Documente Academic
Documente Profesional
Documente Cultură
2014 XRL
ICC Help
Table of Contents
6
Part I Introduction
1 Terms of use................................................................................................................................... 7
2 System requirements
................................................................................................................................... 8
3 Before you start
................................................................................................................................... 9
12
1 Installing of ...................................................................................................................................
drivers
13
2 Switching USB
...................................................................................................................................
mode
14
3 Checking of...................................................................................................................................
installed modules
15
4 Adding new ...................................................................................................................................
modules
16
19
1 Nissan, Infiniti
................................................................................................................................... 20
PIN code by BCM
..........................................................................................................................................................
/ IMMU
PIN code by ICU
..........................................................................................................................................................
PIN code by SEC
..........................................................................................................................................................
PIN code by Glove
..........................................................................................................................................................
Box
PIN code by dump
..........................................................................................................................................................
KEY code by ..........................................................................................................................................................
VIN
21
29
31
33
34
42
2 KIA, Hyundai................................................................................................................................... 43
PIN code by VIN
..........................................................................................................................................................
PIN code by dump
..........................................................................................................................................................
KEY code by ..........................................................................................................................................................
VIN
44
45
51
3 Toyota, Lexus,
...................................................................................................................................
Scion
52
Pass Code by..........................................................................................................................................................
Seed No
53
4 Ford, Mazda,...................................................................................................................................
Lincoln, Mercury
55
Incode by Outcode
..........................................................................................................................................................
PIN code by ISN
..........................................................................................................................................................
PIN code by dump
..........................................................................................................................................................
5 Jaguar
56
57
59
................................................................................................................................... 64
Incode by Outcode
..........................................................................................................................................................
PIN code by dump
..........................................................................................................................................................
65
66
6 MG Rover, Land
...................................................................................................................................
Rover
67
Incode by Outcode
..........................................................................................................................................................
PIN code by dump
..........................................................................................................................................................
7 Smart
68
69
................................................................................................................................... 71
72
73
74
8 Honda, Acura
................................................................................................................................... 75
1st Immo Password
..........................................................................................................................................................
76
2014 XRL
Contents
Release Password
..........................................................................................................................................................
PCM code by ..........................................................................................................................................................
VIN
77
78
9 Chery, Qirui,...................................................................................................................................
Geely
79
PIN code by VIN
..........................................................................................................................................................
PIN code by dump
..........................................................................................................................................................
80
81
10 Renault, Dacia
................................................................................................................................... 85
PIN code by key
..........................................................................................................................................................
tag
86
PIN code by led
.......................................................................................................................................................... 89
PIN code by INCODE
.......................................................................................................................................................... 90
INCODE by PIN
..........................................................................................................................................................
code
91
PIN code by dump
.......................................................................................................................................................... 92
Reprogramming
..........................................................................................................................................................
Code
106
11 Suzuki, Maruti
................................................................................................................................... 107
PIN code by ..........................................................................................................................................................
ECM
List of default
..........................................................................................................................................................
codes
PIN code by ..........................................................................................................................................................
dump
108
109
110
12 Opel, GMC,...................................................................................................................................
Vauxhall, Chevrolet, Holden, Buick
112
PIN code by ..........................................................................................................................................................
VIN
PIN code by ..........................................................................................................................................................
dump
KEY code by..........................................................................................................................................................
VIN
KEY code by..........................................................................................................................................................
dump
113
114
129
130
13 Citroen, Peugeot
................................................................................................................................... 132
PIN code by ..........................................................................................................................................................
dump
Fn Unlock Password
..........................................................................................................................................................
133
151
153
170
172
174
186
17 BMW
190
191
................................................................................................................................... 195
Password by..........................................................................................................................................................
dump
196
18 Chrysler, Dodge,
...................................................................................................................................
Plymouth, Jeep
201
PIN code by ..........................................................................................................................................................
dump
19 Isuzu
................................................................................................................................... 205
20 Volvo
206
................................................................................................................................... 210
21 Porsche
202
211
................................................................................................................................... 213
214
218
222
2014 XRL
ICC Help
24 Samand
................................................................................................................................... 225
25 Ducati
................................................................................................................................... 228
26 Saab
226
229
................................................................................................................................... 231
232
27 Mercedes Benz
................................................................................................................................... 233
Key generation
..........................................................................................................................................................
by dump
234
237
1 Raw binary...................................................................................................................................
file format
238
2 YanHua YH...................................................................................................................................
file format
239
3 YanHua YHF
...................................................................................................................................
file format
240
4 YanHua YHE
...................................................................................................................................
file format
241
5 YanHua YHS
...................................................................................................................................
file format
242
6 DIGA-Consult
...................................................................................................................................
E2P file format
243
7 PonyProg E2P
...................................................................................................................................
file format
244
8 Intel 8-bit hex
...................................................................................................................................
file format
245
9 ETSmart EEF
...................................................................................................................................
file format
246
10 Motorola S-Record
...................................................................................................................................
format
247
11 Rosfar 3000
...................................................................................................................................
file format
248
12 ASCII hex file
...................................................................................................................................
formats
249
252
1 Error Messages
................................................................................................................................... 253
2 Abbreviations
................................................................................................................................... 254
3 MCU, EEPROM
...................................................................................................................................
mask sets
256
4 Unsupported
...................................................................................................................................
car models
261
5 Updates and
...................................................................................................................................
support
262
6 Tips and hints
................................................................................................................................... 263
7 Special thanks
................................................................................................................................... 264
2014 XRL
Part
ICC Help
Introduction
Thank you for choosing ICC! We hope that you are satisfied using our unique and
powerful tool. We will do the best to help you in immobilizer programming and key
cutting solutions for wide range of vehicles and bikes from eighties to the
present.
2014 XRL
Introduction
1.1
Terms of use
Please take a note of this:
You are not allowed to provide PIN / KEY codes for immobilizers to third-party
without our agreement, otherwise your dongle will be switched off without your
prior notice and any refund.
Sharing of your account details, any part of ICC software or additional files to
third-party are violation of our rules. In such cases your dongle will be switched
off or/and your account will be blocked without your prior notice and any refund.
For security reasons ICC have built-in autoblocking function if number of
calculated codes is more than require for personal use. Limit of calculations is
well enough to serve at least 5 workshops. Calculation of codes for "test
purposes", analysis of algorithms, etc may also cause blocking of ICC dongle.
2014 XRL
1.2
ICC Help
System requirements
ICC doesn't have any special system requirements. Any Windows NT / 98 / ME / 2000 /
XP / 2003 / Vista / 7 based computer with at least one USB port is enough for using
ICC.
Minimal system configuration that we recommend:
IBM PC
CPU Intel Pentium 3Ghz
RAM 2048Mb
HDD 4096Mb free space
USB 2.0 Port
OS Windows XP
Screen resolution 1024x768
2014 XRL
Introduction
1.3
To logon on flash drive - run supplied utility, then click "Login" button and enter
password - "icc" without quotes. You will find portable version of ICC and
installation package.
For dongles switched to USB mode or if your OS doesn't have HID support - you will
need to install drivers before using ICC software. Also you will need to change
operational mode from HID to USB on OS with HID support.
Note for Windows 7 users: you need to run ICC software with administrative
privileges if dongle was switched to USB mode. Right-click the program and select
"Run as administrator". Or select "Properties" then "Compatibility" tab and set
checkbox "Run this program as an administrator".
