Documente Academic
Documente Profesional
Documente Cultură
JCRIIFTSMI NJ
GRASS CATCHER
42" Mower
Model No.
917.249791
CAUTION:
Read and follow all Safety
Rules and Instructions
before operating this
equipment.
Sears,
Roebuck
and Co.,
Hoffman
Estates,
Safety
Assembly
Operation
Customer Responsibilities
Repair Parts
II 60179
U.S.A.
SAFETY RULES
&
Safe Operation
Practices
for Ride-On
Mowers
&
IMPORTANT:
THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING
HANDS AND FEET AND THROWING OBJECTS.
FAILURE TO OBSERVE THE FOLLOWING
SAFETY INSTRUCTIONS
COULD RESULT IN SERIOUS INJURY OR DEATH,
I. GENERAL OPERATION
DO NOT:
Read, understand, and follow all instructions in the manual
Donottrytostabilizethemachinebyputtingyourfootonthe
Never carry passengers. ......
ground.
Do n_ mo_; Jn_rev'erse-unless
absolutely necessary. Always
IlL CHILDREN
Tragic accidents can occur if the operator is not alert to the
presence of children. Children are often attracted to the machine
and the mowing activity. Neverassume that children will remain
where you last saw them.
Keep children out of the mowing area and under the watchful
care of another responsible adult.
Be alert and turn machine off if children enter the area.
Before and when backing, look behind and down for small
children.
IV. SERVICE
Use extra care in handling gasoline and other fuels.
are flammable and vapors are explosive.
Use only an approved container.
They
DO:
Mow up and down slopes, not across.
Remove obstacles such as rocks, tree limbs, etc.
Watch for holes, ruts, or bumps.
Uneven terrain could
overturn the machine. Tall grass can hide obstacles.
Use slow speed. Choose a low gear so that you will not have
to stop or shift while on the slope.
Follow the manufacturer's
recommendations
for wheel
weights or counterweights to improve stability.
Use extra care with grass catchers or other attachments.
These can change the stability of the machine.
Keep all movement on the slopes slowand gradual Do not
make sudden changes in speed or direction.
Avoid starting or stopping on a slope. If tires lose traction,
disengage the blades and proceed slowly straight down the
slope.
SAFETY RULES
&
Safe Operation
Practices
for Ride-On
&
Look for this symbolto point out important safety precautions. It means CAUTION!It
BECOME ALERTI!!
YOUR
SAFETY IS INVOLVED.
Mowers
&
CAUTION:
In order to prevent
accidental starting when setting up,
transporting, adjusting or making
repairs, always disconnect sperk plug
wire and place wire where it cannot
contact spark plug.
CONGRATULATIONS on your purchase of a new Grass Catcher. It has been designed, engineered and manufactured to give
you the best possible dependability and performance.
Should you experience any problems you cannot easily remedy, please contact your nearest authorized service center/
department. They have competent, well trained technicians and the proper tools to service or repair this unit.
Please read and retain this manual. The instructionswill enable you to assemble and maintain your Grass Catcher properly.
Always observe the "SAFETY RULES".
STORAGE ...................................................................
10
WARRANTY ................................................................
10
REPAIR PARTS ......................................................
12-13
UNPACKING
TOOLS
INSTRUCTIONS
CARTON
FOR ASSEMBLY
CONTENTS:
(2) ContainerTops
(2) Container Bottoms
(1) Upper Chute
(1) Lower Chute
PARTS
REQUIRED
IDENTIFICATION
COVER
UPPER CHUTE
FULL
INDICATOR
LATCH
GRASS
CATCHER
CONTAINERS
LOWER
CHUTE
LOWER CHUTE
ATTACHING
STRAPS
NOTE: When right hand (R.H.) and left hand (L.H.) are mentioned in this manual, it means when you are seated on the tractor,
in the operator's position.
CAUTION:
Place gearshift/motion
Disconnect spark plug wire from spark plug and placewire whereit cannot come in contact with
plug.
BAGGER
SUPPORT
ASSEMBLY
MOUNTING
SUPPORT
COVER
ASSEMBLY
ASSEMBLY
(See Fig. TO
2)
SHOULDER
BOLTS
1.
2.
3.
COVER
ASSEMBLY
FIG. 1A
If your tractor does not have four (4) shoulder bolts installed
on the drawbar, follow the instructionsbelow.
1.
2.
SUPPORT
ASSEMBLY
LF
TAPPING
SHOULDER
BOLTS
FIG. 1B
TO REMOVE THE SUPPORT ASSEMBLY (See Fig. lC)
1.
FIG. lC
TO
FIG. 2
1.
2.
CONTAINER
MOUNTING
No hardware
required (See Fig. 4)
CONTAINER
ASSEMBLY
(See Fig. 3)
No hardware
required
Place bottom half inside of top half, as shown.
Place one foot inside bottom half and lift top half to meet
bottom half.
1.
3.
2.
