Documente Academic
Documente Profesional
Documente Cultură
4. Figure indicate
(a) Out put is energized when all the inputs energized in AND gate
(b) Output is energized when more than one input energized in OR gate
(d) None
7. Convert 27 in binary no
10. Output is zero when one input is 1 or both inputs are 1, the gate is
15. (0.625)10=( )2
(c) 1011.11
(c) NAND or OR
(i) 101 (ii) 111 (iii) 100 (iv) None of the above
23. The binary number 11101 indicates the following decimal numbers
(i) 28 (ii) 29
(iii) 30 (iv) 27
Y=A B C + A B C D + A B C D E + A B + A B C D E + A the
output is
2. Y= (5, 15, 23, 29, 37, 47, 55, 61) + X (7, 13, 21, 31, 39,
45, 53, 63)
a) OV b) Ground
c) Either a) or b) d) +VCC
a) Vo=AdVd[1+(1/CMRR) Vc/Vd]
b) Vo=AcVc[1+(1/CMRR) Vd/Vc]
c) Vo=AdVd[1+CMRR . Vc/Vd]
d) Vo=AdVd[1+(1/CMRR) Vd/Vc]
a) S=R b) R=S
d) T= clock period
a) High b) Low
a) In series b) In parallel
a) TTL
b) ECL
c) DTL
d) RTL
a) Y = A . B + A B b) Y = A . B + A B
c) Y = A . B + A B d) Y = A . B + A B
a) Clamper circuit
b) Clipper circuit
c) Zener diode
d) LED
21. One nibble is equal to
a) 010110.11 b) 1110011.11
c) 1011011.11 d) 1011010.1
B Y
C
a) Y=(A.B).C
b) Y=A.B.C
c) Y=(A.B).C
d) Y=A.(B.C)
a) 1000 bits
b) 1024 bits
c) 2048 bits
d) 108 bits
28. The output is high only when both input are different. The device is
a) Current driven
b) Voltage driven
c) Power driven
d) None
a) Hartlay b) Collpit
c) Crystal d) Clapp
COMPUTER
4. Algorithm
(d) None
5. DOS is a
(d) none
(d) None
(a) hard disk (b) key board (c) CD-ROM (d) Monitor
(diagrams)
(a) Simple
(b) Complex
(d) None
(a) RAM (b) ROM (c) Floppy disc (d) Hard disc
26 Computer consist :-
(a) ALU, CU, CPU (b) Out put device, CPU, Input device
(i) VLSI (ii) ULSI (iii) LSI (iv) None of the above
44. Algorithm is
46. Which of the following best describes a computer based information system
a) Addition b) Multiplication
5. A computer basically
a) Processes data
7. Assembler is
d) None of these
a) 2 b) 8 c) 10 d) 16
a) Mouse b) Monitor
17. Which of the following memories has got equal access time for
all locations of the memory limit?
a) Read Only Memory (ROM)
b) Programmable Read Only Memory (PROM)
c) Random Access Memory (RAM)
d) Erasable ROM
(a) simple
(b) complex
(d) none
a. Magnetic Disk
b. Ferrite Core
c. Semi Conductor ROM
d. Semi Conductor RAM
(a) I/O (b) Processor (c) CPU (d) None of the above
a. Volatile
b. Non-Volatile
c. Volatile as well as Non-Volatile
d. Neither Volatile nor Non-Volatile
37. MODEM is a
a) Code changing system
b) Programme conversion system
c) Modulator Demodulator system
d) Demodulator modulator system
a) Data bus
b) Data bus & Address bus
c) Control bus
d) Data bus, Control bus & Address bus
(a) Hardware
(b) Memory
(c) Microprocessor
(d) Peripheral device
41. Which of the following storage has greatest capacity with less cost per bit?
a) Semi conductor memory
b) Magnetic tape
c) Magnetic drum
d) None of these
45. The access time for semi conductor memories is of the order
of
a) A few milliseconds
b) A few microseconds
c) A few nanoseconds
d) A few seconds
True
False
47. The memory unit that communicates directly with the CPU is
called
a) Main memory
b) Auxiliary memory
c) Cache memory
d) EPROM
a) Software used
b) Frequency and signal received
c) Both Software and Hardware
d) Only Hardware
A) 1 & 2
B) 2 & 3
C) 1 & 3
D) 2 & 4
a) PASCAL
b) BASIC
c) FORTRAN
d) COBOL
54. In third generation computer
b) Microprocessor is used
a) Bytes
b) Mega bite
c) Mill
d) Byles
d) None
a) Decimal language
b) Binary language
c) Hexadecimal language
a) In sequence
d) None of them
a) An infected disk
b) Links to a network
a) RAM
b) ROM
c) PROM
d) EPROM