Documente Academic
Documente Profesional
Documente Cultură
The plotted data in the figure below shows that the x-mas tree was
located at the TVD (true vertical depth) of 0 feet which is lie on the
surface. The X-mas tree was installed prior in controlling the flow of the oil
and gas out of the well. Beside X-mas tree other subsystem of SSSV
(subsurface safety valve was installed. This system or device used in order
to provide remote sub-surface isolation in the event of a catastrophic
failure of X-mas tree or as a failsafe shutdown system. This drilled well use
a casing of 6 inch internal diameter with 10340 feet for well isolation while
the ran tubing with 3.96 inch internal diameter of 10090 feet long. The
designed casing must have the ability to withstand a several against a
several whole problems like collapse, burst, tensile failure and a corrosion
from the chemical brines. Casing usually built from plain carbon steel with
a minimum of 30 feet each.
Equipment Summary
True
Tubing Tubing
Tubing Tubing
Casing
Casing
Rate
Inside Inside
Tubing
SSSV
Tubing
Tubing
3.96
0.0006
Tubing
3.96
0.0006
Tubing
Casing
0.0006
Casing
1000.0
993.7 1000.0
993.7
3.96
0.0006
3.00
3.96
0.0006
3.96
0.0006
6.00
6.00
0.0006
IPR DATA
The Inflow Performance Curve Cartesian plot of a bottom hole
flowing pressure versus surface flow rate is a diagnostic tools that is used
by the Petroleum engineer to evaluate the performance of a flowing well.
This plot used to determine whether the drilled well is performing as
expected or not. The plotted data is determine or calculate theoretically or
empirically by using the mathematical tools or relationship, which called
as Inflow Performance Relationship (IPR). IPR of the well is the relationship
between the flow rate of the well q and the flowing pressure of the well
Pwf.
Alongside
all
of
the
analytically
derived
Inflow
Performance
From the figure below, it can be seen that when the rate is 0 the pressure
is approximately 5000 psig. When the pressure is 0 the rate is
approximately 27000 STB/day.
REFERENCES
Mohamed, A. M. (2014). Evaluation of Prosper for Modelling Long Lateral Gas Well
Productivity in Toe up, Toe down, Horizontal Well Geometry. Scholars' mine,
1-178.
Paul, K. E. (n.d.). Analysis of Inflow Perfomance Relationships for Niger Delta Oil
Wells.