Information
section.
2014 XRL
about
driver's
installing
is
available
in
"Hardware
management"
10
ICC Help
2014 XRL
Part
II
12
ICC Help
Hardware management
ICC dongle is like a separate computer. It's based on secure smart card chip and
have CPU 16Mhz, 64Kb of memory for storing data and executable modules.
We have developed special program called ICC Dongle Tool for checking of installed
modules, reading registration information, and uploading new algorithms.
All of code calculation algorithms are stored in dongle and can be executed from
your own software using simple API calls.
2014 XRL
Hardware management
2.1
13
Installing of drivers
In most cases you don't need to install a driver for ICC dongle. But if your dongle
is switched to USB mode or OS doesn't have HID support - you need to install
additional driver.
You can find driver on CD with software or download from support area of web site.
Also you can download driver through Microsoft Update (Windows Update) system.
Installation procedure is simple and standard. We will not describe it here because
it's same as for any other PC devices.
If you have any problems with drivers installation procedure - please ask your
technical specialist for help.
Note for Windows 7 users: you need to run ICC software with administrative
privileges if dongle was switched to USB mode. Right-click the program and select
"Run as administrator". Or select "Properties" then "Compatibility" tab and set
checkbox "Run this program as an administrator".
2014 XRL
14
2.2
ICC Help
After that you need to remove ICC dongle, wait 5 seconds and plug it back.
Please note: If your computer have poorly powered USB ports - you need to switch
dongle to USB mode or insert dongle in self powered USB hub (with external power).
Do not use passive - bus powered USB hubs with dongle switched to HID mode because
they can not provide enough power.
Note for Windows 7 users: you need to run ICC software with administrative
privileges if dongle was switched to USB mode. Right-click the program and select
"Run as administrator". Or select "Properties" then "Compatibility" tab and set
checkbox "Run this program as an administrator".
2014 XRL
Hardware management
2.3
15
"Installed" beside algorithm name means that executable or data module is loaded in
to the dongle.
"Absent" or "Outdated" means what module is not installed or it is outdated.
2014 XRL
16
2.4
ICC Help
Update process can take up to several minutes depending on hardware update file
size. Please be patient and do not interrupt update process.
After loading of update file into dongle you will see a confirmation message. If
error message - update was unsuccessful.
Please note, when errors counter will be equal to the maximum of possible errors
(255/255), update process will not be available anymore.
2014 XRL
Hardware management
2014 XRL
17
Part
III
19
2014 XRL
20
3.1
ICC Help
Nissan, Infiniti
Various models of Nissan & Infiniti are supported by ICC.
encrypted code
encrypted code
encrypted code
encrypted code
dump of EEPROM
In addition ICC can calculate a keycode by VIN for 1998-2013 USA, Mexico and Japan
models.
To calculate PIN code for Nissan Pixo and other models based on Suzuki platform select Suzuki as brand.
For some of the models you can use default immobilizer PIN code - "5523". Such
vehicles have a big letter "A" on ICU label. Following vehicle models have a
default PIN code:
To identify NATS version - check label on ICU: STEP-5 means NATS-5, STEP-5.6 means
NATS-5.6, STEP-6 means NATS-6 and STEP-7 means NATS-7.
For Primera P12, new Almera and some other models equipped with NATS-6 immobilizer
PIN code must be calculated by crypted code from SEC label. For models with NATS-5
immobilizer - by crypted code from BCM or ICU label. For models with NATS-7 (based
on Renault-Samsung platforms) by dump from BCM or ECU.
NATS also known as NVIS - Nissan Vehicle Immobilizer System and IVIS - Infiniti
Vehicle Immobilizer System.
2014 XRL
3.1.1
21
BCM is located in left side between centre console and steering rack. Part numbers
of BCM are 284B1-XXXXX, 284B2-XXXXX. They are made in Japan by Calsonic Kansei Corp
for Siemens VDO.
In most cases you can read BCM code using an diagnostic equipment like AD100 or
Carman Scan then calculate a PIN code from BCM code.
BCM Calsonic Kansei, p/n 284B1-CB800:
2014 XRL
22
ICC Help
2014 XRL
2014 XRL
23
24
ICC Help
2014 XRL
2014 XRL
25
26
ICC Help
2014 XRL
2014 XRL
27
28
ICC Help
2014 XRL
3.1.2
29
ICC may show two PIN codes, in dependence of car type and region. In most cases you
need to use first PIN code for models with ICU made in Germany and second PIN code
for models with ICU made in Mexico.
ICU is located near ignition. Part number of ICU is 28590-XXXXX, big letter "B" in
box. They are made in Mexico or Germany by Siemens.
ICU Siemens, p/n 28590-C9902:
2014 XRL
30
ICC Help
Such vehicle models are equipped with NATS6 immobilizer - new Almera, Primera P12
and others. "STEP 6" means NATS-6.
2014 XRL
3.1.3
31
SEC is located in left side between centre console and steering rack. Part number
of SEC unit is 28550-XXX, made in Europe by Siemens.
SEC Siemens, p/n 28550-BN8:
2014 XRL
32
ICC Help
2014 XRL
3.1.4
33
2014 XRL
34
3.1.5
ICC Help
To calculate immobilizer code for Nissan and Infiniti models you need to locate and
read dump from (depend of car model):
ECU - 93C66
ICU - TMS370C032, ST-A2C11776
BCM - 93C56, 93C66, 93C76, 95080, 95160, MC9S12XDT384
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and serial number of electronic unit if available.
Please note: for models based on Renault platform - select "Renault" as brand.
BCM Calsonic Kansei, p/n 284B1-CB800 (left side between centre console and steering
rack):
2014 XRL
2014 XRL
35
36
ICC Help
2014 XRL
2014 XRL
37
38
ICC Help
2014 XRL
2014 XRL
39
40
ICC Help
2014 XRL
2014 XRL
41
42
3.1.6
ICC Help
Note: Available for USA, Mexico and Japan cars only (WMIs are 1N4, 1N6, 3N1, 4N2,
5BZ, 5N1, 5N3, 5Z6, JN1, JN6, JN8, JNK, JNR).
Set type of calculation method to VIN2KEY and enter required data. In few seconds
ICC will calculate a KEY code for using with computerized key duplicators with "Cut
to Code" function.
2014 XRL
3.2
43
KIA, Hyundai
Various models of KIA & Hyundai with 4, 5 and 6 digit PIN codes are supported by
ICC.
PIN code for immobilizer can be calculated by VIN for models with SMARTRA 2/3 ICM
and by dump of EEPROM for all other models.
In addition ICC can calculate keycode by VIN for KIA 2001-2011 models and Hyundai
1986-2011 models.
For some modifications of Kia Clarus, Shuma, Mentor 2, Sephia 2, Sportage,
Carnival, Pride, Sedona, Carens, Rio and other vehicle models made in June-December
of 1999 with Texton immobilizer you can use last 5 digits of VIN as immobilizer PIN
code, where "0" may be be replaced by "1" or "2" in dependencies of car model, VIN
or date of production.
For models made in Russia - immobilizer code is same as KEY code, example: KEY code
- K1234, PIN code - 1234 or 01234 or 001234 or 123400 depend of car model and type
of immobilizer.
Default Immobilizer PIN code for SMARTRA is "234567" and "2345" for Shin Chang type
of ICM.
