Documente Academic
Documente Profesional
Documente Cultură
Connector
UPL-DM-12T Tools/Materials HCG-FRAMESET-1/2
UPL-DF-12T
HCG-CC
TW1412 TQ-114-F18
UPL-NM-12T Torque Wrench Torque Wrench
N-Male Din-Male
UPL-NF-12T
UPL-DRA-12T 12 Adjustable TQ-78-F8
Torque Wrench
Alcohol Wipe
Wrench
Mini Din-Male
UPL-NRA-12T
UPL-MDM-12T
RDCUTTER-S Gator Center SP-PLV
Conductor Cleaner
Straighten cable. Using Attach prep/strip tool to drill. If dielectric disc is located at Slide blue marking guide over
RDCUTTER-S, apply even Be sure to use SP-12PL tool. cable end remove with pliers. cable until it bottoms on the
pressure while rotating tool Prepping cable on the spool This will allow for cable mark- first dielectric ring. Mark cable
around cable to cut off cable is recommended for lengths ing in the next step. with a line at end of marking
squarely. under 6. guide.
Actuate drill to remove jacket No coring of dielectric is nec- Use center conductor Hold prepped cable end at
and expose the center conduc- essary. Hold prepped cable cleaner (Gator tool) to a downward angle, tapping
tor until the prep tool reaches end at a downward angle, remove any remaining the cable while vacuuming a
the mark made on the jacket, tapping the cable while dielectric material on center second time.
and the final cut is in the valley. vacuuming. conductor.
Align outer conductor as Use alcohol wipe to clean Push connector onto cable
shown with groove on cap. inner and outer conductors until it reaches the first
Make a second installation thoroughly. alignment mark (until 2
mark on cable jacket in line clicks are heard/felt).
with end of connector.
Select proper insert for con- Make sure connector is fully When fully compressed,
nector. Pull/push back the seated. Press the green ON connector will move away
Insert A Insert B Insert C insert to allow connector/ button on HCG tool. Then, from alignment mark.
Refer to chart to select proper cable to lay flat in frame. hold trigger until the connec-
insert for connector type. tor closes completely. Do not
push or pull on tool or cable
during compression.
Mobile-enabled:
JMAqr.com
When using the torque wrench,
make sure the mating connector is
supported by an adjustable wrench.
Compare to picture to determine if
correct cable prep was performed.
Scan for install video. (For reference only)