1. Calculate the engineering stress in SI units on a 2.40 cm diameter rod which is subjected to a load of 1450 kg. 2. Calculate the engineering stress in SI units on a bar 12 cm long and having a cross section of 4.00 mm x 8.50 mm which is subjected to a load of 4500 kg. 3. A tensile specimen of cartridge brass sheet has a cross section of 0.500 in x 0.015 in and a gage length of 2.00 in. Calculate the engineering strain which occurred during a test if the distance between gage markings is 2.45 in. after the test. 4. A 0.505 in diameter rod of an aluminium alloy is pulled to failure in a tension test. If the final diameter of the rod at the fractured surface is 0.435 in, what is the percentage of reduction in area of the sample due to the test? 5. A 1.28 cm diameter aluminium alloy test bar is subjected to a load of 110,000 N. If the diameter of the bar is 1.24 cm at this load, determine (a) the engineering stress and strain, and (b) the true stress and strain Questions no. 6 & 7 are based on the following creep data were obtained for a titanium alloy at 50 ksi and 400C. Strain, in/in 0.010 x 10-2 0.030 x 10-2 0.050 x 10-2 0.075 x 10-2 0.090 x 10-2 0.11 x 10-2
Time, h 2 18 40 80 120 160
6. Plot the creep strain versus time
(hours) and determine the steady state creep rate for these test conditions.
NAB 2014
7. What is the minimum creep rate
with respect to the creep curve? 8. A traditional tensile tester can perform all of the following mechanical property tests except a. Hardness b. Shear strength c. Impact strength d. Bending modulus e. Yield strength f. Compressive yield strength 9. Which of the following is likely to scratch glass? a. A file b. A gold ring c. A screwdriver d. A ski pole e. Marble f. Hexagonal carbon 10. A stress is applied to an elastic material, held for 5 minutes, and then the applied stress is cut in half. What happens to the strain when the stress is reduced? Note: Should you need more sample questions for enhancing your knowledge and understanding, plenty of Materials Science references are available at the UTHMs library.