2014 XRL
44
3.2.1
ICC Help
To calculate a code for SMARTRA-2 immobilizer you need to enter last 6 digits of
VIN. SMARTRA-2 system was used on vehicles made till 11 May 2007, all newer
vehicles are equipped with SMARTRA-3 system.
Set type of calculation method to VIN2PIN and enter required data. In few seconds
ICC will calculate a PIN code for immobilizer programming.
For KIA and Hyundai 2007-2011 models with SMARTRA-3 immobilizer you can calculate
PIN code by full VIN (all of 17 chars). Covered WMIs are 200, 201, 5NM, 5NP, 5XY,
KM8, KMC, KME, KMF, KMH, KMJ, KN3, KN4, KNA, KNC, KND, KNE, KNF, KNG, KNH, MAL,
MHX, NAB, NLH, NLJ, PL8, TMA, U5Y, U6Y, Z94.
For Hyundai Assan (HAOS) 2000-2011 models made in Turkey, WMIs are NLH and NLJ you
can calculate a PIN code by full VIN.
For not supported cars you need to calculate PIN code by dump.
For some of the models made in Russia - immobilizer code is same as KEY code,
example: KEY code - K1234, PIN code - 1234 or 01234 or 001234 or 123400 depend of
car model and type of immobilizer.
2014 XRL
3.2.2
45
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and additional information if available.
ICM SMARTRA:
2014 XRL
46
ICC Help
2014 XRL
ICM Shin-Chang:
2014 XRL
47
48
ICC Help
ICM Texton:
2014 XRL
2014 XRL
49
50
ICC Help
2014 XRL
3.2.3
51
Supported WMIs are 200, 5NM, 5NP, 5XY ,KM8, KMC, KMD, KME, KMF, KMH, KN2, KN3, KNA,
KNC, KND, KNE, KNF, KNH, KPH, MAH, MAL, NLH, NLJ, PL8, TMA, U5Y, U6Y, Z94.
Supported KEY-prefixes are: 0, A, B, C, D, E (KE), F, G, H, J, K (HK), L, M, N, P,
R, S, T, U, V (KV), W, X, Y.
Set type of calculation method to VIN2KEY and enter required data. In few seconds
ICC will calculate a KEY code for using with computerized key duplicators with "Cut
to Code" function.
2014 XRL
52
3.3
ICC Help
Pass-Code is required for Key Programming, Erasing, Immobilizer Reset and other
security procedures with Intelligent Tester, Techstream and other OEM software and
hardware equipment.
2014 XRL
3.3.1
53
To calculate the Passcode - enter 6 or 96 chars Seed Number from Diagnostic Tester
or OEM software, VIN (if require) and click "Calculate" button. In few seconds ICC
will show 6 digit Pass Code. Enter code as shown on picture.
Techstream - Smart Code Reset (6 digit Seed Number):
2014 XRL
54
ICC Help
2014 XRL
3.4
55
As well various models of Mazda with MECS are supported by ICC. PIN code for MECS
can be calculated by ISN and by dump of EEPROM from Immo Box and ECU.
2014 XRL
56
3.4.1
ICC Help
Incode by Outcode
For Ford and Mazda models with PATS ICC can calculate INCODE by OUTCODE for
accessing security procedures (coded access) with IDS-VCM and other diagnostic
equipment. Supported all models with PATS made till May 2010.
To calculate the INCODE - enter 6 chars OUTCODE from Diagnostic Tester and click
"Calculate" button. In few seconds ICC will show 4 chars INCODE.
Please note: for coded access which require 8 chars Incode you need to enter full
16 chars Outcode, dash or space separated. For example "0044 1A2B3C 4D5E6F".
Ford IDS - Coded Access:
2014 XRL
3.4.2
57
To calculate a code for LUCAS immobilizer set type of calculation method to ISN2PIN
and enter 10 digit serial number of immobilizer as shown on picture. Serial numbers
of Lucas immobox begins with 5 or 6 only.
Note: code calculation process can take up to 15 minutes (depend of serial number)
using standard algorithm, please be patient. Extra fast algorithm (less than 7
seconds, 125 times faster) is available but it can not be loaded into dongle using
remote update. Direct programming is required. Using ICC Tool you can check which
algorithm is installed. XA module means eXtra fAst algorithm.
Lucas Immobilizer (right side of the steering column):
2014 XRL
58
ICC Help
2014 XRL
3.4.3
59
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
Temic Immo (below radio on centre console or near steering column):
2014 XRL
60
ICC Help
Lucas Immo (right side of the steering column behind lower trim panel):
2014 XRL
TRW Immo (right side of the steering column behind lower trim panel):
2014 XRL
61
62
ICC Help
2014 XRL
2014 XRL
63
64
3.5
ICC Help
Jaguar
ICC can calculate INCODE for most of the Jaguar models with PATS3+ and later.
INCODE is required for Control Unit assignment, adding and erasing of transponder
keys with IDS-VCM, AD100Pro, SBB or any other suitable equipment. INCODE can be
calculated by 6 or 16 chars OUTCODE from diagnostic scanner.
As well various models of Jaguar with 4 digit PIN codes are supported by ICC. PIN
code for immobilizer can be calculated by dump of EEPROM from ECU.
2014 XRL
3.5.1
65
Incode by Outcode
For Jaguar models with PATS ICC can calculate INCODE by OUTCODE for accessing
security procedures with IDS-VCM and other diagnostic equipment.
To calculate the INCODE - enter 6 chars OUTCODE from Diagnostic Tester and click
"Calculate" button. In few seconds ICC will show 4 chars INCODE.
Please note: for coded access which require 8 chars Incode you need to enter full
16 chars Outcode, dash or space separated. For example "0044 1A2B3C 4D5E6F".
Ford IDS - Coded Access:
2014 XRL
66
3.5.2
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
2014 XRL
3.6
67
As well various models of MG Rover and Land Rover with 4 digit PIN codes are
supported by ICC. EKA code for immobilizer can be calculated by dump of EEPROM from
BCU and Immo Box.
2014 XRL
68
3.6.1
ICC Help
Incode by Outcode
For Land Rover models with PATS ICC can calculate INCODE by OUTCODE for accessing
security procedures with IDS-VCM and other diagnostic equipment.
To calculate the INCODE - enter 6 chars OUTCODE from Diagnostic Tester and click
"Calculate" button. In few seconds ICC will show 4 chars INCODE.
Please note: for coded access which require 8 chars Incode you need to enter full
16 chars Outcode, dash or space separated. For example "0044 1A2B3C 4D5E6F".
Ford IDS - Coded Access:
2014 XRL
3.6.2
69
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
To calculate keys password or ISN by dump of EWS / DME for Land Rover models based
on BMW platforms select BMW as brand.
For Land Rover models ICC may calculate two codes as shown on picture, first one
for using with diagnostic equipment and second one to enter by driver door key. On
this example code for diagnostic equipment is "4C86", and code to enter by door key
is "4-12-8-6".
BCU Land Rover:
2014 XRL
70
ICC Help
BCU Lucas:
2014 XRL
3.7
71
Smart
Various models of Smart are supported by ICC. 12 chars TAN code for DAS can be
calculated by 9 chars outcode for key teaching procedure and by VIN for SAM
synchronization.
In addition ICC can calculate a KEY code by VIN for MCC Smart 1998-2013 models.
