Sunteți pe pagina 1din 5

DESIGN OF INTELLIGENT STREETLIGHT MONITORING

SYSTEM BASED ON MICRO CONTROLLER

AIM:
The main aim of this project is to design an intelligent streetlight monitoring system.

PURPOSE:
The purpose of this project is to design an intelligent streetlight monitoring system.

BLOCK DIAGRAM:
CONTROL SECTION:

Power supply
RF
RECEIVER

MICRO
CONTROLLER

GSM

MAX
232

DECODER

MAIN SECTION:
LCD
POWER
SUPPLY

CURRENT
SENSOR

Micro
controller

A
D
VOLTAGE
SENSOR

C
RF
TRANSMITTER

ENCODER

LOAD

POWER SUPPLY:

Step Down
Transformer

Bridge
Rectifier

Filter
Circuit

Regulator
section

DESCRIPTION:
RF TECHNOLOGY:
Now-a-days technology has developed to a large extend. At the same time the need for
systems with automation and high security are preferred. So, by using one of the best
technologies available i.e. RF we are designing an automatic power meter reading system for
commercial and domestic purposes. For paying electricity bills we have to go to e-seva for
paying the bills, this is very time consuming process and in electrical department side there may
be a chance of errors in noting the units and issue of monthly bills. By using this project we can
avoid such problems.
The system is consists of RF digital Power meters installed in every consumer unit and an
electricity system at the energy provider side. The RF Digital Power Meter is a single phase
digital kWh power meter with embedded RF encoder and decoder which utilizes the RF network
to send its power usage reading using encoder back to the energy provider wirelessly. A working
prototype of the system was build to demonstrate the effectiveness and efficiency of automatic
meter reading, billing and notification through the use of RF network.
This project is aimed to develop a system to provide security by intimating the condition of
energy meter reading to the control section. There are two sections in this project, makes use of a
RF transmitter to send the messages resembling the condition.
The main objective of this project is to design a wireless energy meter system with the help
of RF technology. For measuring energy consumed by the user we are going to use current and
voltage sensing circuit, at the same time sensors data will be displayed in LCD and automatically
one message will send through RF communication to the control section. In this project we are
using bulb as a load. On LCD we are going display sensors data. if limit of the sensor data
exceed then SMS will be send to the owner.

GSM TECHNOLOGY:

Every system is automated in order to face new challenges in the present day situation.
Automated systems have less manual operations, so that the flexibility, reliabilities are high and
accurate. Hence every field prefers automated control systems. Especially in the field of
electronics automated systems are doing better performance.
Probably the most useful thing to know about the global system for mobile communication
is that it is an international standard. If you travel in parts of world, GSM is only type of cellular
service available. Instead of analog services, GSM was developed as a digital system using
TDMA technology

HARDWARE COMPONENTS:
1.Micro Controller
2.Power supply
3.RF Transmitter & Receiver
4.Current and Voltage sensors
5.LCD
6.GSM
7.Loads

SOFTWARE TOOLS:
1. Embedded C
2. Keil IDE
3. Uc-Flash or ISP
4. Express PCB

RESULT:
This kind of project is very effective and can be used for recording the sensors data.

S-ar putea să vă placă și