Sunteți pe pagina 1din 2

AB-4199

Specifications/Instructions

Transformer
Model ATY72Z01S1
General
Model ATY72Z01S1 is a compact isolation type transformer which steps down a line voltage of 100, 200 or
220 V AC to a low voltage of 24 V AC. This transformer
is used for 24 V AC power supply.

Features
The screwed terminals enable easy wiring.
The terminal cover enhances safety.

Specifications
Item
Model number
Type
Primary voltage
Secondary voltage
Power rating
Frequency
Mounting
Electrical connections
Ambient temperatue
Ambient humidity
Weight
Accessory
Requirement for
ordering

Specification
ATY72Z01S1
Isolation type
100 V AC / 200 V AC / 220 V AC
23 V AC (with rated load)
32 VA
50 Hz to 60 Hz
Bottom plate mounted with screws
Screw terminals
0 C to 60 C
10 %RH to 90 %RH
1.5 kg
None
Model number

4 mounting holes
on the bottom base

Terminal cover
(Clear acrylic plate)
6 M4 screw terminals

Installation
The Model ATY72Z01S1 transformer is installed with
screws and nuts on a panel or the like. Be sure to install the transformer in the ambient conditions specified
(in Specifications). The transformer can be installed
facing to any direction. To install the transformer on a
panel, fix it with M4 screws and nuts (not attached to this
product) Mounting holes are provided on the bottom
base. (See Fig. 1.)

Mounting
hole
Bottom base

Figure 1.

Dimensions (mm)

Wiring

Internal wiring connection


The internal wiring connection of the transformer is
shown in Fig. 2.
Remove the terminal cover for wiring to the terminals.
The terminals are M4 screw-threaded as shown in Fig. 1.
After the wiring connection, place the cover back.

WARNING

Disconnect from the power source before


performing any wiring to prevent electrical
shock.

23 V AC

220 V AC

CAUTION

200 V AC

To prevent electrical shock, use terminals


with insulation for the power supply wiring.
P

100 V AC

Primary
voltage
Figure 2.

Secondary
voltage

Internal wiring connection

Safety Instructions
Please read instructions carefully and use the product as specified in this manual.
for ready reference.

Be sure to keep this manual nearby

Usage Restrictions
This product is targeted for general air conditioning. Do not use this product in a situation where human life may be
affected. If this product is used in a clean room or a place where reliability or control accuracy is particularly required, please contact Yamatakes sales representatives. Yamatake Corporation will not bear any responsibility for
the results produced by the operators.
WARNING

DANGER: To prevent the risk of severe or fatal electrical shock, always disconnect power source (and
product power supply) before performing any wiring.
CAUTION

Installation must be performed by qualified personnel in accordance with all applicable safety standards.

This product must be operated within its operating ranges specified in this manual. Failure to comply will
cause equipment damages.

Installation must be carried out according to the operating conditions specified in this manual to prevent
equipment damages.

All wiring must comply with local codes of indoor wiring and electric installation rules.

Use crimp terminals with insulation for electric wires.

Specifications are subject to change without notice.

Building Systems Company


Tamachi Kiyota Building
4-3-4, Shibaura
Minato-ku, Tokyo 108-0023
JAPAN
http://www.yamatake.com
Rev. 2.5

May. 2005

(J: AI-4199 Rev. 2.4)

2
2

AB-4199

AB-4199 0.5H-H (W00)

S-ar putea să vă placă și