2014 XRL
72
3.7.1
ICC Help
key
In cases when synchronization of SAM unit was lost and key teaching procedure does
not help to start vehicle ICC can calculate special TAN code by VIN for
synchronization of SAM. This procedure called in DAS - "Carry out control unit
assignment".
To calculate a TAN code - enter 9 chars outcode from DAS and click "Calculate"
button. In few seconds ICC will show 12 chars TAN for DAS. Enter it as shown on
picture.
DAS program a key screen:
2014 XRL
3.7.2
73
To calculate a TAN code - enter VIN and click "Calculate" button. In few seconds
ICC will show 12 chars incode for DAS. Enter it as shown on picture.
DAS - SAM unit assignment:
After synchronization of SAM unit you can start procedure "Teach-in key again".
2014 XRL
74
3.7.3
ICC Help
Two types of KEY codes are supported, 4 digit - MCC1234 and 6 digit - 012345.
Set type of calculation method to VIN2KEY and enter required data. In few seconds
ICC will calculate a KEY code for using with computerized key duplicators with "Cut
to Code" function.
2014 XRL
3.8
75
Honda, Acura
Various models of Honda & Acura are supported by ICC. This is complete solution for
Key Programming and PCM replacement procedures with Honda Diagnostic System.
ICC can calculate 1st Immobilizer Password, Release Password and PCM access code
for HDS. Please note, this is not a 5 digit immobilizer brake codes.
2014 XRL
76
3.8.1
ICC Help
Set calculation method as shown on picture and click "Calculate" button. That's
all.
1st Password is required for adding a key(s) with HDS and clearing transponder
codes of lost programmed ignition keys.
Honda Diagnostic System - 1st Password:
2014 XRL
3.8.2
77
Release Password
For Honda Diagnostic System ICC can calculate Release Password (2nd Password). It's
required in cases when you entered wrong access code more than 3 times and
diagnostic tester was locked.
2014 XRL
and
click
78
3.8.3
ICC Help
To calculate a PCM access code you need to enter last 5 digits of VIN as shown on
picture.
PCM Code is required in cases when all car keys are lost or PCM/ECM Immobilizer
replacement. Please note, PC date settings are must be correct because all of
secret codes are calculating for the current day only.
Honda Diagnostic System - PCM Code:
2014 XRL
3.9
79
PIN code for immobilizer can be calculated by VIN and by dump of EEPROM from ECU
and Immo Box.
Default PIN code for Chery / Qirui and Geely Immobilizers is "1111". You can try it
first before reading dump.
2014 XRL
80
3.9.1
ICC Help
Set type of calculation method to VIN2PIN and enter required data. In few seconds
ICC will calculate a PIN code for immobilizer programming.
2014 XRL
3.9.2
81
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
ECU Bosch ME7.9.7:
2014 XRL
82
ICC Help
2014 XRL
2014 XRL
83
84
ICC Help
2014 XRL
3.10
85
Renault, Dacia
Various models of Renault & Dacia with 4, 8 and 12 digit codes are supported by
ICC.
PIN code for immobilizer can be calculated by serial number from label inside the
key for old models with 4 digit codes and by dump of EEPROM for models with 4, 8
and 12 digit codes.
In addition, ICC can calculate PIN code for TYPE-1 immobilizers by number of blinks
of ECU MIL lamp. This is special function for using with Renault ECU Decoding Tool
aka Renault Immo Tool.
As well ICC have built-in code converter for Renault Clip: PIN code by INCODE and
INCODE by PIN code.
Also, ICC can calculate "After Sales Reprogramming code" for offline programming
with Renault Clip.
2014 XRL
86
ICC Help
2014 XRL
2014 XRL
87
88
ICC Help
2014 XRL
89
Select Semi-Auto operation mode (fast green LED blinking). Press START button.
After every ignition-on, MIL immediately starts to blink fast. Watch the ECU MIL
lamp and count number of ignition-on (start counting from 1). Note number of
ignition-on cycles when MIL stops blinking for a while.
ECU is not decoded after this procedure, you only found out its security code. In
worst case when MIL stops to blink on 254-th ignition-on, counting takes about 8
minutes.
2014 XRL
90
ICC Help
this
data
as
"VF1BGRG0630046526-944HVYA9T13K073MB1R1YZD2-
2014 XRL
91
enter
this
data
as
"VF1BGRG0630046526-944HVYA9T13K073MB1R1YZD2-
2014 XRL
92
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN if available.
ICC may show two PIN codes, in dependence of car type and year of production.
For Laguna II exist two types of immobilizers, if first code will not be accepted click text label "PIN Code:" and ICC will show second emergency code for another
version of immo box.
Twingo IR TRW (immo near back mirror):
2014 XRL
Valeo IR:
2014 XRL
93
94
ICC Help
Megane IR Siemens:
2014 XRL
2014 XRL
95
96
ICC Help
2014 XRL
2014 XRL
97
98
ICC Help
Megane II / Scenic II UCH Siemens (driver side, left under steering column):
2014 XRL
Siemens UCH:
2014 XRL
99
100
ICC Help
2014 XRL
2014 XRL
101
102
ICC Help
2014 XRL
2014 XRL
103
104
ICC Help
2014 XRL
2014 XRL
105
106
ICC Help
2014 XRL
3.11
107
Suzuki, Maruti
Various models of Suzuki with 4 digit PIN codes are supported by ICC.
PIN code for immobilizer can be calculated 20 chars encrypted ID code from ECM or
by dump of EEPROM from Immo Box and ECU. For some of the new models ICC have a list
of default codes.
2014 XRL
108
ICC Help
2014 XRL
109
Please note, default PIN code can be changed using an diagnostic scanner. In this
case you will need to read EEPROM dump from Immo Box or ECU and calculate a code by
dump.
2014 XRL
110
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
IMMO Siemens (located near ignition):
2014 XRL
IMMO Mitsubishi:
2014 XRL
111
112
3.12
ICC Help
PIN code for immobilizer can be calculated by dump of EEPROM from Immo Box, BCM,
UCH, ECU, REC, Radio or Dash. For Chevrolet 1999-2010 models made in Latin America
ICC can calculate PIN code by VIN.
In addition ICC can calculate KEY code by VIN for Chevrolet 2000-2009 models made
in Mexico, Argentina, Brazil. For all other GM models ICC can calculate KEY code by
dump.
For Opel models based on Renault platforms - set Renault as brand.
2014 XRL
113
Set type of calculation method to VIN2PIN and enter required data. In few seconds
ICC will calculate a PIN code for immobilizer programming.
Supported WMIs are 3G1, 3GY, 8AG, 93C, W0L. For not supported cars you need to
calculate PIN code by dump.
2014 XRL
114
ICC Help
REC - 95040
UCH - 93C66
Navi- 24C16
DDM - MC68HC08AZ60
Comfort - MC9S12XET256
Dash - 93C66, 95080, 780828
Display - 93C56, 93C66, 25080
CIM - 93C76, 95160, MC9S12DT128B
BCM - 24C04, 24C16, 93C46, 93C66, 93C86, 95040, 95080, HC912DG128
ECU - AM29BL802CB, 24C04, 95P08, 93C86, 95080, 95160, 95320, 95640, HC11F1
Immo Box - TMS370C702, MC68HC05B6, MC68HC08AB16A, 68HC912DC128A, 93C46, 93C66,
24C04
Radio - 24C32, 95640, MC68HC05B16 (Blaupunkt / Grundig CAR300D, CAR2003, CC20,
CD30, CD30 MP3, CDC40, CDC40 Opera)
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
Note: For Opel models based on Renault platforms - set Renault as brand.
