Documente Academic
Documente Profesional
Documente Cultură
This is Mini LED roulette game circuit using Digital IC, so simple and easy to builds, using IC-4017
to drive LED1-LED10, IC-4011 is oscillator, IC-4013
When the switch S1 the output at pin 1 of the IC1a the voltage is high, The oscillator circuit
output IC2b, IC2c work. Clock pulse generator fed to IC3, a voltage high output to the output
pins 3, 11, and pin 12 of the IC3, the LED1-LED10 light chase sequence. Section LED11 show high
low point. The output of pin 3, 2, 4, 7, 10, of IC3 represented by high points, Output pins 1, 5, 6,
9, 11 instead of the IC3 with the low points. The jackpot for the LED12.The IC1b, IC2a and IC2d as
controls.
Resistor R2 and capacitor C1 determine the period of the output high output from pin 1 of the
IC1a. The capacitor C1 through R2. When you press the switch and the voltage drop across C1 will
gradually increase until the maximum level. It will reset the flip flop IC1a become the output at
pin 1 is low. And the oscillator output circuit to stop working, but there are some LED lights are
pending, it may be that we end up being the LED.
So do not worry, it will switch a few times. Because, given a time period that the R2 and C1. The
devices are required to keep a 6-volt power supply. If changed is 9 volts, must try for security
reasons.
This project is not used many components so can assemble on the universal PCB board. as Figure
2 The wiring looks out carefully for the polarity of the electrolytic capacitors and Diodes and LED
and Pin of the ICs correctly.
Components list
Resistors size W +5%
R1___________10K
R2___________1M
R3___________470K
R4___________330K
Capacitors
C1___________2.2uF 16V___Electrolytic
C2___________0.1uF 50V____Polyester
Semiconductor
D1___________1N4001___1A 50V Diode
LED1-LED12_____LED___Many colors