Documente Academic
Documente Profesional
Documente Cultură
Page 1
Reviewed on 05/28/2015
1: Identification
1.1 Product identifier
Trade name: Penetrant DP-50
1.2 Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
Application of the substance / the mixture Penetrant
1.3 Details of the supplier of the safety data sheet
Manufacturer/Supplier:
Sherwin Incorporated
5530 Borwick Ave
South Gate, CA 90280
Phone: (562) 861-6324
Fax: (562) 923-8370
https://www.sherwininc.com/
Information department: Product safety department
1.4 Emergency telephone number:
Chemtrec +1-800-424-9300 in U.S.A.; outside U.S.A. 001-703-527-3887
Chemtrec contract number 20103
2: Hazard(s) identification
2.1 Classification of the substance or mixture
Classification according to Regulation (EC) No 1272/2008
Asp. Tox. 1 H304 May be fatal if swallowed and enters airways.
Eye Dam. 1 H318 Causes serious eye damage.
Skin Irrit. 2 H315 Causes skin irritation.
Suspected of damaging fertility or the unborn child.- NOT listed as carcinogenic by IARC, NTP or OSHA-Ca
2.2 Label elements
Labelling according to Regulation (EC) No 1272/2008
The product is classified and labeled according to the CLP regulation.
Hazard pictograms
GHS05
GHS08
40.0
Page 2
Reviewed on 05/28/2015
P405
P501
Classification system:
NFPA ratings (scale 0 - 4)
Health = 2
Fire = 1
Reactivity = 0
HMIS-ratings (scale 0 - 4)
HEALTH
*2
FIRE
REACTIVITY 0
Health = *2
Fire = 1
Reactivity = 0
3: Composition/information on ingredients
3.2 Chemical characterization: Mixtures
Description: Mixture of the substances listed below with nonhazardous additions.
Dangerous components:
CAS: 64742-47-8
EINECS: 265-149-8
CAS: 68131-40-8
CAS 64742-52-5
25-50%
25-50%
10-20%
CAS: 92257-31-3
C.I.Solvent Red 164 (eq)
EINECS: 296-120-8
CAS: 64742-94-5
Solvent naphtha (petroleum), heavy arom.
EC number: 919-284-0
1-10%
1-10%
25-50%
25-50%
10-20%
Additional information:
Metabolic studies on some Azo-dyes have detected reduction of azo bonds to aromatic amines. It is prudent to
assume that the product could metabolise to o-toluidine, which have been identified as animal carcinogens.
*
4: First-aid measures
4.1 Description of first aid measures
After inhalation:
Supply fresh air. If required, provide artificial respiration. Keep patient warm. Consult doctor if symptoms
persist.
In case of unconsciousness place patient stably in side position for transportation.
(Contd. on page 3)
USA
40.0
Page 3
Reviewed on 05/28/2015
5: Fire-fighting measures
5.1 Extinguishing media
Suitable extinguishing agents:
Water haze
Foam
ABC powder
For safety reasons unsuitable extinguishing agents: Water spray
5.2 Special hazards arising from the substance or mixture Carbon monoxide and carbon dioxide
5.3 Advice for firefighters
Protective equipment:
Wear self-contained respiratory protective device.
Wear fully protective suit.
*
40.0
Page 4
Reviewed on 05/28/2015
Protective gloves
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation
Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of quality
and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the
resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the
application.
Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has to be
observed.
(Contd. on page 5)
USA
40.0
Page 5
Reviewed on 05/28/2015
Eye protection:
Safety glasses
Tightly sealed goggles
Body protection:
Protective work clothing
Use protective suit.
Not determined.
Change in condition
Undetermined.
> 236 C (> 457 F)
> 93 C (> 199 F) (ASTM D-93)
Not applicable.
Ignition temperature:
270 C (518 F)
Decomposition temperature:
Not determined.
Auto igniting:
Danger of explosion:
Explosion limits:
Lower:
Upper:
0.5 Vol %
7.0 Vol %
Vapor pressure:
Not determined.
Vapour density
Not determined.
Evaporation rate
Not determined.
Water:
Not determined.
Dynamic:
Not determined.
(Contd. on page 6)
USA
40.0
Page 6
Reviewed on 05/28/2015
(Contd. of page 5)
Not determined.
Solvent content:
Organic solvents:
VOC content:
9.2 Other information
1.5 %
1.5 %
13.0 g/l / 0.11 lb/gl
No further relevant information available.
12
(Contd. on page 7)
USA
40.0
Page 7
Reviewed on 05/28/2015
not applicable
not applicable
not applicable
not applicable
(Contd. on page 8)
USA
40.0
Page 8
Reviewed on 05/28/2015
No
Not applicable.
Not applicable.
(Contd. on page 9)
USA
40.0
Page 9
Reviewed on 05/28/2015