Documente Academic
Documente Profesional
Documente Cultură
This menu gathers the functions of simultaneous opening of a DTM .ic2 or .geo and its
associated image .ic1 or img.
The Image file is superimposed to the altimetric file and may have a greater resolution than
the corresponding DTM by a whole multiple of the scale.
These cartographic files can be opened on the disk, or can be directly loaded in memory.
Therefore, the altimetric file can be loaded in mode disk without its associated image : click
over the Cancel button when the system asks you to designate the .ic1 or .img file to open.
When cartographic files are opened on the disk, it is generally preferable to work on small
zones. The tool allows to cut files to generate files with more easily exploitable sizes.
In mode Open Disk Session, it is not possible to work on too small zones ("Illegal File
Format" message).
When cartographic files are opened on the disk, all the modifications are directly made over
the file, exept when the work is done on a part of the file previously cutted via the tool .
In this case only, the tool is available in mode Open Disk Session. If the work is directly
made on the whole file, the user must be very vigilant.
5/ Click over the Remove Layer tool to open the .ic2 or .geo file :
ICS Map Server5.x - Menus - Section 3 page 30
Status Bar
The status bar lists the current process and indicates information regarding the position of
the cursor on the file.
Current process
The information concerning the process is displayed in the status bar as follow :
50 percent completed - Esc to stop Simulation
NB : If you press the CTRL key + T , you will be able to open another image at the same time
and to pass from one to another.
Therefore, the altimetric file can be loaded in mode memory without its associated image :
click over the Cancel button when the system asks you to designate the .ic1 or .img file to
open.
When the cartographic files are loaded into memory, it is preferable to check that their size is
not higher than the computer capacity.
In mode Open Memory Session, it is not possible to work with too big zones.
When the cartographic files are loaded into memory, the operations done are saved via the
Save tool .
Procedures
5/ Click over the Remove Layer tool to open the .ic2 or .geo file :
Status Bar
The status bar lists the current process and indicates information regarding the position of
the cursor on the file.
Current process
The information concerning the process is displayed in the status bar as follow :
50 percent completed - Esc to stop Simulation
NB : If you press the CTRL key + T , you will be able to open another image at the same time
and to pass from one to another.