Documente Academic
Documente Profesional
Documente Cultură
Part I
Pre-Construction Phase (FALAR 1)
Project:
Prepared by:
Approved by:
1. Objectives
This is a compilation of the plans/specifications and design analysis submitted by
the Architect/Engineer.
It deals with life safety from fire, smoke and like emergencies of the proposed
project.
P.D. 1096 directed the DPWH Secretary to prescribe standards, rules and
regulations on fire resistivity. However, on 25 March 1978, The President
issued P.D. 1185 known as the Fire Code of the Phil, which more than
satisfied the requirements called for by P.D. 1096. Implementation was
vested to the Dept. of Natl. Defense and was assigned to and enforced by
the Chief of the Local Fire Service (CLFS) in each municipality or City.
The Administration and Enforcement of the Fire Code (R.A. No. 9514: FIRE
CODE OF THE PHILIPPINES OF 2008) and this IRR shall be under the direct
supervision and control of the Chief, BFP, through the hierarchy of
organization as provided for in Chapter VI of Republic Act No. 6975, the DILG
Reorganization Act of 1990 as amended by Republic Act No. 9263, the Bureau
of Fire Protection (BFP) and Bureau of Jail Management and Penology (BJMP)
Professionalization Act of 2004.
National Structural Code of the Phil. (NSCP) Vol. I (Buildings), 1992 Ed.,
Association of Structural Engineers of the Philippines, Inc. (ASEP)
The design and construction of the proposed building and its structures
will be in compliance with the provisions of the National Structural
Code for Buildings, latest edition, adopted and promulgated by the
Board of examiners of Civil Engineers pursuant to Republic Act
Numbered 544, as amended, otherwise known as the "Civil
Engineering Law".
The average area of the bedrooms is 12.0 square meters; kitchen: 8.40
square meters; and 2.20 square meters for bathrooms.
Basis of design;
The design was based on the FIRE CODE OF THE PHILIPPINES OF
2008 (R.A. No. 9514)
ii.
Number of exits;
The proposed building is composed of two exits; one at the front and
one at the back. The first floor is more or less 3.0 meters high from the
ground.
iii.
Travel distances;
Travel distance from the farthest point to exit doors is more or less 4 to
5 meters away.
f.
j.