Documente Academic
Documente Profesional
Documente Cultură
I. Preparatory Procedure:
1. Enable Usb debugging and Enable OEM unlock in the Developer Options of your Note 3
(Additional Settings > Developer Settings>...), look Fig.1.
FIG.1.
2.
3.
4.
5.
FIG. 2.
6. Open the folder kenzoUnlock in the root of system disk C on your PC. In this folder you must to open the
Command Prompt window (Shift+Rigth click of Mouse and click option Open Command Prompt, for
example).
7. Now check if the Phone is connected via ADB or not (Fig. 3.). Type in the Command Prompt:
adb devices
and press Enter. Your Phone must be identified (FIG. 3.).
FIG. 3.
To troubleshoot disable-enable Usb debugging from Developer options in the Developer Settings.
Now you should be to connect Phone to PC and push button "Refresh" in MiFlash
III. Flashing:
1.
2.
Boot your Phone to Fastboot Mode by pressing "Volume Down + Power" for about 30 seconds.
The phone would switch to Fastboot Mode (rabbit in the hat). If the Phone was disconnected
from PC, please, connect it to PC again and open "Command Prompt" in the folder
"Archive_kenzoUnlock" on PC.
Type in the "Command Prompt" the command:
fastboot devices
3.
and you must to see response which is similar as in the case of the command "adb devices" (point
7 of "Preparatory Procedure" in this instruction). Now Phone connected to PC in the Fastboot
Mode.
Type in the "Command Prompt" the command:
FIG. 4.
If you don't want to flash the custom recovery then type the command:
fastboot reboot
for restart of your Phone. In other case we go into the part about flashing the custom recovery.
If your Phone there in the Fastboot Mode, connected to PC and Command Prompt is open in
the folder Archive_kenzoUnlock (in this folder there file "twrp-3.0.2-1-kenzo.img") then type in
"Command Prompt" the command:
fastboot reboot
for restart your Phone.
THE END.
Citation: DON'T FLASH MIUI RECOVERY ZIP ROM VIA TWRP after unlocking bootloader. IT HAS
STOCK BOOTLOADER AND IT WILL BE RELOCK BOOTLOADER AND THEN BOOTLOOP . Only use
Fastboot ROM and that too replace the unlocked bootloader file. If you are stuck on bootloop then try
to go to Qualcomm download mode using test points:
http://en.miui.com/data/attachment/forum/201603/20/235834ytz0829mcse0gj14.jpg