Sunteți pe pagina 1din 6

CONFIDENTIAL

UNIVERSITI KUALA LUMPUR


British Malaysian Institute
FINAL EXAMINATION
JULY 2010 SESSION
SUBJECT CODE

BEB11203

SUBJECT TITLE

ELECTRONICS I

LEVEL

DEGREE

TIME / DURATION

:
( 2 HOURS )

DATE

:
INSTRUCTIONS TO CANDIDATES

1. Please read the instructions given in the question paper CAREFULLY.


2. This question paper is printed on both sides of the paper.
3. This question paper consists of 5 questions.
4. Answer ALL in part A and 2 questions in part B
5. Please write your answers on the answer booklet provided.

THERE ARE 6 PAGES OF QUESTIONS, EXCLUDING THIS PAGE.

CONFIDENTIAL

Group
No of Student
Tutor

LO1TO1
24
MTM

LO1TO2
26
MTM

LO2TO1
24
MTM

LO2TO2
21
MTM

Subject Leader: MTM


Subject Leader
Signature
Date

LO3TO1
22
HMN

LO3TO2
11
HMN

Total
128
2

Date:
Verified by
Head of Section
Signature
Date

IEB
Signature
Date

CONFIDENTIAL
PART A
Question 1
a) An amplifier has an open loop voltage gain of 5000. Determine the feedback
factor required to reduce the voltage gain to 1000.
[4 marks]
b) The gain of an operational amplifier is 8000 before 8% of its output is applied
with negative feedback. Calculate the percentage of reduction in the feedback
gain of the op amp if the open circuit loop gain reduces by 50% due to aging.
[10 marks]
c) For a Wein Bridge Oscillator to oscillate at a frequency of 5 kHz;
i. Calculate the resistance, R for it positive feedback networks if the
capacitance value is 0.01F.
ii. Determine the value of Rf and Rin to ensure oscillation.

[4 marks]
[4 marks]

iii. Draw and label the circuit diagram of the designed oscillator.
[3 marks]
Question 2
a) List FIVE (5) characteristics of an ideal op amp.

[5 marks]

b) A differentialamplifier has an open loop voltage gain of 11000 and a common-mode


gain of 0.8. Determine the Common Mode Rejection Ratio (CMRR) in decibels.
[6 marks]
c) Draw and label the circuit diagram for:
i.

two pole low pass active filter and frequency response curve.

ii.

one pole high pass active filter and frequency response curve.
[4 marks]

CONFIDENTIAL
d) Design a Band Pass Filter with the following specifications:

cutoff frequencies, fOH = 200Hz, fOL= 5KHz

the voltage/pass band gain = 3

all capacitors = 0.01F.


[10
marks]

.
PART B
Question 1
The input signal to a 40dB amplifier is 30 W. The amplifier itself produces
additional 15 nW of internal noise. The input signal to noise ratio is 50 dB, calculate:
i)

The input noise power to the amplifier.

[5 marks]

ii)

The total output noise power.

[5 marks]

iii)

The output signal power.

[5 marks]

iv)

The output signal to noise ratio.

[5 marks]

v)

The noise factor of the amplifier.

[5 marks]

Question 2
a) The input impedance to a common emitter transistor amplifier is 3.6 k with =
100, ro = 60k, RL = 1.7 k. Determine:
i.

re

ii.

Ib when Vi = 30mV

iii.

Ic

iv.

Ai

v.

Av

[10 marks]

b) Referring to Figure 1, given Vcc = 16V, R B = 220k, RC= 5.6k, = 40, ro =


100k. Determine:

CONFIDENTIAL
a) re

[5 marks]

b) Input impedance, Zi

[2 marks]

c) Output impedance, Zo

[3 marks]

d) Voltage gain, Av

[3 marks]

e) Current gain, Ai.

[2 marks]

Figure 1
Question 3
Referring to Figure 2, given RB = 2k, RC = 30 , VCC = 20V, = 45. Determine:
i. The input power, Pin(dc) .

[5marks]

ii. The output power, Po(ac).

[5marks]

iii. The efficiency of the amplifier, .

[5marks]

iv. The power dissipated

[5marks]

v. The sketch of ac and dc load line.

[5marks]

CONFIDENTIAL

Figure 2

S-ar putea să vă placă și