The images below show the correct way to clean an item using cleanroom wipes and solvent.
1. Take a polyester cleanroom
wipe and hold it by its edges as 2. Fold the wiper in half shown above
4. Apply cleaning detergent or
solvent to the wiper. Ensure that 3. Fold the wiper in half again as wiper and wash bottle do not shown come into contact with each other. This will minimise cross contamination of solvent. 6. Wipe across the surface of the item to be cleaned in a positive 5. Start the cleaning action by motion. At the end of the wipe, bringing down wiper onto lift the wiper away from the surface to be cleaned with the surface as shown with the back front of the wiper held upward end of the hand lifting off the as shown and the whole part of surface last. Turn the wiper the hand pressing down firmly in around so that a "clean" face is a parallel orientation to the facing the item to be cleaned wiper. and wipe accros the next section of un-wiped surface as was done previously.
7. Once both sides of wiper has
been used turn the wiper over so 8. Follow the same procedure as that both the "dirty" sides face above points wiping across each other and clean the next surface in a positive manner. bit of un-cleaned surface as per above instructions. 10. Once you have done wiping twice each side, replace wiper with a new one and follow the procedures as described above. The important thing to remember is that the wiping action must be done in straight lines across surface to be cleaned and not in circular motions. At the end of each wipe lift wiper off the surface completely and only wipe across surface twice with each side of wiper (8 wipe actions per wiper) 9. Wipe across surface as per instructions above and lift wiper 11. While wiping a surface try to cleanly away from surface at end view the surface at a 5 to 10 of wipe. Turn the wiper around angle with a dark back ground if so that the clean face is now it is possible. If you see any facing the surface to be cleaned particles on the surface then and redo the actions specified repeat above procedure. above.