CONTAINER
WARNING
HALF
CONTAINER
TOP HALF
CONTAINER
BOTTOM
CONTAINER
HANDLE
HALF
SUPPORT
TUBE
PRESS TOGETHER
TO FORM SEAL
WHILE LIFTING
TOP HALF
CONTAINER
WARNING
LOCKING
TAB
FIG. 4
ASSEMBLY CHECK: Squeeze sides of lower half of container and check that there is no gap between upper and
lower halves. If a gap appears, unlock tabs to separate
container halves and repeat instructions above.
FIG. 3
1.
2.
3.
4.
OPTIONAL
LOWER
Fig. 5)
No CHUTE
hardware (See
required
GAUGE _
WHEEL
AND
BRACKET
AUGN CHUTE'B"
WITH MOWER"B"
PUSH IN
DEFLECTOR SHIELD
HINGE BRACKET
FIG. 5
DEFLECTOR
SHIELD
REAR GAUGE
WHEEL
BRACKET
FRONT
LATCH
WITHREAR
GAUGEWHEELS
REAR
WITHOUT
GAUGE WHEELS
LATCH
REAR
LATCH
1.
2.
LEVEL
No MOWER
hardware DECK
required
UPPERNo CHUTE
Figs. 6A & 6B)
hardware (See
required
Lower mower deck to its lowest cutting position,
Assemble upperchute by insertingcurved end into hole
in back of cover.
Be sure deck is properly leveled for best mower performance. See your tractors owner's manual for instructions.
4.
5.
FULL
BAG
HANDLE
COVER
UPPER
CHUTE
LOWER
FIG. 6A
ALIGNMENT
SLOT
LATCH
PIN
RUBBER
LATCH
BOSSES
FIG. 6B
BAGGING
OPERATION:
in your tractor
Removeonecontainer at atime bygrasping container handles and pulling toward the rear, off of the
tube rails.
f.
CAUTION
GENERAL
STORAGE
RECOMMENDATIONS
BLADE
CARE
Expendable items which become worn during normal use, such as bags or mower blades.
Repairs necessary because of operator abuse or negligence, including the failure to maintain the equipment
according to instructions contained in the owner's manual.
WARRANTY SERVICE IS AVAILABLE BY RETURNING THE CRAFTSMAN GRASS CATCHER TO THE NEAREST
SEARS SERVICE CENTER/DEPARTMENT
IN THE UNITED STATES. THIS WARRANTY APPLIES ONLY WHILE
THIS PRODUCT IS IN USE IN THE UNITED STATES.
This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.
SEARS, ROEBUCK AND CO., D/817 WA, HOFFMAN ESTATES, ILLINOIS. 60179
10
NOTES
11
GRASS
CATCHER-
- MODEL
NUMBER
917.249791
5
6
7
8 9
10
91213
14
18
20
20
2
/
2
15
16
15
21
35
\
14
16
31
31
31
36
25
KEY
NO.
PART
NO.
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
18
20
21
22
23
69180
127533
161312
126840
18021008
130933
87175
19061216
7206J
60867
10071000
109808X
2029J
130760
130759
162803
71161010
132796
133235
132983
DESCRIPTION
Nut, Crownlock #10-24
Screen, Cover
CoverAsm. (Incl. 3,38,39)
Chute, Upper
Screw, Special #10-14 x 1/2
Full Bagger Indicator
Screw, #10-24 x 1-1/8
Washer 3/16 x 3/4 x 16 Ca.
Spacer, Split
Nut, Acorn #10-24
Washer, lock
Latch, Chute
Nut, Weld
Latch, Hook
Rubber, Latch
Chute, Lower
Screw #10-24 x 5/8
Spring, Cover L.H. (black)
Spacer, Cover
Spring, Cover R.H. (gray)
KEY
NO.
24
25
26
27
28
29
31
32
33
34
35
26
38
39
--
PART
NO.
180923
73800400
4939M
72140405
179745
170165
174083
179746
128600
127534
129584
129586
130895
155042X431
183233
DESCRIPTION
Support Assembly
Locknut
Spring, Retainer
Bolt
Bracket, Stop
ShoulderBolt
Plug, Tubing End
Bagger, Frame
Pin, Hinge
Gasket, Cover
Container, Top
Container, Bottom
Latch Handle, Cover
Strip, Reinforcement
Owner's Manual
NOTES
14
NOTES
15
Ar_t_ne,dayorniglt
(U.S.A.andCanada)
w.$eallJ.ca
w.lmall_com
AnyOne,
dayorng_ (U.SAody)
_m
(1-800-366-7278)
(U.SJ_.only)
www_rect
(U.SA)
1-800-361-6665
(Canada)
Parapedrse_dodereparad_a
AuCanada
poursen_ce
enfra'K:as:
dornkJo,y paraordenarpieza_
1-888.SU.HOGARsM
1-800-LE-FOYERMc
(1-800-533-6g3_
_/w
SeB/s.ca
HomeCentral
J
Sea_ Roebu_andCo
Registered Trademark /
Marca Registrada
MCMarque
18323302 26 02 rad
de commerce
TM
Trademark /
SM
deposee
de Sears, Roebuck
and Co
and Co
PRINTED IN U.S A.