Documente Academic
Documente Profesional
Documente Cultură
2nd TEST
BDA 10703 TECHNICAL DWG & CAD
29/05/2014
(2:00 pm 3:30 pm)
Student Name
: ..
Matrix Number
: ..........................................................................................
Lecturer
: ..
Section
: ..
Total Marks
40
2. Every drawing includes a layer named ___________. This Layer cannot be deleted or renamed to
ensure that every drawing includes at least one layer.
A. 0
B. 1
C. Default
D. Object
3. You are running AutoCAD 2009 release. You can open a drawing created with a __________
release.
A. 2009 and previous
B. 2009 only
C. 2009 and earlier
D. All
4. The default polar angle is measured __________ from the zero angle position.
A. Clockwise
B. Counterclockwise
C. Clockwise and counterclockwise
D. Clockwise or Counterclockwise
Decimal
Engineering
Scientific
Fractional
I & II
I & III
I, II & III
All
7. As you create or move objects, you can use ___________ to restrict the cursor to the horizontal or
vertical directions relative to the user coordinate system (UCS).
A. Tab mode
B. Grid mode
C. Snap mode
D. Ortho mode
A.
B.
C.
D.
I.
2D Drafting & Annotation
II.
3D Modeling
III.
AutoCAD 2009
IV.
AutoCAD Classic
V.
I & II
I & III
I, II & III
I, II & IV
10. _______________ space is the area where you create your design.
A. Drawing
B. Paper
C. Model
D. Layout
-10 , 5
@ -10 , 5
15. Select object using an implied window (drag from left to right) for an Erase command.
Draw your window on the given Before Erase Command view
(2 Marks)
Command: _trim
Current settings: Projection=UCS, Edge=None
Select cutting edges ...
Select objects or <select all>: ______________
Select object to trim or shift-select to extend or
[Fence/Crossing/Project/Edge/eRase/Undo]: __________
(Show using arrow at Before Trim Command view)