Documente Academic
Documente Profesional
Documente Cultură
12 Clintonville Rd
Northford, CT 06472-1653
(203) 484-7161
Ripple Voltage:
Current:
Temperature Range:
Humidity:
Dimensions:
Accessories:
15 to 32 VDC
5.1 mA (LED on)
270A (LED flashing)
3.9K Ohms
25 Ohms
Terminals T3 and T4)
18-28 volts power limited (19 to 28VDC when used with MTL isolator model MTL3043 in
intrinsically safe applications)
0.1 Volts RMS maximum
90mA per module
32F to 120F (0C to 49C)
10% to 93% Noncondensing
41/2 H x 4 W x 11/4 D (Mounts to a 4 square by 21/8 deep box.)
SMB500 Electrical Box
Before Installing
This information is included as a quick reference installation guide. Refer to the control panel installation manual
for detailed system information. If the modules will be
installed in an existing operational system, inform the
operator and local authority that the system will be temporarily out of service. Disconnect power to the control panel
before installing the modules.
1. Install module wiring in accordance with the job drawings and appropriate wiring diagrams.
2. Set the address on the module per job drawings.
Note: Some panels support extended addressing. In
order to set the module above address 99 on compatible
systems, carefully remove the stop on the upper rotary
switch with thumb in the direction shown in Figure 1.
3. Secure module to electrical box (supplied by installer),
as shown in Figure 2A.
Figure 1. Removing
Rotary Switch Stop:
General Description
The FZM-1 Interface Module is intended for use in intelligent, two-wire systems, where the individual address of
each module is selected using the built-in rotary switches.
This module allows intelligent panels to interface and monitor two-wire conventional smoke detectors. It transmits the
status (normal, open, or alarm) of one full zone of conventional detectors back to the control panel. All two-wire
detectors being monitored must be UL compatible with this
module. The FZM-1 has a panel controlled LED indicator
and can be used to replace an MMX-2 module in existing
systems.
8
7
6
5
LOOP
ONES
1
2
3
4
ADDRESS
A78-2318-07
Figure 2B:
0
Wiring
NOTE: All wiring must conform to applicable local codes,
ordinances, and regulations. This module is intended for power-limited wiring only.
4 5 67
8
3
9
2
10
TE
NS 1
11
0
4 5 6 7 15 1 1 12
8 4 3
2
9
1
0
Mounting
The FZM-1 mounts directly to 4 square electrical boxes (see
Figure 2A). The box must have a minimum depth of 21/8 .
Surface mounted electrical boxes (SMB500) are available
from Notifier
www.PDF-Zoo.com
67 8 9
5
10
11
4
3
12
13
2
1 0 15 14
TENS
8
7
6
9
5
4
3
2
10
Compatibility Requirements
To ensure proper operation, this module shall be connected
to a compatible Notifier system control panel only (list
available from Notifier).
N500-49-00
S
ONE
4 5 67
8
3
9
2
10
TE
NS 1
11
0
5
1
4 6 7 5 1 1 12
3
8 4 3
2
9
1
0
Specifications
Normal Operating Voltage:
Maximum Current Draw:
Average Operating Current:
EOL Resistance:
Maximum IDC wiring resistance:
External Supply Voltage (between
DC Voltage:
ES
ON
4
ES
DR
AD
ES
DR
AD
A78-2611-12
A78-2610-10
I56-1172-06
COMMUNICATION LINE
32 VDC MAX.
TWISTED PAIR
IS RECOMMENDED
)(
TO NEXT
)+(
DEVICE
)(
)+(
FROM PANEL OR
PREVIOUS DEVICE
INTERFACE
MODULE
9
8
7
6
5
3.9K EOL
RESISTOR
(INCLUDED)
A2143-10
LOOP
67 8 9
5
10
11
4
3
12
13
2
1 0 15 14
TENS
6789
5
4
3
2
10
ONES
)(
)+(
)(
)+(
ADDRESS
A78-2394-14
TO NEXT
DEVICE
)(
)(
)+(
)+(
COMMUNICATION LINE
CONNECT MODULES
32 VDC MAX.
TO LISTED COMPATIBLE
TWISTED PAIR
IS RECOMMENDED CONTROL PANELS ONLY.
FROM PANEL
OR PREVIOUS
DEVICE
TO NEXT
DEVICE
)(
)(
)+(
)+(
RELAY
CONTROL
MODULE
INTERFACE
MODULE
9
8
7
6
5
LOOP
67 8 9
5
10
11
4
3
12
13
2
1 0 15 14
TENS
6789
5
4
3
2
10
ONES
POWER LIMITED
DC POWER SUPPLY,
LISTED FOR FIRE )+(
PROTECTION
WITH BATTERY )(
BACKUP
)(
)+(
)(
)+(
3
4
ADDRESS
)(
LISTED BATTERY-BACKUP,
SWITCHED DC POWER SUPPLY.
6
5
)+(
LOOP
)(
)+(
3
4
ADDRESS
FROM
PANEL OR
PREVIOUS
DEVICE
A78-2396-10
A78-2395-14
)(
TO NEXT
COMMUNICATION LINE
32 VDC MAX.
TWISTED PAIR
IS RECOMMENDED
)+(
DEVICE
)(
)+(
FROM PANEL OR
PREVIOUS DEVICE
INTERFACE
MODULE
9
8
7
6
5
3.9K EOL
RESISTOR
(INCLUDED)
A2143-10
LOOP
67 8 9
5
10
11
4
3
12
13
2
1 0 15 14
TENS
6789
5
4
3
2
10
ONES
0
1
2
)(
)+(
MTL3043 ISOLATOR
N500-49-00
ADDRESS
www.PDF-Zoo.com
)(
)+(
A78-2394-29
I56-1172-06
2001 Notifier