IMMO Siemens (located near ignition):
2014 XRL
2014 XRL
115
116
ICC Help
2014 XRL
2014 XRL
117
118
ICC Help
2014 XRL
Immo Valeo:
2014 XRL
119
120
ICC Help
BCM Lomina:
2014 XRL
2014 XRL
121
122
ICC Help
ECU Bosch:
2014 XRL
2014 XRL
123
124
ICC Help
2014 XRL
2014 XRL
125
126
ICC Help
2014 XRL
2014 XRL
127
128
ICC Help
129
Supported WMIs are 3G1, 3GY, 8AG, 93C, W0L. Supported KEY-prefixes are: 1, D, H, S,
Z.
Set type of calculation method to VIN2KEY and enter required data. In few seconds
ICC will calculate a KEY code for using with computerized key duplicators with "Cut
to Code" function.
2014 XRL
130
ICC Help
Set type of calculation method to DMP2KEY and browse for a dump file. In few
seconds ICC will calculate a KEY code for using with computerized key duplicators
with "Cut to Code" function.
IMMO Siemens (located near ignition):
2014 XRL
2014 XRL
131
132
3.13
ICC Help
Citroen, Peugeot
Various models of PSA with 4 and 5 digit PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from Immo Box, BSI,
CPH, ECU, Valve or Keyboard for models with keypad immobilizers.
Factory default code for models with keypad immobilizer is "1111". Also you can use
this default code in cases when immobilizer was reseted or EEPROM is erased.
In addition ICC can calculate 16 chars Unlock code for PP2000, Lexia, Proxia,
DiagBox and other OEM diagnostic equipment for Independent Garages. Unlock code is
required for access to various security functions, such as: key learning, repair,
calibration, pairing, configuration, flashing, fault clearing, etc.
2014 XRL
133
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or serial no of electronic unit if
available.
Factory default code for models with keypad immobilizer is "1111". Also you can use
this default code in cases when immobilizer was reseted or EEPROM is erased.
Immo Valeo (behind dash on left hand side):
2014 XRL
134
ICC Help
2014 XRL
2014 XRL
135
136
ICC Help
2014 XRL
2014 XRL
137
138
ICC Help
2014 XRL
2014 XRL
139
140
ICC Help
BSI Siemens:
2014 XRL
BSI Sagem:
2014 XRL
141
142
ICC Help
2014 XRL
2014 XRL
143
144
ICC Help
2014 XRL
2014 XRL
145
146
ICC Help
2014 XRL
ECU Lucas:
2014 XRL
147
148
ICC Help
2014 XRL
2014 XRL
149
150
ICC Help
2014 XRL
151
Set type of calculation to "Fn Unlock" and enter 16 chars Lock Key separated by
dashes from PSA diagnostic equipment. In a second ICC will calculate Password
(Unlock Key, Activation Code) for requested function.
PP2000, Unlock Key Request:
2014 XRL
152
3.14
ICC Help
PIN code for immobilizer can be calculated by dump of EEPROM from BSI, CPH, ECU,
Valve and Immo Box.
ICC can calculate 4 digit code for old models and 5 digit code for new models.
2014 XRL
153
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
IMMO Bosch:
2014 XRL
154
ICC Help
2014 XRL
2014 XRL
155
156
ICC Help
IMMO Siemens:
2014 XRL
2014 XRL
157
158
ICC Help
2014 XRL
BSI Sagem:
2014 XRL
159
160
ICC Help
2014 XRL
2014 XRL
161
162
ICC Help
2014 XRL
2014 XRL
163
164
ICC Help
2014 XRL
2014 XRL
165
166
ICC Help
2014 XRL
ECU Lucas:
2014 XRL
167
168
ICC Help
2014 XRL
3.15
169
PIN code (SKC) for immobilizer can be calculated using 7 to 4 SKC converter or 4 to
7 SKC converter and by dump of EEPROM from Immo Box, ECU, KESSY or Dashboard.
In addition ICC can calculate Component Security (CS) code by dump of EEPROM from
various electronic units.
2014 XRL
170
ICC Help
To calculate a code set type of calculation to PIN2PIN and enter required data: 7
digit code (SKC), dealer no (WSC), importer code and date of issue.
The Importer Code should be:
210
261
264
387
444
572
724
730
995
999
for
for
for
for
for
for
for
for
for
for
all
all
all
all
all
all
all
all
all
all
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
in
in
in
in
in
in
in
in
in
in
United Kingdom
Portugal
Italy
Reunion Island
USA
Spain
Saudi Arabia
Israel
France
Canada
Example: 0430737 - 7 digit code, 01742 - dealer no, 444 - importer code, 150307 date of ussue (15 march 2007). As shown on picture you need to enter this data as
"0430737-01742-444-150307".
Importer and dealer code are located on the rubber stamp used by the dealer to
2014 XRL
171
2014 XRL
172
ICC Help
To calculate a code set type of calculation to PIN2PIN and enter required data: 4
digit code (with leading zero - 01234), dealer no (WSC), importer code and date of
issue.
The Importer Code should be:
210
261
264
387
444
572
724
730
995
999
for
for
for
for
for
for
for
for
for
for
all
all
all
all
all
all
all
all
all
all
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
dealerships
in
in
in
in
in
in
in
in
in
in
United Kingdom
Portugal
Italy
Reunion Island
USA
Spain
Saudi Arabia
Israel
France
Canada
Example: 08618 - 4 digit code, 01742 - dealer no, 444 - importer code, 150307 date of ussue (15 march 2007). As shown on picture you need to enter this data as
"08618-01742-444-150307".
Importer and dealer code are located on the rubber stamp used by the dealer to
2014 XRL
173
2014 XRL
174
ICC Help
EZS - MC9S12DT256
KESSY - MC9S12DT128, 93C86
Immo Box - 24C02, 24C04, 93C46, 93C56, TMS370C702, 68HC05B6, 68HC05B8
ECU - 24C04, 93C46, 93C76, 93C86, 95040, 95080, 95128, 95160, 95320, 95P08
Dashboard - 24C02, 24C04, 24C08, 24C17, 68HC912D60, 68HC912DG128, 68HC912DG256,
68HC711KG2/4, 93C66, 93C86
VDO Dashboards with crypted 93C86 for Audi models made after 2001; Skoda Roomster,
Supeb, Fabia, Seat Ibiza, VW Polo and other models made after 2006 are supported as
well.
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
For PIN codes by dump from KESSY ICC may show 2 codes, first code for old types of
units and second - for new.
Megamos Immo (near steering column):
2014 XRL
2014 XRL
175
176
ICC Help
IMMO Valeo:
2014 XRL
IMMO KOSTAL:
2014 XRL
177
178
ICC Help
2014 XRL
2014 XRL
179
180
ICC Help
2014 XRL
2014 XRL
181
182
ICC Help
2014 XRL
2014 XRL
183
184
ICC Help
2014 XRL
2014 XRL
185
186
ICC Help
Set type of calculation to DMP2CSC and click "Calculate" button, then select a dump
file. ICC will show a CS code and VIN or ID of electronic module if available.
