Documente Academic
Documente Profesional
Documente Cultură
Installation Instructions
SUGGESTED TOOLS
Hoist
Metric wrenches
Metric sockets
REMOVAL
1
11744 NE Ainsworth Circle, Portland, OR 97220 (503) 257-7500 Fax (503) 257-7596
REMOVAL
3
3A
3D
3B
Lower the rear of the subframe by lowering the screw jack. While lowering, ensure that the steering
rack separates from the subframe. Pry the rack from the subframe if necessary. It is always a good
idea to leave most of the weight of the subframe on the screw jack while working.
Remove the left and right end link from the sway bar. Use a T30 torx socket in the center of the end
link fastener to hold the threads from turning and a 15mm on the nut.
10
Remove the sway bar U-bracket bolts (14mm) on the left and the right sides.
1-800-444-6473
REMOVAL
11
Once the bar is loose from the subframe the bar may be
withdrawn from the subframe. This may take some careful
manipulation so dont be afraid to pull down on the
subframe for additional clearance.
12
13
13
11
12
INSTALLATION
1
Assemble the new bushings and new U-brackets onto the new bar and lube the bushings with the
supplied lubricant. Locate the bushings and U-brackets over the holes in the subframe install the four
bolts that were removed. Slide the U-brackets and bar as far toward the rear of the car as
possible. Then tighten bolts to 37ft.lbs.
Raise rear of subframe with the screw jack. Guide the steering rack studs into the sub-frame as it is
raised.
Once the subframe is raised, install the two long rear subframe bolts through the brackets along with
the four bracket stay bolts but do not tighten yet.
Tighten the left subframe bolts front and rear to 77ft.lbs. And then an additional 120 degrees. Now
tighten the right side bolts in the same fashion. Dont forget to tighten the front bolts that were
loosened.
www.ipdusa.com
INSTALLATION
8
A. Re-attach the oxygen sensor bracket to the rear of the subframe with the torx bolts. (2001-on)
B. Re-attach the fluid line bracket bolts and tighten front to rear. (1993-2000)
10
Lower car to ground and make sure the new bar avoids all the suspension components.
11
KIT CONTENTS
6K5036 S80 all models 1999-2006
6K5043 S60 AWD, V70 AWD & XC 2001-06
6K5046 S60R Trac Spec Kit 2004-06
6K5047 V70R Trac Spec Kit 2004-06
Description
1. SB1006F
25mm front sway bar
SBK12 - Sway Bar Mounting Kit
2. 2001
ipd emblem
3. 2B1103
25mm polyurethane bushing
4. B181
Saddle bracket
5. Aqualube Waterproof grease
Qty
1
2
2
2
1
Part #
Description
Qty
1
2
2
2
1