Documente Academic
Documente Profesional
Documente Cultură
1.
2.
3.
4.
5.
6.
7.
8.
9.
The component of the torque converter that drives the oil is the
a) turbine
b) impeller
c) freewheel
d) stator
In typical drive system, the clutch is best located
a) before the engine
b) on the road wheels
c) between the engine and gear box
d) between the differential and wheels
As a general rule, if facings on the friction plate are worn down to the
rivet head,
a) the rivets should be replaced
b) the friction plate should be replaced
c) the clutch should be replaced
d) the linkage should be adjusted
The clutch pressure plate is mounted on the
a) flywheel
b) clutch cover
c) friction plate
d) crankshaft
A warped pressure plate should be
a)
b)
c)
d)
retempered
straightened
replaced
refaced
When the clutch is engaged, the spring pressure clamps the friction
plate between the pressure plate and
a)flywheel
b)differential
c)reaction plate
d)clutch pedal
The three forward speed and reverse gear transmission consists of three
shafts and
a)three gears
b)five gears
c)eight gears
d)ten gears
Synchromesh devices in transmission synchronise the gears about to be
a)meshed
b)demeshed
c)stopped
2
In gear transmission, the counter shaft drive is meshed with the gear on
the
a)output shaft
b)main shaft
c)clutch shaft
Two meshing gears have 4:1 gear ratio. If the smaller gear has 12 teeth,
the larger will have
a)12 teeth
b)24 teeth
c)36 teeth
d)48 teeth
The central gear of an epicyclic gear box is called
a)ring gear
b)planet gear
c)sun gear
d)internal gear
Which type of clutch does not require clutch pedal?
a. Single plate
b. Multi plate
c. Centrifugal
d. Cone
d)driving shafts
The number of planetary gear sets in a hydrodynamic transmission
system is
a)two
b)three
c)five
d)five
When coming out of over drive, the over drive electric control
momentarily
a)declutches the engine
b)interrupts the ignition system action
c)demeshes the sun gear
In order for power to flow through the fluid coupling from the engine
to the car wheels, the driving member must be turning
a)slower than driven member
b) at same speed as driven member
c)Faster than driven member
In the overdrive, there is an arrangement whereby it is possible to lock
stationary the
a)ring gear
b)sun gear
c)planet pinion cage
The coil spring clutch may use from
a)two to six springs
b)three to nine springs
c)four to eight springs
d)ten to twelve springs
If the differential noise is present only when the car is rounding a curve
the trouble would be due to
a)heavy heel contact on gear teeth
b)heavy toe contact on gear teeth
c)Binding in differential case
To correct heavy flank contact on the ring gear teeth
a)move the drive pinion in
b)move the drive pinion out
c)move the ring gear out
d)adjust back lash as necessary
The ring gear is adjusted in the differential by the use of
a)selective washers of proper thickness
b)bearing adjuster
c)adjusting screws
The axle bevel gears in the differential mesh with the