Documente Academic
Documente Profesional
Documente Cultură
1 INTRODUCTION...................................................................................................................................................2
2 TO FIND THE BOOTROM VERSION OF THE C264 CPU3 BOARD.................................................................4
2.1 USING THE SERIAL INTERFACE IN FRONT PANEL..............................................................................................4
2.2 USING THE CAT..............................................................................................................................................7
2.3 LABEL ON THE CPU.......................................................................................................................................9
3 PROCEDURE........................................................................................................................................................10
3.1 FOR CPU BOARDS COMING DIRECTLY FROM PRODUCTION............................................................................10
3.2 FOR CPU BOARDS ALREADY USED WITH A BOOTPROM VERSION UPPER THAN B1.02:..................................12
3.3 STOP C264 APPLICATION...............................................................................................................................12
3.4 CHANGE BOOT PARAMETERS.........................................................................................................................13
3.5 UPDATE BOOTROM........................................................................................................................................14
3.6 ERASE AND FORMAT FLASH........................................................................................................................15
3.7 BOOTINSTALL...............................................................................................................................................17
3.8 SET COMPUTER PARAMETERS.......................................................................................................................18
3.9 RESTART COMPUTER.....................................................................................................................................18
1 INTRODUCTION
To use C264 release B7.21, and above, for PACiS 4.8.1 its
mandatory to update the C264 computer "bootrom . A new flash
memory partition is done to create a specific zones for: waveforms
and cyber security data.
This guide details the installation procedure.
Compatibility matrix
It can be indicated after typing the command v at the line beginning by BSP version
The bootrom version is indicated on the first text sent to the terminal.
It is indicated on the line beginning by BSP version.
NOTES: once the Bootprom boot mode has been selected every time the computer is
rebooted or powered-up it will be stopped in this mode.
The mode must be manually set to Flash boot to get back a normal mode.
NOTES: once the bootrom version has been updated to a new version its mandatory to
update also manually the label (think to next user ).
3 PROCEDURE
This procedure applies for CPU boards coming directly from production or for CPU
boards already used on a project (Repair service or version update).
In this document CPU boards coming directly from production are called production
boards and boards already used on a project are called project boards.
Some phases of the procedure may contain messages or actions that depend on
initial state: production or project.
As the computer it is normally in maintenance mode you directly pass to step 3.4.
Use the version of CAT that includes the right version of the bootrom.
Use at least a B7.21 version of C264 (CAT A1.14).
- If the CPUs current version is already compatible with Perma (PACiS versions
V4.8 or upper), connect to the computer as System Administrator.
- Else (PACiS versions V4.7 or lower), just connect to the computer (no user is
asked)
- Click on Stop
- Click on Yes, stop now
- When finished, reboot computer (click Reboot, and Yes, reboot now).
3.7 BootInstall
- After reboot complete, connect to the computer.
- Verify that the computer is in Boot Mode
- Click on Load application software
- Select the path of the Computer software. For a default installation the directory
may be "C:\Program Files\PACiS\Computer\C264_cpu3"
- Click on Load this application software and Yes
In case of error, fill out the field IP and subnet mask N2 with a correct value.
Production boards:
This value IP2 address is lost after the computer restart.