Documente Academic
Documente Profesional
Documente Cultură
Surveying :
Reconnaissance Survey, Chain Surveying : Conventional signs, Compass Surveying
: Bearing, Plane Table surveying : Methods, Levelling : Temporary and permanent
adjustments - Calculation of areas and volumes, Theodolite Surveying : Horizontal &
Vertical angles - Heights and distances, Tacheometric Suveying : Vertical and
normal staffing, Classification of errors, Principles of least squares, Photogrammetry
Electro Magnetic Distance Measurement.
Engineering Graphics :
Projection of Points - Lines and Plane Surfaces - Projection of Solids - Section of
Solids and Development of Surfaces - Isometric and Perspective Projections.
Soil Mechanics :
Nature of soil phase relationships soil classification soil water static pressure
effective stress principle; permeability seepage; Stress distribution in soil
Consolidation ( Terzhaghis one dimensional consolidation theory ); Compaction
shear strength of soil Mohr Coulomb theory Determination of shear strength by
different methods: slope stability analysis protection measures.
Foundation Engineering :
Site investigation scope and objectives drilling techniques depth and spacing of
boreholes Sampling Techniques penetration tests ( SPT and SCPT ) plate load
test selection of foundation; Foundation types shallow foundation bearing
capacity from field tests settlement of foundations allowable settlement Codal
provisions; design of foundations isolated, combined and raft foundations; Pile
foundations static and dynamic pile driving formulae ( Engineering News and Hiley
method ) Pile Groups capacity and settlement Codal provisions pile load test
negative friction on piles; Earth pressure theories earth pressure on retaining
walls stability analysis of retaining wall.
Engineering Mechanics :
Basics & Statics of Particles : Units and Dimensions - Vectorial representation of
forces and moments, Equilibrium of Rigid Bodies : Vectorial representation of
moments and couples - Properties of Surfaces and Solids : Determination of Areas
1
and Volumes - Parallel axis theorm and perdicular axis theorm, Dynamics of
particles : Velocity and accelerations - Newtons law.
Mechanics of Fluids :
Definitions and Fluid Properties : Fluid and Fluid Mechanics Dimensions and units,
Fluid statistics and Kinematics : Forces on plane and curved surfaces, Fluid
Kinematics : Classifications of flow, Fluid Dynamics : Laminar flow through pipes and
between plates Turbulent flow, Flow through Pipes : Major and minor losses of flow
in pipes.
Strength of Materials :
Energy Principles : Application of energy theorms for computing deflections in beams
and trusses, Indeterminate Beams : Propped cantilever and fixed beams, Uniformly
distributed load - triangular load - analysis of continuous beams - slope and
deflections in continuous beams, Columns : Eccentrically loaded short columns Columns of unsymmetrical sections, Stress and Strain : theories of failure - load
carrying capacity and design of members, Bending of beams : unsymmetrical
bending of beams of symmetrical and unsymmetrical sections.
foundation, box culvert Design of Staircase Design of RCC Beams and Columns
- Design of RCC Slabs ( one way & two way ) Design of Concrete walls Ductile
Detailing of Concrete Structures - Design of Sump & Water tank, Prefabricated
structures : Design of cross section based on efficiency of materials used problems
in design because of joinery flexibility allowance for deformation.
Design of Masonry Structures :
Introduction, Classification of walls, Lateral supports and stability, effective height of
wall and columns, effective length of walls, design loads, load dispersion,
permissible stresses, design of axially loaded and eccentrically loaded brick walls
Executive Engineer
Structural and Quality Control Cell