repeater setups by enquiring, changing and monitoring over
various repeater sites and engineering parameters. OMT can be connected by local,
remote data or SMS modes, allowing real time monitoring and maintenance over
repeaters.
Hardware
Minimum Hardware configuration for OMT installation
32M RAM
COM Port
Hays Modem
Installation procedure
Make sure there is no other application running, and:
If the auto run file is not started, open the CD-ROM directory and click
setup.exe to start installation.
Figure 1-1
Figure 1-2
Figure 1-3
Figure 1-4
Figure 1-5
2.
Operation
This part introduces how to configure and setup for local and remote connection for
Hardware Preparation
Follow the next steps:
Local Control:
1. Turn on the repeater.
2. Turn on the PC.
3. Connect PC to the RS232 serial port in repeater
with RS232 Data cable. Set the COM Port in use
in OMT. Press Connect to connect OMT/PC and
Repeater.
Remote Control:
1. Connect OMT/PC and the modem with PC.
2. Install a SIM card and turn on the repeater
3. Turn on the modem and PC
Start Program
Start OMT. Choose OMT from Start menu, or double click the OMT icon on desktop.
The window See Figure 1-6 pops up after running the program.
Figure 1-6
Remote Connection:
1). Click system Connect Config see Figure 1-7
Figure 1-7
2). Configure the Connection Config as Figure 1-8:
SUNWAVE COMMUNICATION CO., LTD
z
z
z
z
Figure 1-8
Figure 1-9
3). Click Identify to connect the repeater. See Figure 1-10, after that, see Figure 1-11
Figure 1-10
Figure 1-11
10
Figure 1-12
5). Set the Query/Control Phone No.1 and Alarm Phone No.1 as the SIM card number
inside the modem connecting with OMT. See Figure 1-13
Figure 1-13
6). How to Query data.
z Select the item you want query, click query. As Figure 1-14
11
Figure 1-14
Figure 1-15
12
Figure 1-16
Example 2. Set Through Mode. Once the Through mode on, then the ICM will be
Bypass. If it is off, then ICM work normally. See Figure 1-17
Figure 1-17
13
Example 3. Set ICM Setting. Turn on the DL/UL Cancellation Mode to turn on the
ICM. As Figure 1-18
Figure 1-18
Local Connection (use data cable connection):
1). Click system Connect Config see Figure 1-19
Figure 1-19
14
Figure 1-20
Figure 1-21
The rest part (query and set) is totally same as the remote monitoring.
15
Note:
1. When use remote monitoring (SMS). It is better query one data per time to ensure the
rapid feedback. It is not suggest to Select All.
2. For the remote monitoring using CDMA modem. Sunwave OMT just support few
CDMA Modem by now. Like ZTE AC 2736.
3. Enter the factory mode first before you want to set the data.
16