Documente Academic
Documente Profesional
Documente Cultură
28 21:41:07 =~=~=~=~=~=~=~=~=~=~=~=
cat-IN-5#
cat-IN-5#
cat-IN-5#clea
cat-IN-5#clear cou
cat-IN-5#clear counters
Clear "show interface" counters on all interfaces [confirm]
cat-IN-5#
05:35:06: %CLEAR-5-COUNTERS: Clear counter on all interfaces by console
cat-IN-5#
cat-IN-5#
cat-IN-5#
cat-IN-5#
cat-IN-5#sh ip int brie
Interface
IP-Address
OK? Method Status
Vlan1
unassigned
YES NVRAM administratively down
FastEthernet0/1
unassigned
YES unset down
FastEthernet0/2
unassigned
YES unset down
FastEthernet0/3
unassigned
YES unset down
FastEthernet0/4
unassigned
YES unset down
FastEthernet0/5
unassigned
YES unset down
FastEthernet0/6
unassigned
YES unset down
FastEthernet0/7
unassigned
YES unset down
FastEthernet0/8
unassigned
YES unset down
FastEthernet0/9
unassigned
YES unset down
FastEthernet0/10
unassigned
YES unset down
FastEthernet0/11
unassigned
YES unset down
FastEthernet0/12
unassigned
YES unset down
FastEthernet0/13
unassigned
YES unset down
FastEthernet0/14
unassigned
YES unset down
FastEthernet0/15
unassigned
YES unset down
FastEthernet0/16
unassigned
YES unset down
FastEthernet0/17
unassigned
YES unset down
FastEthernet0/18
unassigned
YES unset down
FastEthernet0/19
unassigned
YES unset down
FastEthernet0/20
unassigned
YES unset down
FastEthernet0/21
unassigned
YES unset down
FastEthernet0/22
--More-unassigned
YES unset down
FastEthernet0/23
unassigned
YES unset down
FastEthernet0/24
unassigned
YES unset down
GigabitEthernet0/1
unassigned
YES unset up
GigabitEthernet0/2
unassigned
YES unset down
cat-IN-5#sh
confr gt
Enter configuration commands, one per line. End with CNTL/Z.
cat-IN-5(config)#int gi0/2
cat-IN-5(config-if)#no shu
cat-IN-5(config-if)#no shutdown
cat-IN-5(config-if)#^Z
cat-IN-5#sh run
05:37:33: %SYS-5-CONFIG_I: Configured from console by console int gi02/2
Building configuration...
Current configuration : 172 bytes
!
interface GigabitEthernet0/2
switchport trunk encapsulation dot1q
switchport trunk allowed vlan 2409,2509,2609,2709
switchport mode trunk
speed 100
Protocol
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
down
up
down
duplex full
end
cat-IN-5#conf t
Enter configuration commands, one per line. End with CNTL/Z.
cat-IN-5(config)#int
sp
cat-IN-5(config)#spanning-tree
aut
cat-IN-5(config)#auto
cat-IN-5(config)#auto
speed ?
% Unrecognized command
cat-IN-5(config)#speed
int gi0/2
cat-IN-5(config-if)#au
cat-IN-5(config-if)#auto ?
qos Configure AutoQoS
cat-IN-5(config-if)#auto
sppee
cat-IN-5(config-if)#speed au
cat-IN-5(config-if)#speed auto
cat-IN-5(config-if)#^Z
cat-IN-5#
05:39:01: %LINK-3-UPDOWN: Interface GigabitEthernet0/2, changed state to up
05:39:02: %SYS-5-CONFIG_I: Configured from console by console
05:39:04: %LINEPROTO-5-UPDOWN: Line protocol on Interface GigabitEthernet0/2, ch
anged state to up^Z
cat-IN-5#conf
sh runt int gi0/2
Building configuration...
Current configuration : 161 bytes
!
interface GigabitEthernet0/2
switchport trunk encapsulation dot1q
switchport trunk allowed vlan 2409,2509,2609,2709
switchport mode trunk
duplex full
end
cat-IN-5#sh
confrunt int gi0/2
Enter configuration commands, one per line. End with CNTL/Z.
cat-IN-5(config)#speed
int gi0/2
auto
cat-IN-5(config-if)#du
cat-IN-5(config-if)#duplex au
cat-IN-5(config-if)#duplex auto
cat-IN-5(config-if)#^Z
cat-IN-5#
05:39:43: %SYS-5-CONFIG_I: Configured from console by console
05:39:43: %LINEPROTO-5-UPDOWN: Line protocol on Interface GigabitEthernet0/2, ch
anged state to down
05:39:44: %LINK-3-UPDOWN: Interface GigabitEthernet0/2, changed state to down
05:39:47: %LINK-3-UPDOWN: Interface GigabitEthernet0/2, changed state to up
05:39:49: %LINEPROTO-5-UPDOWN: Line protocol on Interface GigabitEthernet0/2, ch
anged state to up
cat-IN-5#sh int gi0/1
GigabitEthernet0/1 is up, line protocol is up (connected)
Hardware is Gigabit Ethernet, address is 001b.d4ff.4301 (bia 001b.d4ff.4301)
MTU 1500 bytes, BW 1000000 Kbit, DLY 10 usec,
reliability 255/255, txload 1/255, rxload 1/255
Encapsulation ARPA, loopback not set
Keepalive not set
Full-duplex, 1000Mb/s, link type is auto, media type is 10/100/1000BaseTX SFP
input flow-control is off, output flow-control is unsupported
Vlan
1
Port
Name
Status
Vlan
Duplex Speed Type
Gi0/2
connected
trunk
a-full a-1000 10/100/1000Ba
seTX SFP
cat-IN-5#sh int gi0/2 status
GigabitEthernet0/2 is up, line protocol is up (connected)
Hardware is Gigabit Ethernet, address is 001b.d4ff.4302 (bia 001b.d4ff.4302)
MTU 1500 bytes, BW 1000000 Kbit, DLY 10 usec,
reliability 255/255, txload 1/255, rxload 1/255
Encapsulation ARPA, loopback not set
Keepalive not set
Full-duplex, 1000Mb/s, link type is auto, media type is 10/100/1000BaseTX SFP
input flow-control is off, output flow-control is unsupported
ARP type: ARPA, ARP Timeout 04:00:00
Last input 02:27:39, output 00:00:00, output hang never
Last clearing of "show interface" counters 00:09:07
Input queue: 0/75/0/0 (size/max/drops/flushes); Total output drops: 0
Queueing strategy: fifo
Output queue: 0/40 (size/max)
5 minute input rate 208000 bits/sec, 35 packets/sec
5 minute output rate 69000 bits/sec, 1 packets/sec
11863 packets input, 1461038 bytes, 0 no buffer
Received 1511 broadcasts (0 multicast)
0 runts, 0 giants, 0 throttles
0 input errors, 0 CRC, 0 frame, 0 overrun, 0 ignored
0 watchdog, 916 multicast, 0 pause input
0 input packets with dribble condition detected
3498 packets output, 468159 bytes, 0 underruns
--More-0 output errors, 0 collisions, 0 interface resets
0 babbles, 0 late collision, 0 deferred
0 lost carrier, 0 no carrier, 0 PAUSE output
0 output buffer failures, 0 output buffers swapped out
cat-IN-5#sh int fa0/23
gi0/2
FastEthernet0/23 is down, line protocol is down (notconnect)