ECU Siemens Simos 7.1A:
2014 XRL
2014 XRL
187
188
ICC Help
2014 XRL
3.16
189
Mitsubishi
Various models of Mitsubishi with 4 digit PIN codes are supported by ICC.
ICC have a list of default codes for immobilizer as well PIN code for immobilizer
can be calculated by dump of EEPROM from Immo Box.
2014 XRL
190
ICC Help
Please note, default PIN code can be changed using an diagnostic scanner. In this
case you will need to read EEPROM dump from Immo Box and calculate a code by dump.
2014 XRL
191
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and additional information if available.
IMMO Mitsubishi:
2014 XRL
192
ICC Help
IMMO Mitsubishi:
2014 XRL
IMMO Cartronic:
2014 XRL
193
194
ICC Help
BSI MN108319:
2014 XRL
3.17
195
BMW
Various models of BMW with EWS2, EWS3, EWS4 and DME, DDE units are supported by
ICC.
2014 XRL
Four
digit
196
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a keys or synchronization password and decrypted VIN.
EWS-3 module (located near pedals):
2014 XRL
2014 XRL
197
198
ICC Help
2014 XRL
2014 XRL
199
200
ICC Help
2014 XRL
3.18
201
PIN code for immobilizer can be calculated by dump of EEPROM from Immo-1 type,
SKIM, SKREEM, WCM.
Default PIN code for some of the models based on Mitsubishi Eclipse platform like
Sebring, Stratus produced in 2000-2001 is 6876.
2014 XRL
202
ICC Help
93C86,
95040,
95080,
MC68HC08AB16A,
MC68HC08AZ32,
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
If ICC will show two PIN codes - please use second one for Immo-1 type with 24C02.
Immo Type-1/2 (near ignition):
2014 XRL
2014 XRL
203
204
ICC Help
2014 XRL
3.19
205
Isuzu
Various models of Isuzu with 4 digit PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from Immo Box and ECU.
2014 XRL
206
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
IMMO Megamos:
2014 XRL
2014 XRL
207
208
ICC Help
2014 XRL
2014 XRL
209
210
3.20
ICC Help
Volvo
Various models of Volvo with IMMO type 1 and CARTRONIC Immo are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from Immo Box.
2014 XRL
211
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
IMMO Bosch (located near pedals):
2014 XRL
212
ICC Help
IMMO Cartronic:
2014 XRL
3.21
213
Porsche
Various models of Porsche with 4, 5 and 6 digit PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from BCM.
2014 XRL
214
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
To calculate PIN code for Porsche Cayenne - select Volkswagen as brand.
BCM Delphi:
2014 XRL
BCM Delphi:
2014 XRL
215
216
ICC Help
2014 XRL
3.22
217
Chang'an
Various models of Chang'an with 4 digit PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from ECU and Immo Box.
2014 XRL
218
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
ECU Bosch ME7.9.7:
2014 XRL
ECU VA1000Q:
2014 XRL
219
220
ICC Help
Immo LAX3605100:
2014 XRL
3.23
221
Great Wall
Various models of Great Wall with 4 chars PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from ECU and Immo Box.
2014 XRL
222
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
ECU Bosch ME7.9.7:
2014 XRL
2014 XRL
223
224
ICC Help
2014 XRL
3.24
225
Samand
Various models of Samand with 4 chars PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM / FLASH from ECU and
Immo Box.
2014 XRL
226
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
ECU Siemens VDO 5WY5866A:
2014 XRL
2014 XRL
227
228
3.25
ICC Help
Ducati
Various models of Ducati with 5 digit PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from Dashboard.
2014 XRL
229
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
Dashboard Magneti Marelli (999):
2014 XRL
230
ICC Help
2014 XRL
3.26
Saab
Various models of Saab with 4 chars PIN codes are supported by ICC.
PIN code for immobilizer can be calculated by dump of EEPROM from CIM.
2014 XRL
231
232
ICC Help
Set type of calculation to DMP2PIN and click "Calculate" button, then select a dump
file. ICC will show a PIN code and VIN or ID of electronic module if available.
CIM (Column Integrated Module):
2014 XRL
3.27
233
Mercedes Benz
Online Key(s) generation for all kind of Mercedes cars, starting from 1997 till
2010 year with Motorola processors.
2014 XRL
234
ICC Help
Set type of calculation to DMP2KEY and click "Calculate" button. ICC will launch
internet browser, follow instructions on screen.
Please note: this is third-party online service available for additional charge.
You need to purchase this option before use. Internet connection is required for
using this service. Please contact us for details.
You can find additional information about this service in "MB Key Generation User's
Guide".
2014 XRL
2014 XRL
235
Part
IV
237
For PIN codes by dump ICC have automatic byte swap function, auto detection of
EEPROM / Flash type, car model, unit type and version.
And for full dump of EEPROM from MCU (64kb) ICC will find beginning of data block
and automatically prepare valid data for calculation. In most cases you don't need
to care about what range of data from MCU to read.
Binary dump files must have correct size: 128, 160, 256, 512, 640, 768, 1024, 2048,
4096, 8192, 16384, 32768, 65536, 262144, 524288, 851968 bytes. Depend of EEPROM /
MCU / Flash type.
File size for other file formats is automatically calculating after conversion to
binary format. Dump files with incorrect file size are not accepted.
For all of supported file types (except YanHua - YHF and ASCII HEX files with
offsets) with wrong file extension or without extension ICC have built-in smart
auto-detection algorithm. Also you can manually select correct file type in "Open
File" dialog box, enter "*" as file name to see all files.
Contact us if you wish to add support of any other file format.
