Documente Academic
Documente Profesional
Documente Cultură
Fiberstore (FS.COM) | Fiber Optic Transceivers Supported for Juniper EX4200 Switch
WHITE PAPER
Fiberstore (FS.COM) | Fiber Optic Transceivers Supported for Juniper EX4200 Switch
WHITE PAPER
When an SFP+ or SFP+ MACsec uplink module is operating in 10-gigabit mode, only the 10-gigabit
ports (ports 0 and 2) are enabled and you can use only SFP+ transceivers in those ports. When an
SFP+ or SFP+ MACsec uplink module is operating in 1-gigabit mode, all four ports are enabled and
you can use only SFP transceivers in all four ports.
XFP Uplink Module
The figure below shows the XFP uplink module, which provides two ports for 10-gigabit XFP
transceivers. You can install XFP transceivers in these two ports.
Fast Ethernet SFP transceiver modules supported for Juniper EX4200 switches
Fiberstore (FS.COM) | Fiber Optic Transceivers Supported for Juniper EX4200 Switch
WHITE PAPER
Gigabit Ethernet SFP transceiver modules supported for Juniper EX4200 switches
10-Gigabit Ethernet SFP+ transceiver modules supported for Juniper EX4200 switches
10-Gigabit Ethernet XFP transceiver modules supported for Juniper EX4200 switches
Fiberstore (FS.COM) | Fiber Optic Transceivers Supported for Juniper EX4200 Switch
WHITE PAPER
Contact Us
Manufacturing R & D (China)
Follow us
LinkedIn
Twitter
Facebook
G+
Pinterest
Youtube
Blog
Notice: This document is for informational purposes only and does not set forth any warranty, expressed or
implied, concerning any equipment, equipment features, or service offered or to be offered by Fiberstore.
Fiberstore reserves the right to make changes to this document at any time, without notice, and assumes no
responsibility for its use. This information document describes features that may not be currently available.
Contact a Fiberstore sales team for information on feature and product availability.
Fiberstore (FS.COM) | Fiber Optic Transceivers Supported for Juniper EX4200 Switch