Documente Academic
Documente Profesional
Documente Cultură
By,
Jaydip Mondal Roll: 14/ME/45
Madhuja Layek Roll: 14/ME/49
Harsa Mitra Roll: 14/ME/39
Indraneel Paul Roll: 14/ME/43
Procedure:
1. Making of BODY:
Open Catia V5 > Start > Mechanical Design > Part Design > Part1
Choose axis > Draw a 3mm section shown > Shaft it > Draw outline scetches as per proper
dimension > Shaft it again > Fillet the selected edge > Save it.
2. Making of NUT:
Open Catia V5 > Start > Mechanical Design > Part Design > Part2
Choose axis > Draw outline with proper dimension > Pad it > Make hole > Inside it create thread
> Save it.
3. Making of SCREW:
Open Catia V5 > Start > Mechanical Design > Part Design > Part5
4. Making of CAP:
Open Catia V5 > Start > Mechanical Design > Part Design > Part4
5. Making of WASER:
Open Catia V5 > Start > Mechanical Design > Part Design > Part5
Select axis > Draw the outline with proper dimension > Pad it > Do the knurling
operation > Save it.
Assembly Design:
Start > Mechanical Design > Assembly Design
Double click on Product > Insert > Insert existing part with positioning > Add
Part1:Body > Follow same process > Add Part2:Nut > Coincide these two with
respect to axis > Refreash > Surface to surface coincide > Refresh > Double click
on Product > Insert > Insert existing part with positioning > Add Part3:Screw >
Coincide it with the provided hole in previous assembly > Axix to axis coincide >
Refresh > Surface to surface maching > Refresh > Double click on Product > Insert
> Insert existing part with positioning > Add Part4:Cap > Axis coincide > Refresh
> Surface to surface contact > Refresh > Again follow same process and insert
Prtt5:Waser > coincide it with cap and merge it > Refresh > Follow same process >
Insert Part6:Locking Screw > Coincide it with waser > Refresh > Follow same
process > Insert Part7:Tommy Bar > Coincide it with the hole provided in main
screw > Adjust it in x-axis > Refresh.
Drafting :