Documente Academic
Documente Profesional
Documente Cultură
S529-OP31603
Revision A
CDM APPROVED
PRODUCTION RELEASE
Revision A
Prepared by
PREPARED BY:
APPROVED BY:
C. Chen
Changlin Chen, TCR Engineering
APPROVED BY:
R. Macheske
Rick Macheske, Chief Engineer
APPROVED BY:
A. Lewis
Al Lewis, Program Office
APPROVED BY:
W. Cook
William Cook, Flight Assurance Manager
RELEASED BY:
WARNING: INFORMATION SUBJECT TO U.S. EXPORT CONTROL LAWS. The attached documents contain
technical data within the definition of the International Traffic in Arms Regulations, and are subject to export control
laws of the U.S. Government. They are approved for transfer only tothe signatories and their employees who are
nationals of the countries listed on TAA 2273-08, and authorized by the U.S. Department of State.
Retransfer of this data by any means to any other end user or for any
other end use, whether in the U.S. or abroad,
without the written approval of the U.S. Department of State isprohibited. 22 CFR 125.4(b)(2) applicable.
Orbital Proprietary
4-TELKOM-2 On-Orbit-0002
S529-OP31603
Revision A
REVISION HISTORY
REV
DATE
04/23/04
09/21/04
SECTION(s)
AFFECTED
All
All
This document is used for basic test and operational maintenance of the ground
station and spacecraft. It is used to determine the operability of subsystems
of the ground station and spacecraft during normal operations periodically
through the life cycle.
Orbital Proprietary
Page ii
4-TELKOM-2 On-Orbit-0002
S529-OP31603
Revision A
Table of Contents
1.
PURPOSE .....................................................................................................................1
2.
REFERENCES ..............................................................................................................1
3.
DEFINITIONS .................................................................................................................1
4.
ACRONYMS/ABBREVIATIONS .....................................................................................1
5.
5.1
5.1.1
5.1.2
5.2
5.2.1
REQUIREMENTS ..........................................................................................................1
General Requirements ................................................................................................1
Scope .............................................................................................................................1
Constraints .....................................................................................................................2
Process..........................................................................................................................2
Flow Charts ....................................................................................................................3
List of Figures
Figure 1 Overall Flowchart..............................................................................................................3
Orbital Proprietary
Page iii
4-TELKOM-2 On-Orbit-0002
S529-OP31603
Revision A
1.
PURPOSE
The objective of this Telemetry Transmitter (TTX) Failure Recovery Procedure is to outline the
Telemetry Transmitter switchover. The procedure will be executed per Mission Director
direction.
2.
REFERENCES
3.
DEFINITIONS
N/A
4.
ACRONYMS/ABBREVIATIONS
BTX
C&DH
CMD
CRX
CTR
DL
FD&C
PROC
RTM
TTX
SOH
STOL
5.
5.1
5.1.1
Beacon Transmitter
Command & Data Handling
Command
Command Receiver
Command, Telemetry, and Ranging
Downlink
Fault Detection and Correction
Procedure
Redundant Telemetry Module
Telemetry Transmitter
State of Health
Satellite Test and Operations Language
REQUIREMENTS
General Requirements
Scope
The purpose of this procedure is to define the recovery from a failure with the Telemetry
Transmitter or a switch from one Telemetry Transmitter to the other. The spacecraft utilizes two
telemetry transmitters that provide the telemetry link. If a hard failure occurs with the primary
telemetry transmitter, no telemetry will be received. However, command functions should still be
available, allowing a commanded switchover to the redundant TTX.
U.S. Department of State, Approved TAA #2 273-08
Orbital Proprietary
Page 1
4-TELKOM-2 On-Orbit-0002
S529-OP31603
Revision A
5.1.2
Constraints
The mission director must approve the use of this procedure. If no telemetry is being received,
execute the Spacecraft Loss of Uplink and Downlink procedure prior to executing this procedure.
This procedure is based on a nominal entrance configuration; that is, the active BBE routing
telemetry to the active TTX.
5.2
Process
Orbital Proprietary
Page 2
4-TELKOM-2 On-Orbit-0002
S529-OP31603
Revision A
5.2.1
Flow Charts
Transmitter failure or
requirement to swap
Command ON the
alternate transmitter in
High Power mode
Execute State-of-Health
Orbital Proprietary
Page 3
S529-OP31603
Revision A
Operator
Step
Description
Controller
Entrance Criteria
Controller
Constraints
CV OFF
Controller
DECODER SC_CLR
CMD TCR_TTXz_OFF
Controller
Where z = 1 or 2
Controller
CMD TCR_TLM_ROUTE_BBEx_TTXy_SET
Where x = 1 or 2 for active BBE
Where y = 1 or 2 for active TTX
Controller
CMD TCR_TTXy_HI_PWR_ON
Where y = 1 or 2 for active TTX
If Telemetry is not being received, stop here and consult engineering immediately.
Controller
TTX Failover
TCR_TTX1_EPC_VOLTAGE =
TCR_TTX2_EPC_VOLTAGE =
TCR_TTX1_ON_STATUS =
TCR_TTX2_ON_STATUS =
TCR_TTX1_PWR_MODE_STATUS =
TCR_TTX2_PWR_MODE_STATUS =
Orbital Proprietary
Page 4
Record
S529-OP31603
Revision A
Operator
Step
Controller
Controller
10
Controller
11
Description
TCR_BBE1_TTX1_TLM_ROUTE =
TCR_BBE1_TTX2_TLM_ROUTE =
TCR_BBE2_TTX1_TLM_ROUTE =
TCR_BBE2_TTX2_TLM_ROUTE =
CV ON
CMD TCR_TTXy_LO_PWR_ON
Controller
TTX Failover
12
Orbital Proprietary
Page 5
Record