Documente Academic
Documente Profesional
Documente Cultură
The RP620 series of drill rod features thread profiles in their truest
form for the best fit possible instead of accepting common industry To get the maximum performance
practices used on the finished machined threads, Sandvik has introduced and life from your drill rod, it is
a proprietary thread compound to address the issue of galling. Sandviks recommended that you do not mix
high quality standards and level of excellence in manufacturing has Sandvik rods with rods or adapter subs
enabled us to provide wireline drill rods with optimal performance from other manufacturers although
through superior: the materials, process and thread
design may appear similar, dimensions
material specification and tolerances may vary between
heat treatment
machining
manufacturers! !
Contact your Sandvik representative today.
Sandvik recommends using only Sandvik quality manufactured parts. Sandvik does not guarantee the consistency or quality of other manufacturers.
CORING AFTERMARKET RP600 SERIES WIRELINE DRILL RODS
The RP623 series of drill rod features a robust, modified square profile thread on the
box and pin ends commonly referred to in the industry as T.
RP623 SERIES
BB00000053 Drill Rod, NT 1,5 m 60,3 2.38 69,9 2.75 11,60 25.46
BT = 1800 m (5900 ft) depth
BB00000054 Drill Rod, NT 3,0 m 60,3 2.38 69,9 2.75 23,10 50.93
BB00000055 Drill Rod, HT 1,5 m 77,8 3.06 88,9 3.50 17,10 37.70
NT = 2000 m (6500 ft) depth
BB00000056 Drill Rod, HT 3,0 m 77,8 3.06 88,9 3.50 34,20 75.40
NOTE: 0.6 m rod lengths are available on request, contact your Sandvik representative.
!
NOTE: To get the maximum performance and life from your drill rod, it is
recommended that you do not mix Sandvik rods with adapter subs from other
manufacturers, please refer to the adapter sub pages for complete selection of
Sandvik adapter subs. Sandviks anti-galling joint compound MUST be used on the initial
make and break of every rod DO NOT REMOVE.