2014 XRL
238
4.1
ICC Help
2014 XRL
4.2
239
2014 XRL
240
4.3
ICC Help
of
this
file
type
is
not
available
due
to
used
2014 XRL
4.4
241
2014 XRL
242
4.5
ICC Help
2014 XRL
4.6
243
2014 XRL
244
4.7
ICC Help
2014 XRL
4.8
2014 XRL
245
246
4.9
ICC Help
2014 XRL
4.10
2014 XRL
247
248
4.11
ICC Help
2014 XRL
4.12
249
FF
00
0F
3C
FF
02
F2
19
D1
FF
D1
FF
FF
FF
FF
FF
FF
84
01
3C
FF
00
FF
FF
A8
FF
6A
FF
FF
FF
FF
FF
FF
34
A4
1E
FF
27
FF
15
4D
FF
17
FF
FF
FF
FF
FF
FF
16
16
3C
FF
73
FF
FF
FF
FF
C6
FF
55
FF
FF
FF
FF
12
26
02
FF
63
FF
FF
FF
FF
E4
FF
D1
FF
FF
FF
FF
11
00
3C
FF
02
FF
FF
FF
03
CA
FF
6A
FF
FF
FF
FF
04
FF
1E
02
12
FF
FF
FF
D1
2B
FF
17
FF
FF
FF
FF
03
FF
1E
FF
04
FF
FF
FF
A8
FF
55
C6
FF
FF
FF
FF
0A
FF
3C
FF
FF
FF
FF
FF
4D
FF
D1
E4
FF
FF
FF
FF
01
FF
02
FF
FF
E0
FF
FF
FF
FF
6A
CA
FF
FF
FF
FF
3F
FF
3C
FF
FF
FF
FF
FF
FF
FF
17
2B
FF
FF
FF
FF
3C
FF
06
FF
FF
FF
FF
03
FF
FF
C6
FF
FF
FF
FF
FF
1E
FF
0A
FF
FF
FF
FF
D1
FF
FF
E4
FF
FF
FF
FF
FF
3C
FF
0C
07
FF
FF
FF
A8
FF
FF
CA
FF
FF
FF
FF
FF
02
FF
02
10
FF
FF
FF
4D
FF
FF
2B
FF
FF
FF
FF
FF
77
FF
FF
FF
96
DF
E0
03
FF
55
FF
FF
FF
FF
FF
FF
00
0F
3C
FF
02
F2
19
D1
FF
D1
FF
FF
FF
FF
FF
FF
84
01
3C
FF
00
FF
FF
A8
FF
6A
FF
FF
FF
FF
FF
FF
34
A4
1E
FF
27
FF
15
4D
FF
17
FF
FF
FF
FF
FF
FF
16
16
3C
FF
73
FF
FF
FF
FF
C6
FF
55
FF
FF
FF
FF
12
26
02
FF
63
FF
FF
FF
FF
E4
FF
D1
FF
FF
FF
FF
11
00
3C
FF
02
FF
FF
FF
03
CA
FF
6A
FF
FF
FF
FF
04
FF
1E
02
12
FF
FF
FF
D1
2B
FF
17
FF
FF
FF
FF
03
FF
1E
FF
04
FF
FF
FF
A8
FF
55
C6
FF
FF
FF
FF
0A
FF
3C
FF
FF
FF
FF
FF
4D
FF
D1
E4
FF
FF
FF
FF
01
FF
02
FF
FF
E0
FF
FF
FF
FF
6A
CA
FF
FF
FF
FF
3F
FF
3C
FF
FF
FF
FF
FF
FF
FF
17
2B
FF
FF
FF
FF
3C
FF
06
FF
FF
FF
FF
03
FF
FF
C6
FF
FF
FF
FF
FF
1E
FF
0A
FF
FF
FF
FF
D1
FF
FF
E4
FF
FF
FF
FF
FF
3C
FF
0C
07
FF
FF
FF
A8
FF
FF
CA
FF
FF
FF
FF
FF
02
FF
02
10
FF
FF
FF
4D
FF
FF
2B
FF
FF
FF
FF
Number of columns (chars per line) is not limited. Supported space separated, CR/LF
separated, and dash separated file formats. HEX (0-9, A-F) values must be in upper
case.
2014 XRL
250
ICC Help
2014 XRL
Part
252
ICC Help
Additional information
Below you will find following information:
2014 XRL
Additional information
5.1
253
Error Messages
Error messages:
"ICC dongle not found" - means that dongle is not connected or drivers are not
installed if dongle was switched to USB mode.
"ICC dongle error 03" - means error in communication, in most cases you can see
this error because of poorly powered USB port or when dongle is removed. Try to
switch dongle from HID to USB mode using ICC Tool or insert dongle to well
powered USB port. Do not use passive USB hubs.
"This module is not installed" - means that for using this function you need to
install latest hardware update with required code calculation algorithm. For lite
version that means what you need to purchase additional module.
"ICC dongle is blocked" - means that your have violated our rules and your dongle
is permanently blocked.
2014 XRL
254
5.2
ICC Help
Abbreviations
AAM
BCM
BCU
BMT
BSI
CCU
CIM
CPH
CSC
DAS
Dash
Dump
DMP
DME
ECM
ECU
ECU
EIS
EKA
EMS
EWS
EZS
HDS
HIM
HISS
ICC
ICM
ICS
ICS
ICU
IDS
IKE
ISN
ISN
IVIS
Immo
Immo Box
Immobizer
IMMU
KESSY
KOS
MECS
NATS
NVIS
OBD
PATS
PCM
PIN
REC
SAIS
SAM
SCN
SEC
SEC
SKIM
SKREEM
SKC
SMARTRA
Transponder
UCH
Additional information
UCBIC
VCM
VIN
VIS
WCM
WDS
WMI
WSC
2014 XRL
255
256
5.3
ICC Help
Bosch
Mask
MCU
Mask
EEPROM / MCU
A20T
A38P
A49N
A75H
B16B
B19C
B36T
B46E
B60R
B65H
B83T
B84N
B91T
B95T
B96D
C11W
C13W
C14H
C16J
C16W
C27B
C28M
C35N
C40H
C45A
C47M
C83W
C85W
C91F
C92K
C95K
D10J
D20J
D26E
D28J
D33J
D35E
D37R
D40J
D40J
D41V
D45R
D46J
MC68HC705S3
MC68HC11A8
MC68HC11A8
MC68HC811A2
MC68HC805C4
MC68HC811E2
MC68HC805B6
MC68HC11A8
MC68HC11E9
MC68HC11A8
MC68HC05B8
MC68HC11A1
MC68HC05B6
MC68HC11A8
MC68HC11A8
MC68HC11A1
MC68HC11L6
MC68HC05B6
MC68HC811E2
MC68HC705C8
MC68HC11E1
MC68HC11G5FN1
MC68HC05B16
MC68HC05J1
XC68HC711D3
MC68HC711E9
MC68HC11E9
XC68HC711L6
MC68HC11E1
MC68HC05C12A
MC68HC05E0
MC68HC705B5
MC68HC05B16
MC68HC11A1
MC68HC705B16
MC68HC705B16
MC68HC11E9
MC68HC05C12A
MC68HC705B32
MC68HC705X32
XC68HC705BE12
MC68HC11ED0
MC68HC11A8
B22AN
B34AB
B42AB
B43AB
B46AJ
B49AJ
B52AP
B54AH
B81AB
B56022
B57324
B57325
B57347
B57423
B57477
B57519
B57546
B57604
B57605
B57607
B57610
B57618
B57618
B57625
B57654
B57684
B57696
B57701
B57764
B57764
B57769
B57771
B57808
B57922
B57960
B57995
B58014
B58038
B58094
B58098
B58126
B58127
B58150
93C06
24C02
93C06
24C02
24C02
24C02
24C02
24C02
93S66
27C128
2732A
27C32
27C64
27C256
27C64
27C64
27C010
27C256
27256
27C128
27C128
87C257
87C64
2764A
27C256
27C256
27C256
27C256
87C257
87C64
MC68HC05SR3
27C256
27C256
87C257
27C256
TMS27C256
27C256
27C256
27C510
27C512
27C010
27C512
87C257
2014 XRL
Additional information
D47J
D48J
D53J
D54E
