Documente Academic
Documente Profesional
Documente Cultură
Operators Manual
Heat Transfer Equipment
Page 2
TABLE OF CONTENTS
Page 3
CAP PRESS
PARTS LOCATION GUIDE
TEMPERATURE
ADJUSTMENT
KNOB
CAP
HOLD DOWN
LEVER
COUNTDOWN TIMER
FRONT VIEW
PRINT LIGHT
POWER
ON/OFF SWITCH
POWER
CORD
CIRCUIT
BREAKER
PRESSURE
ADJUSTMENT
KNOB
SIDE VIEW
REAR VIEW
Page 4
Operating Instructions
CAP PRESS
The Operating Instructions are designed with you in mind. Carefully read and follow the
step-by-step instructions for best results. If you experience any difficulty, carefully re-read
the instructions and try again.
Step 1
120 Volt
Your CAP PRESS requires a full 4.5 amp grounded circuit for 120 volt operation.
240 Volt
Your CAP PRESS requires a full 2.5 amp grounded circuit for 240 volt operation.
Extension Cords, if used, should be as short as possible and not less than
12 gauge. Heavy duty cords are recommended.
Circuits that have under 15 amps or other high demand equipment or
appliances (especially more than one heat seal machine) should not
be used.
NOTE:
If the supply cord is damaged, it must be replaced by the manufacturer
or its service agent or a similarly qualified person in order to avoid hazard.
CAUTION
FAILURE TO FOLLOW THESE INSTRUCTIONS WILL CAUSE:
1. Erratic controller functions.
2. Inaccurate displays and slow heat-up.
3. The circuit breaker to disengage.
Page 5
POWER
ON/OFF SWITCH
Step 3
Page 6
WARNING:
Page 7
PRINT LIGHT
Enlarged Graphic
for Detail
COUNTDOWN TIMER
Step 7 PRINT
Once your equipment has reached the designated temperature, position the
garment and application and proceed to press.
Lower and lock the heat platen into the press position. This procedure will
start the automatic timing process.
When the Print Light illuminates and constant alarm sounds, lift the heat platen
and proceed according to the application instructions.
Page 8
SW1
ON-OFF
SWITCH
22 GA
14 GA.
GREEN
WHITE
BLACK
CIRCUIT BREAKER
6 AMP
CB
IEC
INLET
L
WHITE
WHITE
TO POS.#2
TO POS.#5
HEATER LIGHT
(RIGHT)
GREEN
US 240V VERSION
POWER CORD
BLACK
CIRCUIT BREAKER
6 AMP
CB
CIRCUIT BREAKER
6 AMP
CB
BLACK
SW1
ON-OFF
SWITCH
1
2
3
4
5
6
7
1
2
3
4
5
6
7
TERMINAL
BLOCK
POWER LIGHT
(LEFT)
22 GA
PROXIMITY SWITCH
SW2
GREEN LIGHT
TIME
ADJUSTMENT
THERMOSTAT
BUZZER
TIMER
RELAY
TERMINAL STRIP
POWER LIGHT
(LEFT)
WHITE
GREEN
BLACK
14 GA
BLACK
14 GA
BLACK
14 GA
US 120V VERSION
POWER CORD
14 GA. 3 COND. SJT
CIRCUIT BREAKER
6 AMP
CB
SW1
HEATER LIGHT
(RIGHT)
ON-OFF SWITCH
PROXIMITY SWITCH
SW2
GREEN LIGHT
TIME
ADJUSTMENT
THERMOSTAT
BUZZER
TIMER
RELAY
CAP PRESS
ELECTRICAL SCHEMATIC
Page 9