Documente Academic
Documente Profesional
Documente Cultură
(i) Find the size of the blank and the number of draws required. (4)
(ii) Sketch (without dimensions) the sectional front view of punch and die
assembly and name the parts (6)
(iii)Sketch the punch and die separately and indicate their dimensions. (6)(JUNE 2007)
2. List any four types of jigs and fixture construction? State the advantages of each and
discuss the relative merits of each. (DEC 2008)
1. Design and draw two views of a jig/fixture for machining the boss of size. 50 on the
bearing bracket shown in Fig. 3.
(June 2007)
Or
Design and draw at least two views of a milling fixture for making a slot of 8 mm wide x
15 mm deep on a dome pin as shown in Fig. 4. Number the parts and prepare part list.
(June 2007)
Or
(i) Explain briefly mechanical and hydraulic presses.
(8)
(ii) Design a milling fixture to make a slot of O 70 x 10 x 10 mm as shown in Figure 3.
(8) (June 2006)