Documente Academic
Documente Profesional
Documente Cultură
TECHNICAL DATA
Power Range
66 yards
Caliber/Ammunition
Magazine capacity
550 BBs
Total length
Weight
Accuracy
50/25 (You can hit a quarter from 50 feet with .20g bbs)
Velocity
Shooting System
Spin up system
-Never aim at a person, shoot fragile objects, or point at anything you do not wish to shoot.
-Keep finger off the trigger until ready to shoot and use eye protection
-Be careful to avoid rebounding.
-Keep out of reach of children.
-Only use .20 g and .25 g BBs
INSTRUCTIONS
A) Release magazine by pushing on the lever (1) located in front of th trigger gauerd and slide the magazine out of the
receptacle (2).
B) To load the magazine, open the tab on top (1) and fill the compartment with recommended BBs (about 300 BBs) into
compartment (2).
C) Spin the wheel located at the bottom of the magazine anticlockwise for about 1 minute. Repeat operation every 150
shots.
D) Insert magazine in receptacle. If you notice some dry firing during burst, spin the wheel again.
E) Push the release (1) as shown on the picture to open the reciever top (2).
F) Plug the charged battery to the connector (1) and slide it into compartment. Make sure to place the wires under the
connector.
G) Push (1) and lock cover back in place (2) as shown in picture.
H) Access the Hop Up system by pullin on the charging handle (1). Move the cursor to adjust firing system (2). Adjust
according to weight of BBs used.
I) Adjust rear sight (Hop Up must be adjusted first) by moving the sliding part up or down (1). Release button is loacted
on the left side of it (2).
J) To start shooting, aim at target, select (1) the desired firing mode (semi or full auto mode) and pull the trigger (2).
SEMI
AUTO:
fire
1
BB
FULL AUTO: Constant firing until trigger is released.
each
time
you
pull
the
trigger.
K) After you are done shooting remove the magazine and put the selector back in "SAFE" position. Make sure to remove all
BBs from rifle and/or magazine before storage.
M) To fold or unfold the certical grip, press the release shown on the picture.
N)
1Push
the
stock
as
shown
2- 3 -4: Push down firmly the stock as shown on (2) and fold as shown on (3) & (4).
to
unfold.