Documente Academic
Documente Profesional
Documente Cultură
Configuration
Lang: support CHS, CHT, ENGLISH, adjust though "V-"
DataCrct: general to the default, for example, print a "color lump"in
500mm*500mm, and the actual size is 500mm*600mm, can adjust it, if the actual
length is longer than the target length, increase this value, conversely, decrease the
value.
BlnkCrct: the distance between the text/image and text/image, the adjustment is the
same as "DataCrct"
be damaged.
PrHeatST: set the heating speed of the "Pre-heat", usually use it below 10 ,
please used carefully, for if misemploy, the printing result will be not good or the
printhead will be damaged.
Motor Acc: Default for 80, please don't adjust this value at will, otherwise, the
printing result will be not good or the printhead will be damaged.
Restore CFG
CFG:: if click " Enter", the mainboard goes back to default value.
FormatS: use to format SD card or USB
Pressing "test" can adjust the printing settings, and can change for
the memory device.
When the machine works, the machine will stop printing after
printing the text/image, repress, the machine will continue to work, in "Suspend"and
Can delete the file in the memory device; if press it, the machine
will stop working in the process of printing, repess it and the machine continues to
print.
Output print
Equipment adjustment
When install the foil, make sure it is in the middle
Press down the red and green buttons to make sure the foil flat
Press"test" to find the printing result, if not good, pls adjust the settings and printhead
position.