Documente Academic
Documente Profesional
Documente Cultură
Main Symptom throttle switch must be used to set up an alternate engine speed.
Cause: ECM detects the throttle signal frequency is greater than or less than 150Hz 2000Hz
time of 2s.
system response: ECM will record fault code, fault code can be viewed on the display
module or .ECM ET throttle position are marked as invalid data.
In one of the following occurs before the recent diesel engine speed to maintain the desired
speed.
a.ECM receive different engine speed signal from the alternate throttle switch.
b. signals from the entry into force of the throttle switch and hold it for 2s or more.
(2) Excavators fault code 0094-03: the fuel pressure sensor and battery positive open circuit,
short circuit
c 5V sensor supply line and battery positive short-circuit fault code does not currently exist
0262-03;
d.5V sensor power lines and ground short circuit fault code does not currently exist 0262-04;
e. diesel engine is not running or running a diesel engine has been going on for at least 3min.
system response ECM will record fault code, fault code can be viewed on the display
module or ET .ECM will
Fuel pressure is marked as invalid data, and the use of 600kPa pressure as the default.
a ECM reads the signal voltage higher than 4.8V continued 8s;
d.5V sensor power lines and ground short circuit fault code does not currently exist 0262-04;
e diesel engine is not running or running a diesel engine has been going on for at least 3min.
system response ECM will record fault code, fault code can be viewed on the display
module or ET .ECM will
Fuel pressure is marked as invalid data, and the use of 600kPa pressure as the default.
(4) fault code 0100-03: oil pressure sensor and battery positive open / short
Main Symptom
a ECM reads the signal voltage higher than 4.8V continued 8s;
d.5V sensor power lines and ground short circuit fault code does not currently exist 0262-04;
system response ECM will record fault code, fault code can be viewed on the display
module or ET .ECM will
Oil pressure is marked as invalid data, and the use of 600kPa pressure as the default.
Main Symptom
c.5V sensor battery positive supply line and short-circuit fault code does not currently exist
0262-03;
d.5V sensor power lines and ground short circuit fault code does not currently exist 0262-04;
system response ECM will record fault code, can be viewed on the display module or ET oil
pressure fault code .ECM will be marked as invalid data, and the use of 600kPa pressure as
the default.
(6) fault code 0110-03: coolant temperature sensor and battery positive open / short
Main Symptom
Coolant temperature is marked as invalid data and the use temperature 90 as defaults.
Main Symptom
system response BCM will record fault code, can be viewed on the display module or ET
fault code .ECM coolant temperature will be marked as invalid data, and the use of
temperature 90 as the default value when the fault code for the current fault codes, diesel
does not go into cold mode.
Comments
comments