0 evaluări0% au considerat acest document util (0 voturi)
125 vizualizări2 pagini
1. Install ET 2010A software, register the license key, and install ET 2011A.
2. Copy the "USB-VAG-COM ISO9141 USB drive" folder to the desktop and connect the hardware to the PC.
3. When prompted, manually install the USB driver by browsing to the folder and following the installation steps.
1. Install ET 2010A software, register the license key, and install ET 2011A.
2. Copy the "USB-VAG-COM ISO9141 USB drive" folder to the desktop and connect the hardware to the PC.
3. When prompted, manually install the USB driver by browsing to the folder and following the installation steps.
1. Install ET 2010A software, register the license key, and install ET 2011A.
2. Copy the "USB-VAG-COM ISO9141 USB drive" folder to the desktop and connect the hardware to the PC.
3. When prompted, manually install the USB driver by browsing to the folder and following the installation steps.
b.after ET 2010A installation finished,and then register license key
Double click keygen et2k9c_kg.exe
Choose JERD2129 Full service dealer ET
c. Get the license key and register on 2010A ET software.
2. and then install 2011A
3. install USB drive
1.copy USB-VAG-COM ISO9141 USB drive folder on your desk.
2.connect hardware to your PC.
a. After hardware connected, new hardware foundwill popup in the bottom right corner. b. Choose manual installation c. Browse to the folderUSB-VAG-COM ISO9141 on your desk. Follow the installation guide step by step until finish.
4. After all these installation finish,right clickmy
computerpropertyhardwaredevice managerCOM port
If ET drive is COM1,then choose the same communicate COM port(COM1)
in ET software configuaration.
After you correct setup communicate port .the hardware should connect well now.
Windows Operating System: Windows Operating System (OS) Installation, Basic Windows OS Operations, Disk Defragment, Disk Partitioning, Windows OS Upgrade, System Restore, and Disk Formatting