Documente Academic
Documente Profesional
Documente Cultură
After launching of new ITC cards of OCB IN in south India, some of the problems
observed at different sites are explained with suggestions to improve OCB IN functioning.
OCB SSP to SRP call routing follows the network scenario as given below. At some
stations, Lev-2 OCB TAX is configured as SSP.
A B C D E F
Local OCB SSP Lev-2 TAX Lev-1 TAX Lev-1 TAX SRP
Page 1 of 2
5 From D- TAX (e.g. Due to routing of more calls Instead of specifying 11 digit
Coimbatore), 08025 (including SRP calls) number as SRP IND, a 4 or 5
codes were routed to through BG Central TAX, digits spare code (e.g 1552) can
Bangalore WMS BHCA of Central TAX has be specified as SRP IND. This
TAX whereas SRP increased considerably code can be routed as it is upto
was connected to BG resulting in heavy call SRP connected TAX. Or, 1552
Central TAX. Since rejection. can be routed upto D-TAX where
11 digits number was it can be routed to SRP-TAX
given as SRP-IND, to with DIS=CN in the ACH to
avoid splitting of convert to actual SRP IND. This
codes upto 11 digits, arrangement will avoid splitting
all 08025 codes of codes at B/C/D. Otherwise, to
including SRP IND limit splitting of codes to 6/7
were routed to digits, information about upto
Bangalore Central which level analysis is required
TAX. (e.g. 0802538) can also be
intimated.
6 C/D is AXE TAX ; IN call is not successful With PTX not NTSR at E,
PTX=NTSR at E- Answer message is received by
TAX AXE TAX and IN call is
successful.
7 Call from SSP to For every call to SRP, there This is due to not sending calling
SRP, routed via are two sets of C7 messages line id & category from SSP.
EWSD TAX with Headers 03 & 04. These additional 4 messages per
(For calls through OCB call is increasing load on PUPEs.
TAXs, one set of 03 & 04
messages.)
8 PTX=NTSR at SSP All SRP calls are treated as With PTX=0 at SSP, SRP calls
successful (with CE=0 in are treated as effective only
OFCLA) when Answer message is
received from SRP.
9 OCB TAX is SSP; All 1602 calls from OCB At TAX SSP, 1602425 was
1602425 was routed Local failed suddenly. After analysed in TRAD 6. When
from OCB Local to routing through ACH with ARCMO was done to modify
TAX thro common FITX, calls were getting OK NTRA06 & TRCHBL, OCB SSP
trunk group with since charge message was TAX started sending Charge
PTX=0; calls OK. received from SSP TAX. message.
Conclusion:
a) For SRP-IND, PTX=0 at SSP and normal PTX (except NTSR) at all TAXs is
found better.
b) Spare code as SPR-IND and routing as it is upto Lev-1 TAX helps to route to
correct TAX without splitting of INDs at intermediate TAXs.
(A.K.KALAIARASU)
DE, RMC, Chennai
Page 2 of 2