Documente Academic
Documente Profesional
Documente Cultură
Satellite Finder
Indoor Connection
Whats Included
Connect to
Receiver
Existing Coaxial Cable
TO RCVR
Terminal
FROM LNBF
Terminal
Specications
22KHz Indicator
Caution: Be sure to unplug the receiver when connecting and disconnecting the coaxial
cable between the receiver and LNBF.
If your receiver displays the signal strength on the TV screen, use an indoor connection.
1. Unplug your receiver from its power source.
2. Disconnect the existing coaxial cable from receiver then connect it to the FROM LNBF
terminal on the satellite nder.
3. Connect one end of the supplied coaxial cable to your receiver and the other end to the
TO RCVR terminal on the satellite nder. Plug in the receiver and turn it on.
4. Roughly align the dish by setting the azimuth and elevation angles to the settings
indicated by your receiver.
5. Rotate LEVEL ADJ. until the satellite nders strength reads approximately 5.
6. Slightly adjust the dish until the satellite nders strength reading increases. If the
strength reading approaches full scale, rotate LEVEL ADJ. to adjust it back to
approximately 5.
7. Adjust the dish until you get the highest possible reading.
Note
9. Turn off the receiver and unplug it from the power source.
10. Disconnect the existing coaxial cable from FROM LNBF terminal on the satellite nder,
and then connect it to the receiver.
Outdoor Connection
Connect to
Receiver
Male-to-Male
F Cable Coupler
(Not Supplied)
Satellite Finder
Coaxial Cable
Users Guide
Limited Warranty
Caution: Be sure to unplug the receiver when connecting and disconnecting the coaxial
cable between the receiver and LNBF.
If your receiver cannot display the signal strength on the TV screen, an outdoor
connection is necessary.
1. Unplug your receiver from its power source.
2. Disconnect the existing coaxial cable from LNBF then connect it to TO RCVR terminal.
3. Use a male-to-male F cable coupler (not supplied, available at your local RadioShack
store or at www.radioshack.com) to connect the satellite nder to the LNBF. Then plug in
the receiver, and turn it on.
4. Follow Steps 4 to 9 under Indoor Connection to make adjustments.
5. Disconnect the coaxial cable from TO RCVR terminal on the satellite nder, and then
connect it to the LNBF.
6. Restore power to the receiver.
2008. RadioShack Corporation.
All rights reserved. RadioShack and RadioShack.com are trademarks used by RadioShack Corporation.
04/04
www.radioshack.com
SENS. ADJUST
04A08
16-594
Printed in China