Documente Academic
Documente Profesional
Documente Cultură
BF2OAe25A
CONTENTS
This manual covers the construction, function and servicing procedures of the Honda BFZOAIBF25A outboard
motors.
Careful observance of these instructions will result in better, safer service work.
Illustrations in this manual are based primarily on the
BF25A LRS.
SPECIFICATIONS
SERVICE INFORMATION
MAINTENANCE
ENGINE COVERITHROTTLEICHOKE
FUEL SYSTEM
SWIVEL CASE
ELECTRICAL EQUIPMENT
OPERATION
WIRING DIAGRAM
1 BF30 SUPPLEMENT
http:llwww.ReadManuals.Com
HONDA
3. MAINTENANCE
BF30A
2. ACCELERATION DEVICEIDIAPHRAGM
ASSEMBLY
1. ENGINE OIL
INSPECTION
Used engine oil may cause skin cancer if repeatedly
left i n contact w i t h the skin for prolonged periods.
Although this is unlikely unless you handle used oil on
a dailybasis, it is still advisable t o thoroughly wash
your hands w i t h soap and water as soon as possible
after handling used oil. KEEP OUT OF REACH OF CHILDREN.
1) Place the outboard motor in the vertical position.
2) Remove the engine cover.
3) Remove the oil dipstick and wipe it clean.
4) Insert it all the way down the dipstick hole, then pull it out
and read the oil level.
5) If the oil level is low, add the necessary recommended
engine oil to bring the oil level to the upper level on the
dipstick. Do not overfill.
SAE5W - 30
API Service classification
Fuel Efficient SG, SH.
NOTE
This oil is usually identified by words such as: "Energy
Conserving II.""Gas Saving,""Fuel Saving," etc.
When a new oil filter has been installed, recheck the
engine oil level after running the engine for a few minutes.
Draining can be performed rapidly and completely when
the engine is still warm.
Place a shop towel under the oil filter when removing
the oil filter.
CAUTION
Running the outboard motor without sufficient cooling
water will damage the water pump and overheat the
engine. Be sure that water flows from the cooling system indicator while the engine is running. If not, stop
the engine and determine the cause of the problem.
Keep clear of moving parts.
http://www.ReadManuals.Com
141
STOPPER
(At bcked)
LEVER
3=9
Page: 275 - Honda BF2OA-BF25A, BF25D-BF3OD Outboard Motors Shop Manual -
http:l/www.ReadManuals.Com
This manual covers the construction, function and servicing procedures of the Honda
BFZOAIBF25A outboard motors.
Illustrations in this manual are based primarily on the BF25A LRS.
Paper book Part No. 66ZV700
Manual Chapters:
1. SPECIFICATIONS
2. SERVICE INFORMATION
3. MAINTENANCE
4. ENGINE COVER/THROTTLE/CHOKE
5. FUEL SYSTEM
6. FLYWHEEL/TIMING BELT
7. RECOIL STARTER (TILLER HANDLE TYPE ONLY)
8. ENGINE REMOVAL/INSTALLATION
9. WATER JACKET COVER/THERMOSTAT/THERMO SWITCH
10. CYLINDER HEAD/VALVES/OIL PUMP
11. CRANKCASE/CYLINDER BLOCK/CRANKSHAFT/PISTON
12. PROPELLER/GEAR CASE/EXTENSION CASE
13. OIL PAN/ENGINE UNDER CASE/SWIVEL CASE
14. STEERING LINK ARM/REMOTE CONTROL BOX (REMOTE CONTROL TYPE ONLY)
15. THROTTLE CABLE RACKET/SHIFT LEVER/TILLER HANDLE (TILLER HANDLE TYPE
ONLY)
16. ELECTRICAL EQUIPMENT
17. OPERATION
18. WIRING DIAGRAM
BF30 SUPPLEMENT
Searches for
library of workshop manual for Honda marine bf30d4 lrtd year
2004 online eBook and manual, service repair manual online
store Honda outboard BF25D BF30D, 1978-1999 Honda 2130HP 4-stroke outboards, Honda marine outboard BF20A
BF25A BF25D BF30D pdf workshop repair manual-service
mamuals, 1997 Honda bf 25, Honda Outboard Motor, Honda
outboard BF20A BF25A BF30 cylinder workshop service repair