D54J
D58J
D59J
D59J
D60J
D61N
D62J
D67F
D69F
D69J
D82R
D82R
D86B
D99H
E11P
E20T
E20Y
E22B
E25B
E28B
E31M
E32B
E38B
E41C
E53M
E54F
E57S
E59B
E61R
E61W
E62H
E62W
E69W
E74J
E75J
E78C
E79R
E82K
E88N
F10V
F10W
F11N
F12A
F17V
2014 XRL
MC68HC11EA9
MC68HC11PH8
MC68HC05X32
MC68HC705P9
MC68HC05B8
MC68HC11PA8
MC68HC705B32
MC68HC705X32
MC68HC05B16
XC68HC711KA4
MC68HC05X16
MC68HC711K4
PC68HC711N4
MC68HC05X32
MC68HC11E9
MC68HCP11E1
MC68HC705J2
MC68HC711P2
MC68HC16Z2
MC68HC705C4A
MC68HC705P6CP
MC68HC11E20
MC68HC05P3
MC68HC11E9
MC68HC705K1
MC68HC05C8
MC68HC05J3
PC68HC916Y1
MC68HC711P2
MC68HC16Z1
MC68HC11KA4
MC68HC11KA4
MC68HC705C8
MC68HC705F8
MC68HC11K4
MC68HC16Z1
MC68HC16Z1
MC68HC11P2
MC68HC11K4
MC68HC05J1A
MC68HC705C8A
MC68HC11E20
MC68HC711KA2
MC68HC05B6
MC68HC705SR3
MC68HC11L6
MC68HC05J1A
MC68HC11F1B4
B58157
B58185
B58196
B58213
B58214
B58234
B58235
B58239
B58243
B58252
B58253
B58256
B58258
B58275
B58293
B58323
B58331
B58334
B58335
B58380
B58381
B58399
B58400
B58424
B58517
B58530
B58533
B58539
B58541
B58542
B58543
B58544
B58545
B58546
B58547
B58548
B58550
B58601
B58608
B58639
B58647
B58718
B58755
B58768
B58791
B58813
B58838
B58911
27C512
87C257
93C46
93C06
27C256
27C256
87C257
27C512
CJ87BC6QG
24C02
24C02
24C01
24C02
27C1024
27C512
93C46
28F010
28C64
AT28C64B
24C02
AM28F512
AM29F010
87C510
27C512
27C020
27C010
27C4096
27C256
27C512
27C512
27C512
27C1001
87C257
87C510
27C010
TMS27PC210
27C512
AM29F200B
93C66
87C510
87C257
27C512
AM29F200
AM29F400AB
AM29F200AB
93C56
27C256
TMS27C010A
257
258
ICC Help
F23H
F29K
F33P
F37E
F41E
F41J
F44T
F49K
F52E
F53E
F56K
F62A
F62J
F63J
F67V
F68K
F71L
F73K
F73T
F74B
F88B
F92J
F96J
F97J
F98Y
G10V
G11D
G23V
G26C
G28F
G32V
G33P
G35N
G39Y
G40G
G41V
G47V
G49V
G53F
G54K
G58F
G58T
G59F
G62K
G63P
G78M
G96A
G96Y
MC68HC05P4A
MC68HC11MA8
PC68HC16V1
MC68HC11F1
MC68HC05L28
MC68HC05L28
MC68HC705J1A
MC68HC705C8A
MC68HC11E32
MC68HC11KG4
MC68HC705B16
MC68HC05C8
MC68HC05B16
MC68HC705C9A
MC68HC16Z1
MC68HC912D60
MC68HC05C8
MC68HC912D60
MC68HC16Z1
MC68HC05X4
MC68HC705X4
MC68HCP11A1
MC68HC11E9
MC68HC11E9
MC68HC708AS48
MC68HC(7)11P2
MC68HC16Z2
MC68HC08AZ32
MC68HC16Z3
MC68HC05B16
MC68HC11KG4
XC68HC705P6ACP
MC68HC05B16
MC68HC08AS20
MC68HC805K3
MC68HC705B32
MC68HC705X32
MC68HC08AZ32
MC68HC05J1A
MC68HC05TB
MC68HC705J1A
MC68HC705JJ7
MC68HC711E20
MC68HC708AS48
MC68HC705J1A
MC68HC705V12
MC68HC705B32
MC68HC705V12
B9411
AM27C256
2014 XRL
Additional information
H14A
H19S
H24M
H32S
H42K
H48T
H50F
H50W
H52P
H54T
H55B
H55F
H55W
H56A
H57A
H62A
H62P
H72J
H73K
H77A
H86A
H91F
H94K
H96J
H98X
J15G
J20X
J26H
J26R
J27F
J34P
J35D
J37F
J38M
J54E
J56W
J61D
J64Y
J66D
J66H
J73R
J74Y
J79Y
J88Y
K00J
K02S
K03B
K05W
2014 XRL
MC68HC708AS48
MC68HC711E20
MC68HC05V12
MC68HC705JB4
MC68HC705C8A
XC68CM16Z1
MC68HC812AV4
MC68HC711E9
MC68HC705V12
MC68HC12BE32
MC68HC705BD9
MC68HC805K3
MC68HC912DG128
MC68HC08AZ32
MC68HC05H12
MC68HC908AS60
MC68HC908AT32
MC68HC705C8A
68HC812AV4
MC68HC705C9A
MC68HC711KG2
MC68HC912B32
MC68HC08AS20
MC68HC05JJ6
MC68HC11KS8
MC68HC912BC32
MC68HC908GP32
MC68HC08AS20
MC68HC08AS20
MC68HC08AS32
MC68HC12BE32
MC68HC08AZ60
MC68HC908MR24
MC68HC12BE32
MC68HC912B32
MMC2001
MC68HC908AS60
MC68HC912B32
MC68HC08AZ32
MC68HC705J1A
MC68HC705C8A
MC68HC908AS60
MC68HC908BD48
MC68HC908JK3
MC68HC908RK2
MC68HC05P4A
MC68HC705C9A
MC68HC711D3
259
260
ICC Help
K07E
K08B
K08S
K08W
K11N
K13J
K20R
K22K
K25E
K29E
K36N
K38K
K39K
K45D
K45H
K50E
K54X
K56G
K59D
K59H
K75F
K78X
K79X
K81H
K82H
K85K
K85V
K91D
L02H
L05H
L06H
L09H
L45J
L51J
L52H
L53J
L54J
L69J
L72A
L85D
L87J
MC68HC11KS2
MC68HC705C8A
MC68HC908GP32
MC68HC711KS2
MC68HC908LD64
MC68HC12D60
MC68HC05PV8A
MMC2001
MC68HC912BC32
MC68HC912BD32
MC9S12DP256
M68HC912D60
MC68HC908SR12
MC68HC908KX8
MC68HC908JB8
MC68HC912DG128
MC68HC711K4
MC68HC908AB32
MC68HC08JB8
PC527283MFU
MC68HC912D60
MC9S12H256
MC9S12DP256
MC68HC711E9
MC68HC11E20
MC68HC908AZ60A
MC68HC908AZ60A
MC68HC912DG128
M68HC912D60
M68HC912DT128
MC68HC908SR12
MC68HC908KX8
MC9S12C32
M68HC912D60
MC68HC08AZ32A
MC68HC908GR8
MC68HC908MR32
MC68HC908QT1-4
MC68HC08AB16A
MC9S12A128
MC68HC908AZ60A
2014 XRL
Additional information
5.4
261
2014 XRL
262
5.5
ICC Help
Login must be entered in upper case, without blanks and quotes. Password must be
entered in lower case, without blanks and quotes.
Please use direct link
accessing support area.
http://immo-code.com/updates
if
you
have
problems
2014 XRL
Additional information
5.6
263
2014 XRL
264
5.7
ICC Help
Special thanks
Special thanks for advice and help to (in alphabetical order):
Andrzej Poludniak
Anton Snytko
Di Tianzheng
Dmitriy Baravliov
Dmitriy Elagin
Elie Daoud
Gennady Kudinov
Greg Chambers
Jeff Bayliss
Juan Alfredo Trejo
Piotr Witkowski
Saber Derwish
Wen Jin Xiang
2014 XRL
Additional information
2014 XRL
265