Documente Academic
Documente Profesional
Documente Cultură
Magnetic sensor mounting fixtures can be used for mounting WT100/101 (clamp specific), WT200
and WT210 series sensors as an alternative sensor mounting solution to stud welding or clamping on
pipes and vessels. Each fixture accommodates one sensor and it is fixed onto the pipe using only the
pull forces provided by the magnets.
Refer to 'Installation guide - 500 series magnetic sensor fixture'.
Refer to the datasheet for the relevant sensor model being installed.
Table of Contents
Safety notices............................................................................................................................................................... 2
Specification ................................................................................................................................................................. 3
Introduction ................................................................................................................................................................. 3
Operating temperatures ............................................................................................................................................ 3
Dimensions .................................................................................................................................................................. 4
Handling, storage and transit .................................................................................................................................... 5
Permasense Ltd, Century House, 100 Station Road, Horsham, RH13 5UZ, UK
www.permasense.com
support@permasense.com
+44 20 3002 0922
Safety notices
Strong magnets are used in this product
Do not use near medical equipment or magnetically sensitive electrical equipment.
Do not switch ON unless it is on a pipe.
Hazards:
H314 Causes severe skin burns and eye damage.
H302 Harmful if swallowed.
EUH014 Reacts violently with water.
Permasense Ltd, Century House, 100 Station Road, Horsham, RH13 5UZ, UK
www.permasense.com
support@permasense.com
+44 20 3002 0922
Specification
Magnetic units:
MagSquare 600 X 4
Bolts
Without handles
8.5 [18.74]
8 [1798]
1 [224.81]
Sensor compatibility
4 [2.95]
Warning. Do not use standard torque settings nominally quoted to 8Nm to install sensors using
this sensor mounting method.
Introduction
Each fixture has four magnetic units. The fixture is installed by switching ON the magnetic units and
can be uninstalled by switching them OFF using the handles. The handles are removable to avoid
accidental change of state of the magnets.
Operating temperatures
Magnetic fixture ID
Operating temperature (C) [F]
510
511
Permasense Ltd, Century House, 100 Station Road, Horsham, RH13 5UZ, UK
www.permasense.com
support@permasense.com
+44 20 3002 0922
Dimensions
mm[inches]
Permasense Ltd, Century House, 100 Station Road, Horsham, RH13 5UZ, UK
www.permasense.com
support@permasense.com
+44 20 3002 0922
18 [40]
Permasense Ltd, Century House, 100 Station Road, Horsham, RH13 5UZ, UK
www.permasense.com
support@permasense.com
+44 20 3002 0922